1997 FORD F-150 Complaints

I HAVE A FORD F150 V6 4.2 WITH A BLOWN ENGINE. I STARTED IT ONE MORNING TO A LOUD KNOCKING AND SMOKE FROM THE EXHAUST. I UNDERSTAND THIS HAS BEEN A FREQUENT PROBLEM THAT FORD REFUSES TO TAKE RESPONSIBILITY FOR. MY TRUCK HAS 81,000 MILES ON IT. *JB

DT*: THE CONTACT STATED WHILE ATTEMPTING TO START THE VEHICLE, THERE WAS A LOUD KNOCKING NOISE COMING FROM THE ENGINE FOLLOWED BY THE ILLUMINATION OF THE CHECK ENGINE LIGHT AS WELL AS SMOKE FROM THE EXHAUST. ALTHOUGH THE PROBLEM PERSISTED, THE VEHICLE WAS NOT INSPECTED BY A DEALER.

I NOTICED MY FORD 4.2L V-6 WAS LOSING COOLANT. BUT, THERE WAS NO LEAKS EXTERNALLY. I WENT OUT TO START IT THE OTHER MORNING, AND IT WOULD NOT TURN OVER. I SEARCHED THE INTERNET, AND FOUND INFO ON HYDROLOCKING AND BAD GASKETS. I REMOVED ALL THE SPARK PLUGS, AND CRANKED THE ENGINE. LOTS OF COOLANT CAME OUT OF CYLINDER 1. NOW, I'M LOOKING AT BEST ALL NEW GASKETS, OR POSSIBLY A NEW ENGINE IF THE TIMING COVER GASKETS WEREN'T REPLACED UNDER THE RECALL. *NM

I HAVE A 1997 F150 V-6 4.2L PICK UP TRUCK. I HAVE BEEN LOOSING ENGINE COOLANT AND MY ENGINE OIL LEAKS OUT. I HAVE FOUND THAT THE LOWER INTAKE GASKET PROBLEM IS VERY COMMON WITH THIS ENGINE TYPE AND TRUCK. I FOUND OUT THAT FORD HAD A RECALL ON THIS GASKET BUT THEY DID NOT SEND ME ANY INFORMATION ABOUT IT. THE RECALL ON THE GASKET EXPIRED IN 2005 ( I WAS TOLD BY FORD). I ONLY HAVE 66,000 MILES ON THIS TRUCK. CAN YOU GUYS HELP ME? *NM

I OWN A 1997 FORD F-150 TRUCK, 4.2L V-6. MY WIFE WAS DRIVING THE TRUCK AND WITH NO WARNING THE ENGINE STARTED KNOCKING VERY BADLY, SHE WAS FRIGHTENED AND DROVE THE TRUCK HOME VERY SLOWLY, WHICH ALMOST GOT HER INTO AN ACCIDENT. AFTER DOING RESEARCH WITH FORD MECHANICS AND PRIVATE MECHANICS, I FOUND OUT THE ENGINE IS A DEFECTIVE ENGINE THE YEARS WERE 1997 AND 1998. I CONTACTED FORD AND THEY WILL NOT STAND BEHIND THEIR PRODUCT. THERE CUSTOMER SERVICE IN DETROIT WAS NO HELP AT ALL. I BOUGHT THE TRUCK WITH 36,000 MILES ON IT, TOOK VERY GOOD CARE OF IT, AND IT NOW HAS 64,000 MILES ON IT AND CANNOT BE DRIVEN. I RECENTLY RECEIVED A RECALL FOR THE CRUISE CONTROL SAYING IT COULD CATCH ON FIRE. UNFORTUNATELY THE TRUCK CAN'T BE MOVED UNTIL I REPLACE THE ENGINE, AND IT IS IN MY GARAGE. IF THIS TRUCK CATCHES ON FIRE AND BURNS MY HOUSE DOWN FORD WILL BE SUED. THERE WAS NO WARNING WHEN THE ENGINE WENT, FAILURE WAS TOTAL LOSS OF ENGINE, AGAIN FORD HAS DONE NOTHING. *NM

MY 1997 4.2L V6 F150 WOULD NOT START, REPLACED STARTER MOTOR, PULLED PLUGS FOUND COOLANT IN #1 CYLINDER. I'M CURRENTLY DIGGING INTO THE ENGINE TO REPLACE THE HEAD GASKET. *NM

1997 FORD 150 V6 4.2 L ENGINE FAILURE, NEVER RECEIVED NOTIFICATION FROM FORD ABOUT LOWER INTAKE GASKET RECALL, OR THE RECALL ON THE FRONT COVER GASKET. BOTH DEFECTS CAUSE ENGINE FAILURE BY HYDROSTATIC LOCK, BENDING OR BREAKING THE CONNECTING ROD(S) IN 1 OR MORE CYLINDERS. *NM

