1997 FORD F-150 Complaints

CHECK ENGINE LIGHT CAME ON AND WHEN MECHANIC SERVICE VEHICLE HE INFORMED ME THAT COOLANT HAS LEAKED INTO THE NUMBER FOUR CYLINDER AND THAT THIS ENGINE HAS A HISTORY OF HEAD GASKET FAILURES. HE CAN REPLACE GASKET BUT BELIEVES THAT THIS WOULD ONLY BE A TEMPORARY FIX. HE WOULD BE WILLING TO REPLACE GASKET FOR $1600 BUT HE CAN NOT GUARANTEE RESULTS, A REPLACEMENT ENGINE WOULD COST APPROX. $4800. AFTER RESEARCHING THIS ISSUE ON THE WEB IT HAS BECOME APPARENT TO ME THAT FORD HAS LONG KNOWN OF THIS PROBLEM BUT HAS FAILED TO TAKE ANY ACTION TO REMEDY THIS SITUATION. *JB

TL*THE CONTACT OWNS A 1997 FORD F-150. THE CONTACT STATED THAT THE WIRING HARNESS CAUGHT FIRE UNDER THE HOOD. FORD STATED THAT HE WOULD BE RESPONSIBLE FOR THE REPAIRS. HE BEGAN RECEIVING RECALL LETTERS REGARDING THE WIRING HARNESS IN 2004. THE CONTACT HAS BEEN IN TOUCH WITH FORD CONCERNING REPAIRS AND/OR REIMBURSEMENT. THE RECALL NUMBER WAS UNKNOWN. THE CURRENT AND FAILURE MILEAGES WERE 52,660. UPDATED 12/12/2007 *BF

MY F150 XLT 4.2L ENGINE HAD BEEN OPERATING NORMALLY PRIOR TO 9/21/07. THE TRUCK WAS SITTING AT HOME AND HAD NOT BEEN DRIVEN FOR APPROXIMATELY ONE WEEK WHEN I WENT TO DRIVE IT. AS I CRANKED IT, THE ENGINE SUDDENLY BEGAN MAKING A VERY LOUD CLATTERING NOISE. I IMMEDIATELY SHUT OFF THE ENGINE AND OPENED THE HOOD TO SEE IF SOMETHING WAS HITTING THE FAN BLADE OR SOME SIMILAR EVENT. AFTER INSPECTING THE ENGINE COMPARTMENT AND DISCOVERING NOTHING UNUSUAL VISUALLY, I AGAIN STARTED THE ENGINE AND AGAIN THE SAME HORRIBLY LOUD NOISE CONTINUED. I WAS TOLD BY AN AUTO MECHANIC WHO LIVES NEARBY THAT THE NOISE SOUNDED LIKE A ROD "KNOCK" CAUSED BY CATASTROPHIC ENGINE FAILURE. AFTER LEARNING OF THE 99B29 RECALL ON THIS 4.2 ENGINE FOR FRONT GASKET DEFECTS THAT CAUSE COMPLETE ENGINE FAILURE IF NOT STOOPED IN TIME, I CONTACTED THE ORIGINAL OWNER AND LEARNED THAT HE HAD NEVER BEEN NOTIFIED OF ANY SUCH RECALL, AND HE SPECIFICALLY STATED THAT ANYTIME HE WAS NOTIFIED OF A PROBLEM HE ALWAYS TOOK THE VEHICLE TO THE DEALER AS INSTRUCTED. IN FACT, HIS FATHER WORKED AT A FORD DEALERSHIP AND HIS FATHER SOLD HIM THE TRUCK AND HE STILL HAD NO KNOWLEDGE OF ANY SUCH RECALL. I HAD RECENTLY ADDED ENGINE COOLANT TO THE RESERVOIR BEFORE THE ENGINE FAILURE BECAUSE IT WAS VERY LOW, BUT I DISCOVERED NO LEAKS ANYWHERE NOR ANYTHING ELSE UNUSUAL SO THERE WAS NOTHING APPEARING OUT OF THE ORDINARY. THE ENGINE IS NOW RUINED DUE TO THE FAULTY GASKET BECAUSE THE VEHICLE OWNER WAS NEVER NOTIFIED OF THE DEFECTIVE CONDITION. IN FACT, THE ORIGINAL OWNER TOOK THE VEHICLE TO A FORD DEALERSHIP MORE THAT ONE YEAR AGO ON MAY 18, 2006 FOR AN ELECTRICAL RECALL (05S28, CRUISE CONTROL) AND THEY SHOULD HAVE AND COULD HAVE ALSO FIXED THE DEFECTIVE GASKET AT THAT TIME, WHICH WOULD HAVE PREVENTED MY TOTAL ENGINE FAILURE FROM EVER HAPPENING... BUT THEY DIDN'T. FORD'S FAILURE TO FIX ALL RECALLED DEFECTS ON 5/18/06 WAS INEXCUSABLE. FORD OWES ME A NEW ENGINE! *JB

