2006 FORD F-150 Complaints

CRASH ON FREEWAY, CAR HIT ME, CAR HIT CENTER DIVIDER, MADE ME FLIP DOWN THE FREEWAY. AIR BAGS DID NOT GO OFF. CAR IS TOTALED. *TR

I REPORTED MY CATALYTIC CONVERTERS WENT BAD TO RICHMOND FORD LLC. I HAVE A 2006 FORD F-150 XLT WITH 44,000 MILES. THE SERVICE MANAGER INFORMED ME THAT THE 3 YEAR, 36,000 MILE FACTORY WARRANTY WAS PAST. IT WAS DURING A ROUTINE STATE INSPECTION MY MECHANIC FOUND THE ISSUE. I AGAIN CALLED MY MECHANIC. HE INFORMED THAT THERE IS AN 8 YEAR 80,000 MILE FEDERAL EMISSIONS WARRANTY. I AGAIN CALLED RICHMOND FORD LLC. SPOKE WITH THE SERVICE MANAGER, HE TOLD ME THAT THERE WAS NO SUCH WARRANTY. I HAD TO TAKE MY TRUCK TO A LOCAL EXHAUST SPECIALIST. IT TOOK A WEEK AND OVER $2000 TO REPAIR MY TRUCK. I CALLED FORD MOTOR COMPANIES CUSTOMER CARE LINE. THEY INFORMED ME THERE WAS A FEDERAL EMISSIONS WARRANTY AND IT WAS FOR 8 YEARS OR 80,000 MILES. NOW I AM OUT $2000 AND I AM FIGHTING WITH FORD TO RECOVER MY EXPENSES, LOST TIME FROM WORK WITH NO SUCCESS CAN YOU ASSIST OR PROVIDE ME WITH ANY CONTACT INFORMATION TO ASSIST ME IN THIS MATTER. YOUR ASSISTANCE WOULD BE GREATLY WELCOME. *TR THANKS, BRIAN M DOUGHERTY

TL*THE CONTACT OWNS A 2006 FORD F150. WHILE DRIVING APPROXIMATELY 20 TO 25 MPH ON NORMAL ROAD CONDITIONS A LOUD NOISE EXPELLED FROM THE STEERING WHEEL. THE DRIVER EXERTED HIGHER EFFORT TO TURN THE STEERING WHEEL AND WAS ABLE TO CONTINUE DRIVING WITH CAUTION. THERE WERE NO WARNING LIGHTS ILLUMINATED ON THE INSTRUMENT PANEL. THE CONTACT STATED THAT HE WOULD PERFORM THE REPAIRS ON THE VEHICLE. THE CONTACT IS AWARE OF THE SAFETY RISK INVOLVED. THE FAILURE AND CURRENT MILEAGES WERE 62,000. UPDATED 10/13/09. *LJ THE CONSUMER STATED A POWER STEERING PUMP SHOULD FAIL ON A 3 YEAR OLD VEHICLE. UPDATED 10/15/09

PLEASE SEE ODI#10278394. COMPLAINT CONTINUED. TRUCK TAKEN TO GARAGE TO BE FIXED IN JANUARY 09 BECAUSE OF VIBRATION IN STEERING FROM BRAKES. OCT, GUARANTEE RUN OUT, AND BRAKES STILL NOT FIXED. VIBRATION CONTINUED. ORDERED NEW PERFORMANCE ROTORS AND PADS. UPON INSTALLATION OF THESE ITEMS I INSPECTED CALIPERS AND FOUND CRACKS AND CHIPS IN CYLINDER PLUNGERS WHICH CONNECT TO PUSH THE PADS. I WOULD SAY THIS CAME FROM CONSTANT VIBRATION OF THE FRONT BRAKES WHICH FORD DID NOT FIX FOR EIGHT MONTHS. THE CENTER PLUNGER OF THESE CALIPER PISTONS ARE MADE OF A FIBER BOARD WHICH WILL NOT STAND UP TO VIBRATION, FIBER BOARD IS A VERY HARD AND BRITTLE MATERIAL WHICH IS GOOD FOR HEAT AND WEAR BUT NOT VIBRATION. CALIBERS HAVE TO BE REPLACED. OF COURSE AT MY EXPENSE. TRUCK IS UNDRIVEABLE AND THIS CONDITION CAN CAUSE A VERY SERIOUS ACCIDENT AND DEATH IF BREAKDOWN OF THIS FIBER BOARD TYPE MATERIAL SHOULD FAIL WITHOUT NOTICE. YOU WOULD COMPLETELY LOSE YOUR CONTROL AND BRAKES. *TR

