1998 FORD F-150 Complaints

CONSUMER'S REQUEST ASSISTANCE IN GETTING FORD TO REIMBURSE THEM FOR REPAIRS FOR FAULTY GASKET ON THEIR 1998 FORD F150 PICKUP TRUCK.*MR WATER LEAKED INTO THE OIL BECAUSE OF A FAULTY GASKET WHICH THEN CAUSED THE ENGINE TO BLOW. THE CONSUMER DID SOME RESEARCH AND FOUND OUT THAT THE GASKET WAS RECALL IN 1999. THE CONSUMER INDICATED THAT HE NEVER RECEIVED AND NOTICE OF A GASKET RECALL. THE CONSUMER REQUEST THAT FORD REIMBURSE HIM FOR THE FAULTY ENGINE. *NM

DT: THE BRAKE PRESSURE SWITCH WHICH WAS OVER THE MASTER CYLINDER ON A 1998 FORD F150 CAUGHT ON FIRE. THIS, IN TURN, CAUSED THE BRAKE FLUID RESERVOIR TO CATCH ON FIRE. IT BURNT TWO FUSES AND UNDER THE WHEEL WELL. THIS HAPPENED WHILE THE VEHICLE WAS OFF, AND IT WAS AT THE MECHANIC. VEHICLE CAUGHT ON FIRE AFTER SITTING FOR A WEEK. THE MECHANIC HAD CHANGED THE MOTOR APPROXIMATELY TWO WEEKS AGO. THE MECHANIC WAS ABLE TO PUT THE FIRE OUT. THE MECHANIC WAS THE ONE WHO DETERMINED THAT CRUISE CONTROL SWITCH CAUSED THE FIRE. THE VEHICLE HAD ALREADY BEEN FIXED. THIS OCCURRED ON JULY 21, 2005. *AK *JB

I HAVE A 1998 FORD F-150. THE VEHICLE WOULD NOT COME OUT OF PARK WHILE IN MY DRIVEWAY. I EXAMINED THE FORD OWNERS MANUAL AND IT ADVISED HOW TO GET THE VEHICLE OUT OF PARK AND TO CHECK THE FUSE TO THE BRAKE LIGHTS. THE BRAKE LIGHTS WERE NOT WORKING AND I REPLACED THE FUSE AS INSTRUCTED AND STARTED THE VEHICLE. IMMEDIATELY I COULD SEE SMOKE COMING FROM THE ENGINE COMPARTMENT. I OBSERVED THE CRUISE CONTROL SWITCH WHICH PLUGS INTO THE MASTER CYLINDER WAS ON FIRE. I PULLED THE WIRE FROM THE MELTED SWITCH AND THE FIRE WENT OUT. NO ACTION HAS BEEN TAKEN AS FORD SAYS MY VEHICLE IS NOT UNDER RECALL. NO DAMAGE OTHER THAN THE SWITCH AND WIRING, I WAS LUCKY. *JB

HEAD GASKET/ HEAD BOLT FAILURE AT 66,000 MILES. MECHANIC REPORTED IT DURING ROUTINE SERVICE. SAID 3 THINGS CAUSE THIS FAILURE. 1. LACK OF COOLANT (OVERHEATING), 2. DEFECTIVE GASKET OR 3. FACTORY DEFECT DURING THE MILLING THE HEAD. MECHANIC REPORTED THIS AS A KNOWN PROBLEM WITH THIS MODEL OF FORD TRUCK. SINCE THE COOLANT LEVEL HAS ALWAYS BEEN MAINTAINED, THAT LEAVES THE OTHER TWO POSSIBILITIES. SINCE THIS VEHICLE IS REGULARLY SERVICED, PROBLEM WAS CAUGHT RIGHT AWAY. NO INDICATION OF PROBLEM BEFORE HAND. NO TSB ISSUED FOR THIS VEHICLE BUT SOME FOR OTHER FORD VEHICLES IN SAME MANUFACTURING YEAR. SEARCHING THE INTERNET FOUND SIMILAR PROBLEMS WITH OTHER FORD 150S' WITH PREMATURE BLOWN HEAD GASKETS. REPAIRS AT FORD DEALER WERE $2300 WITH LITTLE CHOICE TO GO ELSEWHERE. PROBLEMS WITH DEALER IN GETTING REPAIR DONE CORRECTLY, BUT THAT IS A DIFFERENT COMPLAINT. I HAVE SEEN OTHER RECALLS FOR DEFECTIVE HEAD GASKETS OVER THE YEARS, THIS ENGINE SHOULD BE CONSIDERED. *NM

