2015 FORD F-150 Complaints

Vehicle has a catastrophic design flaw. If water enters the LED BLISS tail light assembly even in small amounts for anreason, including due to manufacturing defects, minor damage such as a crack, e treme wet weather, or wear and tear of seals, then numerous electrical failures occur of the entire warning system. This includes not only the tail lights, and blind spot backup and cross traffic systems, but catastrophic failure of all dashboard door and window controls. The vehicle cannot be easily unlocked including with remote, climate and accessories cannot be controlled. They vehicle can barely be operated and great expertise and expense required to return the vehicle to proper service. This has happened twice to this vehicle in 2022. Both times it was from minor damage to the taillight lens. Water entered the connectors for a network system which is critical to numerous vehicle safety and critical systems which are completely digital. The part required replacing is available only from a dealer as an OEM part and cost $500 plus labor. Research shows this is a widespread confusing problem, which renders high end models nearly inoperable with uncontrollable systems other than basic engine functions and subjecting consumers to great inconvenience and expense. The manufacturer does not appear to have offered recall services and only will repair or replace if the item fails under warranty. Under any interpretation this problem is a gross failure in engineering and safety. What other vehicles with a minor taillight problem have failure of a majority of systems? So many codes are thrown that the average technician and consumer must bear great expense to repair for diagnosis, and then replacement with extremely expensive parts only available from dealer.

Rear driver's door lock froze and wouldn't lock. Upper lock/latch latched on rear driver's side door, but lower lock/latch froze and wouldn't latch/lock. Had to drive to work with the lower lock not latched and wait for weather to warm up for latch/lock to release. Problem happens every year when the weather gets cold.

I connected the 7-pin trailer wire of my 16' tandem axle enclosed trailer with electric brakes to my pickup. I checked the lights on the trailer. All functioned correctly. I got into my pickup to drive. The integrated trailer brake controller was smoking and getting hot. No error messages popped up on the dashboard. I pulled the fuse for the trailer brake module to prevent the integrated trailer brake module from melting or catching fire. Upon searching the internet, this appears to be a problem with my model year (2015 F-150). Ford dealership re-programs the trailer brake module. This needs to be addressed before the brake controller fails and could potentially catch fire. It also could cause an accident, because the electric trailer brakes will lock up or cease to engage.

While sitting in my driveway getting ready to go to town, I pulled the seat belt to lock it into place when I hear a pop then the seat belt would not retract at all. It was as if the retractable spring broke. I left the truck sitting until I could get a replacement belt from Ford (450.00) to repair this safety issue. Had this belt failed in a collision it would have caused severe damage to the driver. This issue needs to be addressed before someone dies in an accident. There was no warning signs before this happened and I was very lucky it happened in my driveway and not on the highway.

Al darmarcha mi camioneta no dio marcha creei que la vateria estaba baja pero no dio marcha solo encendieron las luces del tablero brake system y Electric park brake no damarcha se bloqueo por completo

Throttle body failure while driving resulting in immediate need to pull off the road as vehicle lost power and a lot of warnings lights going off. Very dangerous at Haigh speeds in traffic.

My Trucks oil Pan Gasket leaks oil. I had it fix, but the Ford company had to use an aftermarket part on my truck instead of a OEM part. After I had My Truck in the shop i encountered multiple individuals online and in person that has had this issue. Here is a few form: [XXX] [XXX] [XXX] Can you check into this issue and see if it warrants a recall. Regards [XXX] [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

The contact owns a 2015 Ford F-150. The contact stated that another vehicle had backed into the contact's vehicle which cracked the lens cover on the rear cross traffic system. Once the lens cover cracked, moisture began to enter the lens cover which caused both the window defroster and the power windows locks to not operate as needed. The contact stated that several warning messages including the "Cross Traffic Collision", and "Tail Collision" had appeared on the instrument panel. The contact called several dealers in his area and was informed that the part to repair the vehicle was on back order. The manufacturer was notified of the failure. The vehicle was not repaired. The failure mileage was approximately 90,000.

Driving 68mph with cruise control engaged, truck violently jerked. Gear indicator went to 1st and started flashing. There was no gas pedal response. The truck was just coasting. About 10 seconds later, the gear indicator went back to 6th and resumed normal operations. This seems to be the same lead frame issue earlier f150s had with this transmission but no recall has been made for the 2015’s. This is a serious safety issue and needs to be addressed by Ford

While driving at approx 50 MPH the engine suddenly stopped and shut off. I coasted to the side. There was no ability to restart the engine. It was towed to my mechanic who informed me the engine had fully seized. Engine odometer was approx 103,000 miles at time of incident. There was a full engine oil reservoir.