MY 2006 FORD F 150 WITH A 4.6 LT V-8 FACTORY INSTALLED SPARK PLUG CAME OUT DAMAGING THE IGNITION COIL AND STARTING A SMALL FIRE. *TR

I PURCHASED FIRESTONE DESTINATION 20 INCH TRUCK TIRES, HAVE ONLY A FEW THOUSAND MILES ON THEM AND THE SIDEWALL BLEW OUT ON THE FREEWAY ALMOST CAUSING A ROLL OVER. *TR

SLOW AIR LEAK IN TIRE. DEALER FOUND A CRACK IN THE INSIDE OF THE WHEEL NEXT TO THE TIRE BEAD. CRACK IS ONLY ON THE INSIDE, VERTICAL FACE OF THE WHEEL. THIS IS THE FIRST TIME FOR THIS FAILURE ON THIS VEHICLE SINCE I OWNED IT. THE SERVICE PERSON OFFERED TO SELL ME A NEW WHEEL. I ASSUME THIS PART IS OEM AND HAS NEVER BEEN REPLACED. I ORDERED THE NEW PART. *TR

STEERING GOT HARD, WOULDN'T RETURN TO CENTER, NEARLY PUT TRUCK INTO DITCH AFTER TURNING OUT OF DRIVEWAY.....THOUGHT POWER STEERING WAS INOP...SEEMS THE COUPLI NG WAS SEIZED UP....DEALER SAID IT HAPPENS ALL THE TIME...I BELIEVE THIS IS A SERIOUS SAFETY DEFECT...IT WAS COVERED UNDER AN EXTENDED WARRANTY, BUT STILL COST ME THE DEDUCTIBLE ,PLUS AS IT WAS FAILING , MY DRIVING PROBABLY SEEMED ERRATIC TO ANYONE VIEWING THE STRUGGLE TO GET VEHICLE STRAIGHTENED OUT AFTER A TURN....I BELIEVE THIS IS A RECALLABLE ITEM.... STEERING DEFECTIVE. *TR

THE INTEGRATED WHEEL END SOLENOID IS PRONE TO WATER FROM THE COWL DRAINING ONTO IT, THUS SHORTING OUT AND ALLOWING THE 4X4 VACUUM SYSTEM TO LOSE VACUUM. WHEN THIS HAPPENS, THE TRUCK'S FOUR WHEEL DRIVE SYSTEM ENGAGES UNEXPECTEDLY AND CAUSES DAMAGE TO THE WHEEL HUBS. ONCE THIS HAPPENS, THE DEALERSHIP COSTS ARE VERY EXPENSIVE, REQUIRING A NEW IWE SOLENOID, VACUUM SYSTEM, AND FRONT HUBS. *TR

TRUCK BEGAN SHUDDERING WHEN BRAKING @ LOW/HIGH SPEEDS. WAS TOLD ROTORS WARPED @ APPROXIMATELY 6,000MI. DEALERSHIP HAD THE ROTORS MACHINED AND THEN ADJUSTED CALIPERS. AFTER DRIVING TRUCK OFF NOTICED BRAKE PEDAL WAS SLIGHTLY SOFTER BUT NO LONGER FELT VIBRATION/SHUDDERING. AT APPROXIMATELY 9,000MI ONCE GAIN FELT SLIGHT SHUDDER/VIBRATION WHEN BRAKING. TOOK TRUCK TO DEALERSHIP WITH APPROXIMATELY 13,000MI AND WAS TOLD ROTORS WERE ONCE AGAIN WARPED. I HAD CERAMIC BRAKES INSTALLED @ APPROXIMATELY 24,000MI AND NEW ROTORS INSTALLED @ APPROXIMATELY 30800MI. WITH THE ROTORS INSTALLED SIGNIFICANT VIBRATION STILL OCCURS WHEN BRAKING AT ANY SPEED. SAFETY CONCERNS FOR SOME TIME NOW. APPARENTLY SHUDDERING NOT DUE TO WARPED ROTORS AS DEALERSHIP SUGGESTED. *TR