1997 FORD F-150 Complaints

WINDSHIELD WIPERS FAILED DURING RAIN, MANAGED TO PULL OFF ROAD SAFELY. (OTHER ELECTRICAL DEVICES FAILED AS WELL) WIPERS NO LONGER WORK. VEHICLE IS OUT OF SERVICE UNTIL REPAIRED. FORD IS AWARE OF PROBLEMS. SEE FORD TECHNICAL SERVICE BULLETIN 98-9-13 AND FORD SPECIAL MESSAGE #15773 . *TR

I RECENTLY PURCHASED A 1997 FORD F-150. I HAD PARKED IT FOR A FEW WEEKS UNTIL I SOLD MY CHEVY TAHOE. WHEN I WENT TO START IT THE BATTERY WAS DEAD. I CHARGED THE BATTERY AND WHEN I RECONNECTED IT I WENT IN THE CAB AND COULD SMELL BURNING PLASTIC AND ALL THE LIGHTS ON THE DASH WERE ON, EVEN THOUGH THE KEY WAS IN MY HAND. I LOOKED UNDER THE DASH AND FOUND THAT THE GEM MODULE WAS SIZZLING AND SMOKING. I QUICKLY GOT OUT AND DISCONNECTED THE BATTERY. I HAVE NO DOUBT THAT IT WOULD HAVE STARTED ON FIRE HAD I NOT NOTICED IT IN TIME. IT SURPRISED ME THAT NO FUSES WERE BLOWN. I LOOKED ONLINE AND FOUND THAT THIS IS A VERY COMMON THING FOR ALOT OF 1997 - 2003 FORDS AND WAS WONDERING WHY THIS HASN'T BEEN RECALLED. I WORKED FOR A CHEVY DEALERSHIP IN MARQUETTE MI SO I KNOW A LITTLE ABOUT RECALLS AND I FEEL THAT THIS IS VERY UNSAFE AND IT SHOULD NOT BE AN EXPENSE PUT ON THE CONSUMER. I THINK THAT WITH THE DECLINE IN SALES FOR THE AMERICAN AUTOMAKERS THEY SHOULD BE TAKING CARE OF THESE FAULTY MODULES. I AM CURRENTLY IN THE PROCESS OF REPLACING IT SO IM NOT SURE HOW MUCH IT WILL COST ME BUT IM EXPECTING IT TO BE BETWEEN $120- $160. *TR

TL*THE CONTACT OWNS A 1997 FORD F-150. THE VEHICLE HAS CHAPARRAL AP TIRES, SIZE LT265/75R16. THE CONTACT STATED THAT THE VEHICLE WAS SHAKING SEVERELY. THE DEALER ATTEMPTED TO BALANCE THE TIRES, BUT WAS UNSUCCESSFUL. THE VEHICLE WAS TAKEN TO ANOTHER DEALER AND THEY STATED THAT THE TIRES WERE OUT OF ROUND. THE CONTACT WAS REFERRED TO A THIRD DEALER AND THEY LOADED DOWN THE TIRES WITH WHEEL WEIGHT. THE MANUFACTURER REFERRED HIM TO ANOTHER DEALER AND THEY STATED THAT THERE WAS A SERIOUS DEFECT WITH THE TIRE. THE FAILURE MILEAGE WAS 124,000. UPDATED 11-25-08 *BF UPDATED 11/26/08*JB

I WAS ON MY WAY HOME FROM WORK AND MY BRAKE LIGHT CAME ON SO WHEN I GOT HOME I STARTED TO CHECK TO SEE WHAT THE PROBLEM COULD BE AND FOUND A FUSE THAT WAS BROKEN. I REPLACED THE FUSE AND THREE HOURS LATER WE SMELLED SMOKE IN OUR HOUSE AND FOUND MY SHOP WAS ON FIRE. WE CALLED THE FIRE DEPARTMENT AND AFTER THE FIRE WAS OUT FOUND THAT THE TRUCK WAS THE CAUSE OF THE FIRE. *TR

