1997 FORD F-150 Complaints

NO KNOWN EVENT LEADING UP TO FAILURE. ENGINE MADE A LOUD EXPLODING NOISE AND STARTED POPPING AFTER EXPLOSION. THE DEALERSHIP EXPLAINED THAT IT WAS A BLOWN SPARK PLUG AND THAT THE HEAD HAD TO BE REPLACED. COST $1600.*AK

MY 1997 FORD F150 WITH A 4.2L V-6 ENGINE BEGAN GIVING ME PROBLEMS A FEW MONTHS AGO. IT BEGAN HAVING AN ERRATIC STARTING PROBLEM. IT THEN BEGAN TO BLOW OUT WHITE SMOKE OUT OF THE EXHAUST. I CHECKED THE COOLANT SYSTEM WITH PRESSURE GAUGES, AND EVERYTHING SHOWED TO BE FINE. I DID THIS SEVERAL TIMES, BECAUSE WHITE SMOKE CONTINUED TO COME OUT OF THE EXHAUST. THEN I WENT TO START IT THE OTHER MORNING AND IT TURNED OVER THE ROD IN THE #4 CYLINDER IS BENT DUE TO COOLANT IN THE CYLINDER. I HAVE HEARD THIS HAPPENING TO MANY PEOPLE, AND THINK THAT FORD SHOULD STEP UP AND TAKE RESPONSIBILITY! . THE TECH THEN EXPLAINED THAT THE F-150S HAVE HAD A TREND PROBLEM WITH THESE ENGINES FOR YEARS; COOLANT WOULD LEAK INTO A CYLINDER CAUSING TOO MUCH COMPRESSION RESULTING IN A BENT OR BROKEN ROD. IT COST ME OVER $2000 FOR SOMETHING FORD KNEW WAS DEFECTIVE. I SENT A LETTER (ATTACHED) TO FORD AND RECEIVED A CALL FROM CUSTOMER SERVICE BASICALLY TELLING ME IT WAS THE OWNER'S RESPONSIBILITY. THIS VEHICLE WAS METICULOUSLY CARED FOR ACCORDING TO THE OWNER'S MANUAL BUT, BECAUSE OF AN ENGINEERING PROBLEM WITH THE MANUFACTURER, THE ENGINE FAILED. I RESEARCHED AND FOUND HUNDREDS OF STORIES LIKE MINE AT HTTP://FORUMS.TREEMEDIA.COM/FB/SHOWTHREAD.PHP?T=224&PAGE=1&PP=15 . I FINED IT EXTREMELY UNFAIR THAT I AND HUNDREDS IF NOT THOUSANDS OF OTHERS HAVE TO BEAR THE FINANCIAL BURDEN OF REPLACING A DEFECTIVE ENGINE. THESE VEHICLES SHOULD HAVE BEEN RECALLED YEARS AGO. *JB

GASKET FAILED ON 4.2 LITER FORD ENGINE, CAUSING A ROD TO BREAK. I WAS NEVER NOTIFIED OF THE GASKET RECALL IN 1999. IT'S GOING TO COST ME $3000 TO FIX. FORD SHOULD BE LIABLE FOR THIS. THERE ARE THOUSANDS OF OTHERS JUST LIKE MINE OUT THERE.*AK

I'LL HAVE A 1997 FORD F150 FOR NO REASON MY MOTOR BLEW A ROD I'LL READ IN THE INTERNET ABOUT A LOT OF PEOPLE HAVING THE SAME PROBLEM THE MOTOR ARE DEFECT, ISN'T FORD DEALER DURING ANYTHING ABOUT IT. THIS IS NOT RIGHT I'LL WENT TO WORK IN MY TRUCK CAME HOME FROM WORK, 3-HOURS LATER STARTED MY TRUCK THE ENGINE KNOCK CONTINUES TO BANG, I TURN IT OFF I WAS TOLD THAT THE TRUCK BLEW A ROD. THIS IS VERY ON FAIR I CAN'T AFFORD A ANOTHER CAR. PLEASE ADVISE. THANKS YOU. *NM

LOWER INTAKE MANIFOLD IN 4.2L V6 (FORD F150) FAILED (MELTED) ALLOWING COOLANT TO LEAK INTO A CYLINDER RESULTING IN HYDRO-LOCK. THE PISTON AND CONNECTING ROD IN THAT CYLINDER WERE DAMAGED (PISTON SKIRT BROKEN, ROD BENT). SINCE THEN I HAVE LEARNED THAT FORD HAS BEEN AWARE OF THIS PROBLEM ALMOST SINCE THE TRUCK WAS NEW ('97) AND REFUSED TO PROVIDE ANY SUPPORT TO OWNERS EXCEPT WHERE THE GASKET FAILED DURING THE REGULAR WARRANTY PERIOD. AS I UNDERSTAND IT FAILURE IS INEVITABLE, AND EVEN SO FORD DID NOT MAKE AN ATTEMPT TO CONTACT OWNERS REGARDING THIS PROBLEM. IN MY CASE FORD'S REFUSAL TO PROVIDE A WARNING OF THIS PROBLEM TURNED A RELATIVELY INEXPENSIVE REPAIR (REPLACEMENT OF THE GASKET) INTO OVER $1300 IN PARTS AND LABOR. *JB

