2023 FORD F-150 Complaints

I started receiving notifications that the battery on my 2023 Ford F150 was in battery save mode due to low battery. I called my dealership and set up an appointment. I took in my vehicle and they charged the battery but told us that Ford has an issue with these batteries not holding a charge. He recommended we just run our truck in the driveway for 30 min when this happens. The charge lasted 3 day's, I drive this vehicle multiple times daily and we have taken many trips in it. I have never had a vehicle that the battery will not charge properly and then to be told they know this is an issue but aren't doing anything to fix it is unacceptable.

While traveling North on [XXX] in N. Texas, congested roadway at the time, had to come to an abrupt stop because a vehicle in front of me suddenly hit their brakes. The forward collision system worked as it should, the icon popped up on the display and the vehicle started braking. One morning as I prepare to pull out of my driveway, vehicle facing North, the forward collision icon is on the dash with a diagonal line through it. I wasn't sure what that meant so I looked it up and it meant that something was blocking the sensor. Happened to be dirt from recent dust storm with rain so there was a spot that the windshield wipers cant reach therefore the sensor was blocked. Cleaned it off no more icon on the dash. Traveling West on [XXX] in West Texas, the icon appears on the dash once again with the diagonal line through it. The closest vehicle to me was around 3 quarters of a mile in front of me so there was no danger of a front collision. I noticed that as I passed under an overpass the icon disappeared but as soon a I exited the overpass the icon reappeared. Once the sun reached a certain point in the horizon when setting, the icon went off for good. This has also happened when driving in town and I am heading home form work. traveling West into the setting sun. Without a doubt if the sun is in a certain point on the horizon when setting, it will block or blind that sensor however you wish to describe it, and that safety feature will be temporarily inoperable until the sun sets lower. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

My Ford F150 was hit by another vehicle going at least 45 mph on the passenger which push my vehicle into another vehicle. However, the airbags was never deployed which cause injury to my right side from steering wheel.

I am writing to request assistance regarding the Customer Satisfaction Bulletin published by NHTSA, titled "Heated Steering Wheel Performance Upgrade 22G06": [XXX] I purchased a 2023 Ford F-150 Tremor from Ryan Ford in Sealy, TX, as a custom order with a build date of December 2022. While I originally paid for a heated steering wheel as part of the vehicle's configuration, this feature was removed during production due to supply chain issues. The omission is noted on my vehicle’s window sticker. Upon reviewing the 22G06 bulletin, I understand that certain F-150 vehicles, including those built in December 2022 at the Dearborn plant, qualify for the upgrade. Based on this information, my truck appears to meet the eligibility criteria outlined in the bulletin. I initially contacted my sales agent at Ryan Ford to arrange the upgrade but was informed that my truck is not eligible and was directed to contact Ford Customer Service. When I reached out to Ford Customer Service, I was advised to contact NHTSA, as Ford is unable to consider adding my truck to the VIN list for eligibility without NHTSA approval. This back-and-forth has left me without a clear resolution or pathway forward. Could you please clarify why my vehicle is deemed ineligible for this upgrade, despite seemingly meeting all the stated criteria? Furthermore, I would appreciate your guidance on how I can ensure my dealership completes this upgrade, considering my vehicle's apparent qualifications. Thank you for your attention to this matter. I look forward to your response. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

The instrument cluster failed to present information upon start up. Multiple restarts did not resolve the issue.

The contact owns a 2023 Ford F-150. The contact stated while driving 70 MPH, the transmission downshifted to second gear unexpectedly, causing the rear wheels to squeal. There was no warning light illuminated. The contact pulled to the side of the road temporarily. The contact stated resumed driving at highway speeds; however, the failure recurred, and the vehicle downshifted to 2nd gear. The contact was able to drive to the nearby dealer, where the vehicle was being diagnosed. The vehicle was not diagnosed or repaired. The manufacturer was notified of the failure. The failure mileage was approximately 20,000.

The contact owns a 2023 Ford F-150. The contact stated while driving 55 MPH on a flat road surface, the vehicle made an abnormal exploding sound, and the contact noticed that the panoramic sunroof rear glass panel had shattered without impact. The contact stated that the shattered glass did not fall into the interior of the vehicle because the sunroof interior canvas cover was closed. The contact pulled over to the side of the road and assessed the damage. The vehicle was driven to the nearest dealer, where it was determined that the panoramic sunroof rear glass panel needed to be replaced. The dealer informed the contact that the autobody repair department would perform the extensive repair. The vehicle was not repaired. The manufacturer was notified of the failure and declined to cover the repair under warranty. The failure mileage was approximately 29,000.

The rear axle bolts - both - were sheared. Specifically, the bolt head and a portion of the bolt shaft were loose within the small hub cap that covers the axles. I was unaware that either bolt had failed. The failure was discovered on [XXX] when I took the vehicle into a Ford dealership for an oil change tire rotation. I was waiting for the service to be completed. The service advisor, Rocky Garcia, approached me and informed me that one of the rear axle bolts had sheared, and the vehicle was unsafe to drive. At my request he returned with one fairly large bolt head with a shaft that had clearly sheared. He said that this was not the subject of a recall, but that it was covered under warranty. When the vehicle was returned to me on Saturday, December 14, 2024 I learned from the invoice that both rear bolts had failed. The invoice states that both rear "axle shafts" were replaced. The vehicle was manufactured in July or August of 2024 and falls outside of the recall that exists for 2023 Ford F-150 with the Trailer Tow Max Package, Ford reference No. 23S65. A simple internet search reveals Ford has struggled with this same defect for years. The rear axle bolt is a critical component, and it is absurd that in 2023, Ford is struggling with using a bolt of sufficient strength. As I am reminded every time I start the vehicle, the Ford F series was in its 75th year in 2023. One would think that developing an axle bolt of sufficient strength after 75 years would not be hard. I have towed a camper approximately 10 times since the purchase of the vehicle in August 2023. The camper, fully loaded, weighs at most 3,600 lbs. The sheared bolt was retained by Covert Ford in Austin, TX. I felt no change in the handling of the vehicle at any time, there were no warning lamps, etc., and heard no noise.

Sunroof BLOWUP. It didn't break: IT BLOW UP. Explosion was LOUD; DISORIENTING ; CONFUSING. It put vehicle, me and passagers at risk. Reson for the glass exploding are not clear. I was doing nothing that would cause it to happen. Not a use in time of explosion. No know stressers. No weather caused reasons in happening. IT EXPLODED for no know reason.

The contact owns a 2023 Ford F-150. The contact stated while driving at an undisclosed speed, the accelerator pedal was depressed; however, the vehicle failed to accelerate as intended. The contact stated that the transmission shifted hard while accelerating. The vehicle was taken to two dealers; however, the failure was not duplicated. The vehicle was not diagnosed or repaired by an independent mechanic or the dealer. The manufacturer was made aware of the failure and a case was filed. The contact was advised to contact the NHTSA Hotline to report the failure. The failure mileage was 800.