1997 F150 4.2L ENGINE FAILURE. *JB. UPDATED 01/11/08. *LJ THE ENGINE MAIN BEARINGS, LOWER ENGINE GASKET AND TIMING BELT GASKET COVER WERE REPLACED. UPDATED *JB

'97 F150 4.2 V8 COOLANT LEAK, ENGINE BLOWN @ 140,000 AFTER SEVERAL HEAD GASKET REPAIRS. *JB

I HAD MY SPARK PLUGS REPLACED TWICE AT $541 DOLLARS AT A FORD DEALERSHIP BECAUSE THEY WERE "CORRODED". UPON TAKING IT SOME PLACE ELSE GOODYEAR TO BE SPECIFIC THEY PULLED UP A FACTORY RECALL ON FORD F150 FROM 97 BECAUSE A GASKET LEAKS COOLANT ONTO THE SPARK PLUGS CAUSING CORROSION. EMPIRE FORD NEVER EVEN GAVE ME A REASON FOR THIS, JUST KEPT CASHING THE CHECKS, NOW THEY ARE SAYING MY VIN NUMBER WAS NEVER INCLUDED, BUT I HAVE THE SAME PROBLEM AS THOSE RECALLED, COINCIDENCE, IMPOSSIBLE. *JB

TL*THE CONTACT OWNS A 1997 FORD F-150. THE CONTACT STATED THAT A ROD PUNCTURED THE OIL PAN AND RUINED THE ENGINE. THE VEHICLE IS UNABLE TO BE DRIVEN AND HAS NOT BEEN TO THE DEALER. HE HAS DISCOVERED SEVERAL OTHER PEOPLE WHO HAVE EXPERIENCED THE SAME FAILURE. THE VIN, SPEED, AND MILEAGE INFORMATION WERE UNAVAILABLE.

AT 1:50A.M. ON 8/1/2007 OUR 1997 FORD F150, WHICH WAS UNDER RECALL, BURNED IN OUR DRIVEWAY. DAMAGE WAS ALSO DONE TO 2 OTHER VEHICLES, OUR HOME, DRIVEWAY, AND BASKETBALL GOAL. *TR

VEHICLE WAS PARKED IN DRIVEWAY WITH DOORS LOCKED AND IGNITION IN THE OFF POSITION. NO ONE WAS NEAR OR IN THE VEHICLE. LOOKED OUT WINDOW AND NOTICED WHAT LOOKED LIKE MIST FROM A WATER SPRINKLER FROM THE FRONT SIDE OF TRUCK. LOOKING CLOSER, I REALIZED IT WAS SMOKE AND THEN SAW FLAMES FROM THE TIRE WELL AND UNDER THE HOOD BY THE WINDSHIELD WIPERS. CALLED 911. THE FIRE DEPARTMENT ARRIVED VERY QUICKLY, PUTTING THE FIRE OUT. THEIR ASSESSMENT WAS IT WAS AN ELECTRICAL SHORT WHICH HAD CAUSED THE FIRE. THE FIRE CAUSED THE HOOD HYDRAULIC LIFT TO EXPLODE LIKE A ROCKET, HITTING THE WINDSHIELD, CRACKING IT AND THEN SHOOTING OFF INTO THE YARD. THE FRAMES INSIDE THE ENGINE HOUSING BY THE DRIVERS TIRE BURNT THE HOUSING COMPLETELY AWAY. THE WIRING HAS BEEN COMPLETELY BURNED AND MELTED AWAY INSIDE THE ENGINE COMPARTMENT. ALL THE PLASTIC FLUID CONTAINERS MELTED, THE ENTIRE ENGINE HOUSING, ENGINE AND ALL ELECTRICAL COMPONENTS UNDER THE HOOD WERE BURNED UP OR DAMAGED IN SOME WAY BY THIS FIRE. THE TRUCK WILL NOT START OR RUN. NONE OF THE LIGHTS WORK, RADIO, HEAT, AIR OR POWER FUNCTIONS WORK. THE TRUCK IS TOTALLY INOPERABLE. I CONTACTED THE INSURANCE COMPANY AND THEY DIRECTED ME TO THIS SITE TO LOOK FOR FIRE RELATED DEFECTS AND TO FILE A COMPLAINT. THE TRUCK HAS NOT BEEN REPAIRED AS IT IS BEYOND REPAIR SINCE ALL THE WIRING AND MOST OF THE INSIDES UNDER THE HOOD HAVE BURNED UP OR MELTED. *JB