BOUGHT 97 FORD F-150 TRUCK FROM PRIVATE PARTY.. IT HAD RECALL ON IT WAS NOT TOLD ABOUT IT AND MY TRUCK ENGINE CAUGHT FIRE WHILE THE CAR WAS OFF AND HAD BEEN OFF FOR ABOUT AN HOUR. *TR

TL*THE CONTACT OWNS A 1997 FORD F-150. THE VEHICLE CAUGHT FIRE IN THE DRIVEWAY. THE DEALER ADVISED THE CONTACT TO BRING IN THE VEHICLE FOR REPAIR. THE DEALER CALLED BACK AND STATED THAT THE LEGAL DEPARTMENT DID NOT APPROVE THE REPAIR OF THE VEHICLE. THEY FURTHER STATED THAT THEY SENT THE CONTACT A RECALL NOTICE, BUT HE CLAIMED THAT IT WAS NOT RECEIVED. THE CONTACT STATED THAT THEY SENT THE NOTICE TO A DIFFERENT MAILING ADDRESS, WHICH IS WHY IT WAS NOT RECEIVED. THE NHTSA CAMPAIGN ID NUMBER WAS UNKNOWN. THE FAILURE AND CURRENT MILEAGES WERE 175,000.

TL*THE CONTACT OWNS A 1997 FORD F-150. THE CONTACT STATED THAT THERE WAS A WATER LEAK IN THE FRONT WINDSHIELD OR A FIREWALL THAT CAUSED ELECTRICAL DAMAGE TO THE FUSE BOX OR THE GEM MODULE. THE FAILURE OCCURS DURING THE RAIN. WHILE DRIVING AT ANY RPM, THE FUSE BOX WOULD SHORT OUT. THE WARNING LIGHTS ON THE INSTRUMENT PANEL WOULD FLASH INTERMITTENTLY AND THE VEHICLE WOULD NOT ACCELERATE. THE VEHICLE WAS REPAIRED, BUT THE FAILURE STILL PERSISTS. THE FAILURE MILEAGE WAS 121,000. UPDATED 3/5/09 *CN THE WINDSHIELD WAS REPLACED AND NO LONGER LEAKS. AN IMPROPER SEAL WAS THE CAUSE OF THE LEAKAGE. UPDATED 03/10/09. *JB

TL*THE CONTACT OWNS A 1997 FORD F150. THE VEHICLE CAUGHT FIRE WHILE PARKED IN THE DRIVEWAY. THE VEHICLE WAS DESTROYED. A REPORT FROM THE FIRE DEPARTMENT WILL BE AVAILABLE. A CASE NUMBER WAS OBTAINED AND POLICE REPORT NUMBER PD080825409115 WAS FILED. THE CAUSE OF THE FAILURE WAS LISTED AS THE VEHICLE SPEED CONTROL. THE FAILURE MILEAGE WAS UNKNOWN.

DEFECTIVE ENGINE THAT CAUSES THE INTAKE MANIFOLD GASKET TO LEAK COOLANT INTO THE ENGINE OIL. I HAVE HAD THIS REPLACED TWICE AND AM NOW IN NEED OF IT AGAIN. *TR

TL*THE CONTACT OWNS A 1997 FORD F-150. THE VEHICLE HAS MICHELIN LTXM/S TIRES, SIZE P235/70/R16. THE CONTACT STATED THAT THERE WAS A DEFECT ON THE VALVE STEMS. WHILE DRIVING APPROXIMATELY 60 MPH, BOTH PASSENGER SIDE TIRES DEFLATED. THE CONTACT REDUCED THE SPEED AND PROCEEDED TO THE SHOULDER OF THE HIGHWAY. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC AND THEY STATED THAT THE FAILURE WAS RELATED TO BOTH VALVE STEMS. THE TECHNICIAN REPLACED THE VALVE STEMS ON THE TIRES. THE CONTACT WAS VERY CONCERNED OF THE SAFETY RISK INVOLVED WITH THE VALVE STEM DEFECT. THE TIRE FAILURE MILEAGE WAS 76,000. THE VEHICLE FAILURE MILEAGE WAS 76,400 AND CURRENT MILEAGE WAS 84,000.