2000 FORD F-150 Complaints

I WAS DRIVING HOME FROM WORK ON THE HIGHWAY WHEN I STARTED TO SMELL A SLIGHT BURNING SMELL. I WAS FOLLOWING A TRACTOR TRAILER TRUCK AND I ASSUMED IT WAS JUST THE SMELL OF THAT TRUCKS BRAKES. A FEW MILES UP THE HIGHWAY MY TRUCK SHUT OFF WHILE DRIVING. WHEN I PULLED OVER THATS WHEN I SAW ANOKE COMING FROM UNDER THE HOOD. I GRABBED MY KEYS AND POPPED THE HOOD. THATS WHEN I SAW A GOOD SIZED FLAME ON THE DRIVERS SIDE OF THE ENGINE COMPARTMENT. I WENT A SAFE DISTANCE FROM THE TRUCK AND CALLED 911. MY TRUCK QUICKLY WENT UP IN FLAMES. I DID SOME RESEARCH AND FOUND ALOT OF TRUCKS THE SAME YEAR AS MINE WERE CATCHING FIRE DUE TO A RECALL FOR THE SPEED CONTROL SENSOR. I THEN LOOKED INTO THAT AND FOUND THERE WAA NO PENDING RECALL FOR THAT ISSUE FOR MY TRUCK AND COULD NOT FIND IF IT HAD BEEN DONE ON MY TRUCK PREVIOUSLY.

WHILE THE TRUCK WAS STATIONARY, AFTER HAVING BEEN DRIVEN ABOUT 20 MINUTES PRIOR WE COULD SMELL A BURNING PLASTIC SMELL. A FEW SHORT MINUTES LATER THE ENGINE WAS ENGULFED IN FLAMES. THE FIRE STARTED IN THE FRONT DRIVERS SIDE AND SLOWLY MAKE ITS WAY TO THE BED. THE HOOD WAS COMPLETELY DISINTEGRATED BY THE TIME THE FIRE DEPARTMENT HAD PUT IT OUT. WE BELIEVE THIS WAS DUE TO THE RECALL CAMPAIGN 11S21. WE DID OWN THE VEHICLE OUT RIGHT, AND DID NOT CARRY INSURANCE, BUT MY OTHER VEHICLE HAD SOME DAMAGE AND A NUMBER OF MY HUSBANDS TOOLS WERE DESTROYED.

TL* THE CONTACT OWNS A 2000 FORD F-150. THE CONTACT STATED THAT WHILE THE VEHICLE WAS PARKED, THE FUEL TANK STRAP FRACTURED AND SEPARATED FROM THE VEHICLE. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE VEHICLE WAS NOT INCLUDED IN NHTSA CAMPAIGN NUMBER: 11V385000 (FUEL SYSTEM, GASOLINE). THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 108,000.

AT APPROX. 2:22 AM ON THE MORNING OF 3/4/2016, THE ENGINE BECAME ENGULFED IN FIRE AFTER HAVING BEEN PARKED IN THE DRIVEWAY SINCE 3:00 PM ON 3/3/2016. WE LATER LEARNED OF A NUMBER OF RECALLS LEAD BY FORD FOR THE REPLACEMENT OF A DEFECTIVE BRAKE SWITCH WHICH WOULD CAUSE THIS TYPE OF FIRE. WE CHECKED THE VIN OF THE VEHICLE WITH BOTH NHTSA AND FORD AND FOUND THAT NO RECALL WAS EFFECTIVE FOR THIS PARTICULAR VEHICLE. I HAVE ATTACHED THE FIRE REPORT AND PHOTOS.

EXTEND CAB WITH 4 DOORS. WHERE THE REAR SEAT AND SEAT BELTS MOUNT TO THE BODY IT IS COMPLETELY RUSTED AWAY. THE SEAT AND SEAT BELT IS LOOSE AND WILL NOT BE SECURED IN A CRASH. VERY LITTLE RUST ON THE REST OF THE CAB AND THE ROCKER PANELS ARE INTACT. HOWEVER THE SEAT BELTS FOR THE REAR PASSENGERS ON BOTH THE RIGHT AND LEFT SIDE ARE NOT CONNECTED.

WHILE DRIVING MY TRUCK IT STARTED TO SPIT AND SPUTTER. FOUND MY NUMBER 8 SPARK PLUG HAD BLOWN OUT. MECHANIC FOUND THE THREADS ON THE SPARK PLUG AND THE ENGINE HEAD STRIPPED.

WHILE SITTING STATIONARY WAITING FOR A TRAFFIC LIGHT. WHEN THE LIGHT CHANGED I BEGAN TO MOVE AND EJECTED A SPARK PLUG FROM MY 5.4L TRITON ENGINE. AFTER HEARING A LOUD POPPING NOISE AND THE CAB OF THE VEHICLE FILLED UP WITH GAS FUMES. LUCKLY I WAS CLOSE TO HOME. BUT I AM LUCKY THAT THE ENGINE COMPARTMENT DID NOT CATCH FIRE FROM GAS AND VAPORS IN THE ENGINE AREA.

TL* THE CONTACT OWNS A 2000 FORD F-150. THE CONTACT STATED THAT THERE WAS A FUEL ODOR COMING FROM THE VEHICLE. UPON FURTHER INSPECTION, THE CONTACT NOTICED THAT THE VEHICLE WAS LEAKING FUEL FROM THE UNDERCARRIAGE OF THE VEHICLE. THE VEHICLE WAS TAKEN TO THE DEALER WHERE IT WAS DIAGNOSED THAT THE VEHICLE'S FUEL TANK WAS RUSTED AND FRACTURED AND NEEDED TO BE REPLACED. THE CONTACT WAS ALSO MADE AWARE OF NHTSA CAMPAIGN NUMBER: 11V385000 (FUEL SYSTEM, GASOLINE) IN WHICH THE VEHICLE WAS INCLUDED, BUT THE CONTACT FAILED TO RECEIVE NOTIFICATION. THE CONTACT STATED THAT THE MANUFACTURER WOULD ONLY COVER THE REPAIR OF THE FUEL TANK STRAPS AND NOT THE FUEL TANK ITSELF. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 140,000.

SPARK PLUG BLOWING OUT OF THE CYLINDER HEAD BECAUSE OF BAD FACTORY THREADING AND POSSIBLY HURTING ENGINE AND MAKING TRUCK RUN IMPROPERLY. THIS IS THE SECOND TIME THIS HAS HAPPENED WITHIN ONE YEAR ON A TRUCK AT 90K MILES. THIS NEARLY CAUSE MY TO HAVE A MULTIPLE CAR ACCIDENT.

THE SPARK PLUG BLEW COMPLETELY OUT WHILE DRIVING, IT ALSO BROKE THE COIL PACK WHEN IT BLEW.