2023 FORD F-150 Complaints

Tailgate light bar was replaced under safety recall due to concern of moisture getting into housing. Replacement bar now shows signs of water in light bar after rain storm. Both red and reverse lights are flickering.

The contact owns a 2023 Ford F-150. The contact stated that while driving at an undisclosed speed, the vehicle stalled with the check engine warning light illuminated. The vehicle was able to be restarted. The vehicle was taken to the dealer to be diagnosed, and it was determined that the wiring harness had failed due to rodents chewing on the wires. The contact was informed that the wiring harness needed to be replaced. The vehicle was repaired. The manufacturer was made aware of the failure, and a case was opened. The failure mileage was approximately 8,000.

I was leaving my storage unit on Sunday October 6, 2024 at around 7 pm. I was traveling at 5 mph as I approached the exit gate code box. I stopped at the top of the steep hill by depressing the brake. I rolled down the window so I could put the code in that opens the rolling gate below. As I took my foot slowly off the brake, suddenly the vehicle rapidly accelerated, veering slightly left, the steering wheel locked as I pressed the brake pedal twice more it was unresponsive. We flew like a rocket ship knocking down small trees, 2 light posts with 1 light coming down and breaking passenger side windshield. Continuing crashing through 2 iron water main fixtures and through an iron gate. At the bottom of the hill the truck flew into the air and came to a hard landing, the steering wheel unlocked and we came to a stop quickly as the one pedal finally engaged and the computer screen announced " one pedal engaged". Then announced Power Train Malfunctioned. Also airbags never deployed. Prior to the wild ride, the vehicle was awaiting the overdue WiFi update named Power Train system update and prior to approaching the hill, I had tried twice to turn on the one pedal and got the never before seen message " one pedal failure could not engage". Truck was a total loss and my passenger and I were injured. When I contacted a Ford representative and told them about the incident, I mentioned that there was 2 other incidents of a brief steering wheel lock and rapid acceleration without injury or crash, I was told that I should have brought it in, therefore they were not responsible. The 2 brief incidents left me unsure of what had happened so we thought it was a fluke and without out any computer warnings we paid it no mind.

The contact owns a 2023 Ford F-150. The contact stated while driving 35 MPH, making a right turn and coming to a stop, the check engine and Forward Collision Avoidance warning light were deactivated, and the traction control warning light and other system failure warning lights were illuminated. The contact attempted to depress the brake pedal; however, the brakes failed to respond as needed. The contact coasted down the street and drifted and parked the vehicle. The contact attempted to accelerate; however, after depressing the brake pedal, the vehicle failed to stop as needed. The contact drifted and stopped and turned off the vehicle. The vehicle was towed to the dealer who diagnosed that the electronic brake booster had failed and needed to be replaced. The dealer contacted the manufacturer and opened a case. The vehicle was repaired. The manufacturer was informed of the failure and a case was opened. The manufacturer referred the contact to the NHTSA Hotline to report the failure. The failure mileage was 22,075.

The contact owns a 2023 Ford F-150. The contact stated that due to the Battery Management System (BMS), the vehicle failed to properly charge due to the short distances driven. Due to the cold climate and low usage, the vehicle entered Deep Sleep Mode, leading to the vehicle failing to start. The vehicle was taken to a dealer where a battery test was performed, and it was determined that the battery was in good condition. The manufacturer was notified of the failure, and the contact was referred to the dealer. The manufacturer referred the contact to the NHTSA Hotline to file a complaint. The vehicle was not repaired. The failure mileage was unknown.

While not a safety issue, i would like to lodge a complaint against Ford for not including my vehicle's VIN on a NHTSA published recall that it should be eligible for. For 22G06, my 2023 Ford F-150 had the heated steering wheel removed due to the chip shortages. Ford is refusing to either fix or explain why my vehicle is not eligible, even though it meets the "Affected Vehicles" requirements on the document at the below link. [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

The rear axle bolts were both discovered to be broken during a recent tire change. Upon inspection at the dealership it was confirmed that both rear axle bolts had sheared off and had begun to wear the splines of the rear drive axle that would have resulted in loss of ability to maneuver or park the vehicle. The dealership indicated that a recall had been issued for similar previous models of my truck, but my truck was not included in the recall. I am asking for recall 23S65 to be expanded as it obviously did not include all affected vehicles.

The contact owns a 2023 Ford F-150. The contact stated that while driving at various speeds, the vehicle experienced a loss of automotive power and independently shifted into park(P). Several unknown warning lights were illuminated. In addition, the contact stated that the vehicle failed to restart for several minutes and was unable to shift of out park(P). The vehicle was previously taken to a local dealer and the engine control module was repaired; however, the failure persisted. The vehicle remained with the dealer for additional diagnostic testing. The manufacturer was made aware of the failure. The failure mileage was approximately 125,000.

I made a left-hand turn during a snow storm, and the right rear wheel slid and I made contact with the curb at a relatively low speed. The rear right wheel assembly failed and snapped, leaving the wheel assembly 90 degrees to normal. In other words, the wheel went from vertical to horizontal. Upon visual inspection, the axle snapped, and the axle's interior steel looked defective. The axle appeared very coarse, porous, and poorly consolidated. I requested to keep all the parts which are now located in storage. Both the insurance company and the Ford Motor Company dealership seemed to think the axle was defective. Nobody was injured or hurt.

The contact owns a 2023 Ford F-150. The contact stated that while reversing, the back-over prevention camera malfunctioned, and a blank screen was displayed, causing a visibility hazard for the driver. Additionally, the "Brake Fault" message was displayed while at a stop light. The cause of the failure was not yet determined. The manufacturer and local dealer were notified of the failure, but no assistance was provided. The failure mileage was 2,000.