DT: THE CONTACT STATED THE RIGHT FRONT STEERING LINKAGE AND TIE ROD BROKE, RESULTING IN TOTAL LOSS OF STEERING. THE DEALER PROVIDED A SOLUTION AT THE CONTACT'S EXPENSE. *AK UPDATED 01/25/06. *JB

MY 1997 FORD F150 WITH A 4.2L V-6 ENGINE BEGAN GIVING ME PROBLEMS A FEW MONTHS AGO. IT BEGAN HAVING AN ERRATIC STARTING PROBLEM. IT THEN BEGAN TO BLOW OUT WHITE SMOKE OUT OF THE EXHAUST. I CHECKED THE COOLANT SYSTEM WITH PRESSURE GAUGES, AND EVERYTHING SHOWED TO BE FINE. I DID THIS SEVERAL TIMES, BECAUSE WHITE SMOKE CONTINUED TO COME OUT OF THE EXHAUST. THEN I WENT TO START IT THE OTHER MORNING AND IT TURNED OVER AND FIRED ONCE. THEN IT MADE A REAL LOUD BANGING NOISE, AND WOULD NOT CRANK AGAIN. I CONTINUED TO WORK WITH IT, AND FINALLY GOT IT TO CRANK AGAIN, AND IT WAS KNOCKING. THE KNOCKING SOUND WAS COMING FROM THE OIL PAN. I PULLED THE ENGINE OUT, AND TOOK IT APART. THE ROD IN THE #4 CYLINDER IS BENT DUE TO COOLANT IN THE CYLINDER. I HAVE HEARD THIS HAPPENING TO MANY PEOPLE, AND THINK THAT FORD SHOULD STEP UP AND TAKE RESPONSIBILITY! *NM

I HAD PURCHASED A USED FOR F-150 FOR THE DEALER IT WENT THROUGH INSPECTION AND WAS WORKING VERY WELL. HOWEVER AFTER ABOUT SIX MONTHS OF USE IT STARTED TO LOOSE COOLANT, BUT DOT VISIBLY. IT WOULD RUN HOT , I WOULD ADD COOLANT AND CONTINUE. THEN IN APRIL OF 2005 THE ENGINE LOCKED UP AND HAD TO BE REPLACED. THE MECHANIC SAID THAT THE ENGINE HAD HYDROLOCKED AND WOULD NEED TO BE REBUILT. *NM

LEAKING COOLANT INTERNALLY DUE TO KNOWN MANUFACTURER DEFECT IN GASKETS. THERE WAS NO EXTERNAL LEAKS, JUST DISAPPEARING COOLANT LEVELS AND CAR OVERHEATING. AFTER THE COOLANT WAS TOPPED OFF, I TRIED STARTING THE CAR THE NEXT MORNING, THE CAR WOULDN'T START DUE TO HYDROLOCK. WHEN IT DID FINALLY START, THE ENGINE PRODUCED A LOUD PINGING SOUND (SUCH AS A ROD KNOCK). I AM IN THE PROCESS OF GOING FURTHER INTO THE ENGINE TO ASSESS DAMAGE. THIS IS A KNOW DEFECT TO THE MANUFACTURER AS THEY HAVE RELEASED A TSB TO ADDRESS THE PROBLEM. OF COURSE THIS IS ONLY SHARED WITH THE PUBLIC AFTER DAMAGE IS DONE. PLEASE HELP! *JB

1997 F-150 4.2 ENGINE FAILURE DUE TO KNOWN (BY FORD) DEFECT THAT ALLOWS COOLANT TO LEAK IN TO ENGINE AND DAMAGE THE ENGINE. THE VEHICLE ([XXX] FAILED AT MY SON'S SCHOOL OVER 100 MILES FROM HOME. THIS PARTICULAR PROBLEM IS WELL DOCUMENTED ON THE INTERNET. UNFORTUNATELY, WE DID NOT REALIZE THIS UNTIL THE ENGINE FAILED. THERE ARE MANY FORD CUSTOMERS ANXIOUS FOR GOVERNMENT SUPPORT TO REQUIRE A RECALL TO HELP FINANCE THIS VERY EXPENSIVE (~$4,000) PROBLEM. *NM UPDATED 07/17/2012 *JS INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)