(1) NO SPECIFIC EVENTS PRECEEDED FAILURE. (2) DURING ROUTINE INSPECTION BY OWNER, A LEAK WAS DISCOVERED IN A STEEL BRAKE LINE NEAR THE FRONT DRIVERS SIDE WHEEL. CAUSE OF LEAK APPEARS TO BE RUST THROUGH. THERE IS EXTENSIVE RUSTING OF BRAKE LINES ON THIS VEHICLE. (3) REPAIRS HAVE NOT BEEN PERFORMED YET. RUSTED BRAKE LINES WILL BE SAVED AFTER REPAIRS ARE PERFORMED. *NM

11/16/2005 ~ GO IN FOR A ROUTINE OIL AND LUBE. ATTENDANT GIVES ME DETAILS, I HAVE AIR FILTER REPLACED AND COOLANT ADDED BECAUSE IT WAS LOW. 2/23/2006 ~ GO IN FOR MY ROUTINE OIL AND LUBE. I ASK THE ATTENDANT TO LOOK AT THE COOLANT, I TELL HIM THAT IT KEEPS GETTING LOW. SURE ENOUGH HE COMES BACK AND LETS ME KNOW ITS VERY LOW, DID I WANT TO PUT COOLANT IN IT. 4/28/2006 ~ I GO TO MY 97 F-150 TO HEAD OUT TO AN INTERVIEW, SHIRT AND TIE, CUP OF COFFEE AND PAPERWORK IN HAND. PUT THE KEY IN THE IGNITION AND IT WONT TURN OVER. IT ISN'T THE "BATTERY IS DEAD" WON'T TURN OVER, ITS A "I WANT TURN OVER BUT I CAN'T" OVER AND I CALL MY MECHANIC. HE ARRIVES AND GETS OUT HIS JUMPERS TO SEE IF IT IS A DEAD BATTERY. WE LOOK AT THE STARTER, ELECTRICAL EVERYTHING AND CAN'T SEEM TO FIGURE IT OUT. HE SAYS TO ME, "YOU DON'T HAVE VERY LOW OR LITTLE COOLANT, PUT SOME IN THE RESEVOIR" HE ASKS ME IF I NOTICED ANYTHING ODD, ANY HESITATION THE PREVIOUS DAY, I TELL HIM NO, I LITERALLY DROVE 3 MILES TO GO TO THE MARKET AND THAT WAS IT FOR DRIVING THAT DAY. HE ASKS ME TO PUT IT IN REVERSE AND WE TRY AND PUSH IT BACKWARDS TO TURN THE MOTOR OVER. IT WON'T BUDGE, AT THIS POINT HE SAYS THERE HAS TO BE SOMETHING IN THE CYLINDER(S), GAS, WATER, OIL, SOMETHING AND WE'LL PULL THE PLUGS AND SEE WHAT COMES OUT. WE PULLED THE PLUGS AND COOLANT CAME POURING OUT OF CYLINDER #2. I HAVE PICTURES ETC OF THE COOLANT AND PLUGS. I FOUND THERE ARE MANY PEOPLE HAVING ISSUES IDENTICAL TO THIS WITHIN THE SAME TIMBERING OF MILEAGE AND EVEN THE SAME CYLINDER. HTTP://FORUMS.TREEMEDIA.COM/FB/SHOWTHREAD.PHP?T=224 HTTP://WWW.FORD-TRUCKS.COM/FORUMS/SHOWTHREAD.PHP?T=473230 HTTP://EN.WIKIPEDIA.ORG/WIKI/FORD_ESSEX_V6_ENGINE_(CANADIAN)#4.2 MY MECHANIC IS NOW PRICING A COMPLETE GASKET KIT AND WILL NEED TO TAKE THE MOTOR APART TO FIX THE PROBLEM. THE MOTOR SOUNDS AS IF IT IS OK AND WE ARE GOING TO TRY TO REMEDY THE GASKET SITUATION AND SEE IF WE CAN'T GET IT TO RUN NORMALLY. *JB

DT*: THE CONTACT STATED THE VEHICLE LOST POWER INTERMITTENTLY WHILE DRIVING AT ANY HIGHWAY SPEED. THIS HAPPENED MORE OFTEN WHILE TOWING SOMETHING BEHIND THE VEHICLE. THE ENGINE SPEWED COOLANT ONTO THE ENGINE BLOCK. THE VEHICLE HAS BEEN TO THE DEALERSHIP FIVE TIMES. THE HEADS HAVE BEEN CHANGED ONCE; THE RESERVOIR SYSTEM HAS BEEN CHANGED TWICE. THE EGR VALVE HAS BEEN CHANGED TWICE. HOWEVER, THE PROBLEM STILL PERSISTS.