2011 FORD F-150 Complaints

Going down the highway at 60mph. Car went from 6th gear to 1st gear and tires locked up and I started sliding. I could smell the tires burning. I threw it into neutral and the tires unlocked. I dropped back down to 40 mph and went back into drive. No issue after.

The power steering goes out randomly. While driving forward , backing up, parking, turning. Very dangerous to drive.

Was in a car Collison not wherein setbelt and airbags did not deploy or come out at all

Hard downshifts from 5 to 4. At low speeds, like parking lots it shifts hard from 1 to 2. At freeway speeds while attempting to pass instead of dropping a gear to passs it downshifts to 1st, rpm’s shoot up and it results in having to pull off stop and place in park. Once in park back to D and able to take off. At any speed from 30 mph or more there is a sort of “tap of brakes” feeling every .15 of a mile.

The display will show a wrench icon and check engine light. The transmission will suddenly downshift and lose power. The RPMs will either rise or remain the same but unable to accelerate. The wheels will intermittently lock up. This occurs at high speeds on the highway and on back roads at slower speeds. Stopping the tuck, shutting it off and turning it back on will "reset" and it will run ok but the timing between incidents is intermittent. There is a recall for this issue however the dealership (Greico Ford in Raynham) refuses to make the repairs, instead telling me this is no longer covered by recall: Transmission molded leadframe extended coverage [XXX] Today was the latest event, however this has been ongoing since December 2024. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

Entering the highway, the transmission shifted into 1st, the gauges blanked out and a service light came on. Upon taking it in for inspection, FORD compliant 19N01 already existed but had limited mileage/date that has now expired. The problem and solution is the same found under 19N01

Speedometer stopped working and automatic transmission would not shift out of first gear without manually shifting. Transmission then would not come out of third gear.

I own a 2011 Ford F-150. While driving at highway speed, the transmission unintendedly downshifted to first gear, causing the vehicle to lose motive power. This can, by Fords admission, cause accidents and Injury. The check engine warning light and Wrench Symbol was illuminated. Sometimes it is able to restart and reset sometimes not. This problem has occurred several times while driving. I took it to my normal mechanic, where it was diagnosed with an output shaft speed sensor failure. He said that the transmission lead frame needed to be replaced. The vehicle has not yet been repaired. I spoke to Ford customer service and they refuse to fix it and said my VIN was not included. See NHTSA Safety Recall Report 16V-248

When driving on the interstate with the normal flow of traffic at 55mph, the vehicle abruptly downshifted from 6th gear to 1st gear causing the the vehicle to lock up an nearly caused an accident. This was followed by a a mechanic warning light and the speedometer to lock out and no longer work. Once pulled over, the vehicle was powered down. When the vehicle was turned back on operation returned in a limp state.

What is happening is a KNOWN issue that effects Ford F-150's from 2011-2013 Models with the 6-Speed transmissions. The issue is with the Molded Lead Frames. The fault causes hard downshifts out of now where. I was driving on a highway, at highway speeds, when the truck downshifted to 1st Gear. Incredibly unsafe, jolted the truck to an immediately forced reduced speed, luckily no one was behind me. Ford is aware of this, but is not correcting affected vehicles. My vehicle is a 2011 F-150, I tried to have it fixed while it was still under the "extended coverage" but Ford denied it due to it only being a "possible malfunction" at the time. Roughly 2 years later, the malfunction & defect is now on full force, rendering the truck unsafe to drive due to sudden down shifts at random intervals, multiple times a day while driving, yet now it is "passed the coverage." That is unacceptable, and is safety issue for the many of these generation models of F-150's that are still out driving.