2023 FORD F-150 Complaints

Dealer identified Water intrusion into the rear wiring, harnesses is causing corrosion in the PIN connectors, which therefore leads to flickering tail lights which could be mis interpreted as braking or a turning. I also experienced random acceleration from slow speeds and a failure to decelerate. [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

driving approximately 20 miles an hour, gently applying the brake as I was approaching a stoplight when the brake suddenly engaged forcefully causing the car to jerk to a stop unexpectedly. There was a warning across the dash that said " forward collision is not available" and that disappeared. A local dealership said this was an ABS issue and reprogrammed it.

This vehicle is a BEV with regenerative braking. At various times while driving, when the regenerative braking is engaged, the brake lights illuminate to indicate to other drivers that the vehicle is slowing down. The problem is there is no indication inside the vehicle for the driver to know when the brake lights are on. This seems like a potential safety hazard. The driver can feel the effects of the regenerative braking and knows the vehicle is slowing but does not know when the slowing is enough to illuminate the brake lights.The driver's only option to ensure the brake lights are activated is to apply additional braking via the brake pedal but additional braking may not be the safest action to take in some situations. Depending on traffic, weather, and road conditions it would be safer for the driver to know when their brake lights are illuminated.

2023 Ford F-150 Lightning ER Platinum Ford Case Number: [XXX]  VIN: [XXX]  Failed: Battery overheated far beyond safety limits. No indication on dash. Safety: When it was finally checked, 3 sensors reported temps of 399, 419, and 419F. The service manager verified the temps. A photo of the diagnostic screen is available. These temps made a battery fire a significant possibility putting myself and others on the road around me in danger. The car is at the dealer in Hays, KS being looked at. There was no indication on the dashboard that there was any problem. According to information I have uncovered, these temperatures are over 3x the safety limits specified by FORD. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

The contact owns a 2023 Ford F-150. The contact received notification of NHTSA Campaign Number: 25V512000 (POWER TRAIN); however, the part to do the recall repair was not yet available. The dealer was contacted and informed the contact that parts were on backorder. The contact was concerned that the failure might occur while driving in an area where there was no phone service as the residence was in the countryside. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the issue and confirmed that parts were on backorder. The contact had not experienced a failure.

Hello, My range should be 320 mph on my F150 lightning. It is 226 fully charged was lower the last charge. This effects safety, time and money wheh traveling. I took it to the dealer and they said that there is nothing they can do. That I should run the range down to zero miles and that should reset the range. That didnt work. I have had several propulsion proplems. So many that I won a Lemon law suit. According to the NHTSA the range loss is tied to the systematic battery or drivetrain defect and ford refuses to honor my warranty and my extended warranty or address a potiential safety hazzard.

The driver's side rear light is full of moisture and some water. It is available for inspection. The Ford dealership in Beeville Texas Coastal Bend Ford inspected it already and informed me that it would cost $1,400 to replace and that it was only going to get worse. They also informed me that Ford allows a certain percentage of moisture and water to be in there safely. When you see the pictures this is definitely unacceptable and unsafe. This is causing the reverse lights to flicker intermittent. The moisture accumulation inside the lights can result in inoperative or flickering reverse lamp function. Inoperative reverse lamps may reduce the awareness of other motorists or road users of the driver's intention to operate the vehicle in reverse gear increasing the risk of injury or crash. I bought the vehicle from a Ford dealership in Austin Texas less than 10 days ago. I reported it to them and they stated it wouldn't be covered under warranty. The best assessment in my opinion of cause is going to be microcracks in the outer lens. Because my truck is a 2023 Ford F-150 King Ranch, and there is a known recall for the same issue for 2022-2023 Lariat and Platinum models, so this can't be a coincidence. Refer NHTSA recall number 23V-418

I am writing to formally report a concern regarding excessive rear brake wear on my 2023 Ford F-150 Lightning. My vehicle currently has approximately 21,000 miles, and I have been informed that the rear brake pads and/or rotors require replacement significantly earlier than would be expected under normal driving conditions. Given that the F-150 Lightning utilizes regenerative braking technology, I expected brake component wear to be substantially reduced compared to conventional vehicles. Vehicle Information: Owner: [XXX] Model: 2023 Ford F-150 Lightning VIN: [XXX] Current Mileage: 21,000 miles Selling/Servicing Dealer: Shultz Ford Date of Purchase: December 2023 I am concerned that the level of rear brake wear may indicate a defect, design issue, or improper brake system operation. I respectfully request that Ford review this matter and determine whether this condition is covered under warranty, subject to a Technical Service Bulletin, or associated with any known issues affecting this model. Please advise what diagnostic steps Ford recommends and whether assistance with repair costs may be available. I would also appreciate information regarding any similar complaints, investigations, or known issues related to excessive rear brake wear on the 2023 F-150 Lightning. Thank you for your attention to this matter. I look forward to your response and a timely resolution of this concern. Sincerely, [XXX] [XXX] [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

2023 Ford F-150 Lightning, VIN [XXX], 42,370 mi. The rear light bar has microcracks allowing moisture intrusion. Water droplets are visible inside the red lens across the tailgate and inside the white reverse lamp (photos attached, taken 5/30/2026). This is the warning condition named in recall 25SB6 (NHTSA 25V731) and predecessor 23S30 (NHTSA 23V418): water droplets in the lightbar outer lens, which can cause inoperative or flickering reverse lamps. On 6/15/2026 I took the truck to Koons Baltimore Ford, 6970 Security Blvd, Baltimore MD 21244, Advisor Rahim King, RO [XXX]. The dealer's own repair order Line B states: RECALL 25SB6 REVERSING LAMP INSPECTION, VERIFIED OPEN RECALL, at $0 warranty pay. After verifying the open recall on this VIN, the dealer still refused to replace the moisture-failed light bar under the recall. Instead, they have charged me $190 customer-pay to check and advise on water in the red bar and white reverse light, the identical defect the recall fixes for free. The dealer also tried to bill my third-party extended service plan and told me to file an auto insurance claim. All three are improper: a federal recall remedy must be provided free by the manufacturer (49 USC 30120), not charged to the customer, an insurer, or a service contract. SAFETY RISK: A truck backing up without working reverse lamps is more likely to strike a pedestrian or a child below the driver's sightline, since others are not alerted the vehicle is reversing. Reverse lamps are federally required. This failure can result in serious injury or death. REQUEST: Please document (1) the recurring light bar moisture and reverse-lamp defect, (2) the dealer's refusal to remedy a verified open recall free of charge, (3) the improper $190 diagnostic charge, and (4) attempts to shift recall cost to the customer, a service contract, and auto insurance. I can provide RO [XXX] and photos. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

Today 6/18/2026 I was stopped at a stoplight and the engine cut off as if often does and when the light changed and I stepped on the gas instead of restarting the car went into park and remained off until I restarted the truck. This is similar to the safety issue built into the truck if stopped and the front door is opened the truck automatically goes into park. This is the second time it has happened in the past year- the truck being stopped at a light and the engine stops running and when I step on the gas instead of restarting it has gone into park.