PURCHASED A 1997 FORD F-150 IN EARLY SPRING OF 2006. VEHICLE HAD LESS THAN OR CLOSE TO 100,000 MILES. DROVE THE VEHICLE BETWEEN 1,000 AND 2,000 MILES OVER THE NEXT YEAR. IN LATE MARCH OR EARLY APRIL OF THIS YEAR THE VEHICLE'S ENGINE, A 4.2 L 6 CYLINDER MOTOR SELF DESTRUCTS. ON THE MORNING IN QUESTION, I WENT OUT AND ATTEMPTED TO START THE VEHICLE. THE MOTOR TURNED OVER VERY SLUGGISHLY AS IF THE BATTERY WAS LOW. WHEN THE MOTOR STARTED, IT MADE A TERRIBLE RACKET AND BLEW A CHUNK OF THE ENGINE BLOCK OUT APPROXIMATELY THE SIZE OF MY THUMB. AFTER THIS HAPPENED, I RESEARCHED THE PROBLEM ON THE INTERNET ONLY TO FIND THAT 1997 4.2 L FORD MOTORS HAVE A DEFECTIVE GASKET WHICH ALLOWS WATER TO FLOW INTO THE CYLINDERS. THE GASKET HAD FAILED AND ALLOWED WATER TO LEAK INTO THE CYLINDER(S) OVERNIGHT CAUSING THE VEHICLE TO HYDROLOCK AND "BLOW UP". FORD HAS BEEN AWARE OF THIS PROBLEM FOR MANY YEARS, AND EVEN SENT OUT NUMEROUS TECHNICAL SERVICE BULLETINS REGARDING THE PROBLEM. I HAVE EVEN FOUND EVIDENCE THAT THEY MAY SENT OUT A FEW RECALL NOTICES, BUT NOT TO EVERY OWNER. HUNDREDS OF '97 F-150 OWNERS HAVE HAD THIS SAME PROBLEM, AND THEY, LIKE ME, CANNOT AFFORD TO PAY THE APPROXIMATELY $5,000 TO REPAIR THEIR MISTAKE. I CURRENTLY OWE ABOUT $5,000 ON THIS VEHICLE, WHICH AT THIS TIME IS ONLY AN EXPENSIVE LAWN ORNAMENT. FORTUNATELY, THERE WAS NOT FIRE OR INJURIES WHEN THIS OCCURRED, BUT THEY COULD HAVE. I'M CERTAIN THAT FORD NEVER REPLACED THE GASKET ON THIS VEHICLE, AS THE ONLY RECALL "STICKER" IS ONE FOR THE ENGINE COMPUTER. AS FOR BEING TOO OLD TO BE RECALLED, SEVERAL MONTHS AFTER I PURCHASED THE VEHICLE, I RECEIVED A RECALL NOTICE FOR A WIRING PROBLEM ON IT. CERTAINLY FORD SHOULD ISSUE A RECALL, OR AT LEAST PAY TO HAVE THE PROBLEM FIXED. THE INCIDENT DATE IS ONLY APPROXIMATE, AS I CANNOT RECALL THE EXACT DAY THAT IT HAPPENED. *TR