2017 FORD F-150 Complaints

This is a MAJOR issue with Ford F150s. I am not sure how this was never a recall. Ford issues a TSB for this but NOTHING is the TSB fixes the issue. There is a major fault in the IWE system that causes the 4x4 to engage randomly causing the truck to have major steering issues. It causes grinding, like metal on metal grinding, the steering wheel locks in place at times and I personally almost dies several times from this.The locking steering wheel caused me to crash into a ditch because I could not bring the steering wheel back to center. This has randomly happened to me several times while driving, The TSB claims the issue to be intermittent, which it is due to the fault in this IWE system. FOrd needs to literally cover and replace the entire IWE system before someone gets hurt. Please look this up, this is a very known issue that deserves to be a recall and not a TSB. Please help save lives.

This first began when we went to Oregon from dry Central Valley in California and hit rain. Multiple error messages appeared: Service Advance Trac, Check 4x4, Hill Assist Not Available, ABS, Steering Assist Fault, etc. Power steering assist was lost and is now intermittent which creates a dangerous situation. The ABS brakes made load groaning noises. I went to O’Reilley’s and used their OBD2 scanner. It showed codes: U1012-00, U0212-00, U0121-00, P062C-00, all being communication errors. I got a new battery and had a shop scan it. The clockspring was bad so it was replaced with an OEM from Sunrise Ford. He can’t get any communication with any of the other modules. I researched the issues and disconnected the battery while I cleaned the ABS controller connection with electrical contact cleaner. I checked some of the grounding points that weren’t checked by the shop. All of the error messages are now gone except the STEERING ASSIST FAULT. My research showed that this may be related to a wheel speed sensor or the front hub that contains the sensor. It also might be the ABS controller. I entered Engineering Test Mode and have the following continuous DTCs: C40182, C12100, C41582, C42082, C15100, C21200, C42982, C10200. Since they all end in 00 or 82 I think they are likely related. I was told in an online forum that they are communication errors. I think that might apply to the 00 errors, but don’t know about the 82 errors. The truck has under 28,000 miles and the extended warranty expired in May 2024.

I was drinking home from work one day traveling at a rate of 60 mph and all of a sudden the transmission shifts into 2nd gear which made me come to a fast stop with no warning and would not allow me to accelerate to the posted speed limit. This is very dangerous and it’s a common issues that ford will not take accountability for.

Leaking sunroom. I cleaned tube's couple times and it is still happening. Ever time it's been raining my floor mat is soaking wet

The transmission-10 speed. Yes it is available. The vehicle has been exhibiting on and off hard shifting since early December. Yesterday while crossing an intersection the vehicle went out of gear and would not move. A car behind me traveling at normal speed had to brake and swerve into the next lane to avoid hitting my vehicle. After contacting a few transmission shops they all confirmed that this has been an ongoing issue with these transmissions and they could not work on it and the only option was to replace it. Additionally Ford seems to be aware of the problem as they have issued a number of TSB's. The vehicle has not been inspected. The only thing I noticed was that the 1-10 gear indicator turned off.

The contact owns a 2017 Ford F-150. The contact stated that shortly after refueling the vehicle; while his wife was driving at a slow speed and merging onto the highway, the transmission failed to shift above 4th gear. In addition, the contact stated that the RMP had increased but the vehicle failed to accelerate as intended. No warning light was illuminated. The vehicle was towed to a local dealer where it was determined that there was failure with 2 wiring harnesses that required replacement. The vehicle was not repaired. Upon further investigation, the contact noticed that the rearview camera image occasionally failed to properly display an image. The manufacturer was made aware of the failure. The failure mileage was approximately 72,000.

Door latch on both front doors continues to intermittently freeze and will not either open or allow the doors to remain closed.

My 2017 F150 is 7 years old with 80K mileage. Engine problem: Cold start ticking/tapping/rattle noise. Ford claimed it sent a letter in 2021 but I never received. Googled and found there are large amount of the same complaints on 2017-2020 F150 with 3.5L EcoBoost engine. The Cam Phaser / VCT Units will fail. Vehicles may not restart after auto-start-stop. Ford issued Customer Satisfaction Program 21N03 and Technical Service Bulletin TSB23-2143. Those measures are not enough. Ford should recall all 2017-2020 F150 with 3.5L Ecoboost built before Nov 30, 2019. Lug nuts at wheels: Ford used cheap two-piece nuts. All the nuts were swollen in Dec 2024 and could not be removed by myself. I had to drive my F150 to Quick Lane and paid $140 to get all the nuts replaced with one-piece nuts. An employee of Quick Lane told me Ford used cheap two-piece nuts for long time, and it's a common issue on some Ford vehicles. Image if a tire is flat on highway while the nuts are swollen and the flat tire can not be changed! Ford should recall all vehicles using the cheap two-piece nuts. I still keep the old nuts as an evidence.

There has been a continuous oil leak from the oil pan since the vehicle was first purchased from the dealer. The manufacturer is aware of this issue and has issued a TSB for all vehicles from the Kansas and Detroit plants that are affected by a defective oil pan. The manufacturer is refusing to issue a recall despite the issue being wide spread and the dealership reporting that if left unfixed, the issue could result in loss of steering and could cause a serious accident. The vehicle has been inspected by the dealership and instructions were given to contact the customer support center for the manufacturer. The manufacturer admitted to knowing about the defect and still refuses to issue a recall.

Cam phasers make engine rattle at startup and idle. A recall has been put out but the dealer did not get the issue fix and sold it anyway. Also rear sensors don't work right.