FORD F150 HEAD GASKET LEAKED WATER INTO THE CYLINDER CAUSING BENT RODS.***NO ANSWER REQUIRED***. *MR *JB

I HAVE A 1998 F-150 AT THE BOTTOM OF THE WINDOW MY DOORS ARE SPLITTING AND STARTING TO RUST I KNOW ITS HAPPENING QUITE A BIT I WORK IN THE INDUSTRY AND SEE THIS ON A REGULAR BASIS ALSO THE FORD DEALERS DO HAVE A FIX FOR THIS PROBLEM BUT THE CONSUMER PAYS IT IS NOT COVERED WHY?*JB

DT: CONTACT STATED WHILE DRIVING THE FRONT STRAPS ON THE GAS TANK BROKE, CAUSING THE FRONT TANK TO HIT THE GROUND AND RUPTURE. CONSUMER HAD JUST FILLED THE TANK AND GASOLINE SPILLED OUT ONTO THE HIGHWAY. THE FIRE DEPARTMENT AND THE EMERGENCY MANAGEMENT AGENCY WERE ON THE SCENE WHERE THIS OCCURRED. THERE WAS A REPORT FROM THE EMERGENCY MANAGEMENT AGENCY. CONSUMER CONTACTED THE MANUFACTURER, THEY SAID THERE WERE NO OTHER COMPLAINTS OF THIS NATURE, BUT FOR THE CONSUMER TO KEEP HIS RECEIPTS IN CASE THERE WAS A RECALL. THE VEHICLE WAS TOWED FROM THE HIGHWAY TO A LOCAL SERVICE DEALER. THE SERVICE DEALER STATED THAT ONE OF THE STRAPS RUSTED. *AK

DT: WATER INFILTRATION AROUND THE WINDSHIELD CAUSING THE ELECTRICAL SYSTEM TO MALFUNCTION. WHEN IT RAINED WATER LEAKED INTO THE VEHICLE AROUND THE WINDSHIELD AND SOAKED THE INTERIOR PANEL WHICH HOLDS THE FUSES. THE FUSE PANEL ALSO RUSTED. THE OWNER WAS NOT SURE ABOUT OTHER DAMAGE. THIS HAS BEEN A PROBLEM FOR ABOUT 6 MONTHS. THE OWNER TOOK THE VEHICLE TO THE DEALERSHIP AND TO A GLASS COMPANY. THE DEALERSHIP HAD NOT EXPERIENCED THAT PROBLEM BEFORE. OWNER MADE HIS OWN TEMPORARY PATCH FROM SILICONE. THE PATCH WORKED. OWNER CALLED FORD AND FILED A COMPLAINT. *AK WHEN IT RAINED ELECTRICAL COMPONENTS LIKE THE WINDSHIELD WIPERS, POWER WINDOWS , HEADLIGHT ETC WOULD NOT FUNCTION PROPERLY. *NM

1. DRIVING WITH MY FIANCEE TO GO OUT TO EAT IN EVANSVILLE 2. LOSS OF REAR BRAKES(FOUND OUT LATER A PINHOLE IN BRAKELINE) 3. DAMAGE FRONT IN DUE TO TRAFFIC STOP QUICKLY AND I COULD NOT, SO I WENT OFFROAD TO AVOID A CAR IN A SOYBEAN FIELD. TO CORRECT THE FAILURE I AM NOT INSTALLING THE RECYCLED BRAKE LINES THAT I THINK WAS USED WHEN THE F150 WAS MADE SHOULDN'T THEY LAST MORE THAN 7 YEARS SINCE THIS IS A SAFETY FOR THE DRIVER,ALL PASSANGERS AND OTHER MOTORISTS, I HAVE HAD A GARAGE ORDER STAINLESS STEEL, AND THE FRONT BODY PARTS. I DON'T KNOW THE COST OF THE BILL YET..BUT I'M WITHOUT MY TRUCK..FOR AWHILE. AND A HONEY THAT HAS HAD A HEADACHE ALL DAY AND A SPRAIN WRIST...HOPE IT GOES AWAY(THE HEADACHE).

FORD F-150 1998. THE VEHICLE WAS PARKED AND WITHOUT WARNING IT CAUGHT ON FIRE. THE DRIVER CALLED THE FIRE DEPARTMENT TO EXTINGUISH THE FIRE. NO INJURIES WERE REPORTED. THE VEHICLE WAS TOWED AND TOTALED BY THE INSURANCE COMPANY. *AK THE MAJORITY OF THE FIRE WAS ON THE DRIVERS SIDE OF THE VEHICLE UNDER THE HOOD. THIS INCIDENT ALSO DAMAGED A NEIGHBORING VEHICLE DUE TO THE FIRE. *SC *JB