2023 FORD F-150 Complaints

while driving in gears between 8-10 I experienced a loss of power (Possible mis-firing) while at speed between 50-60 miles per hour. This occurs every time the vehicle is driven.

The truck initiated a "Stop Safely Now" alert and would not start. I was in a very bad neighborhood at the time and feared for my personal safety. I had to get out of the vehicle, walk away for 10 minutes where the key fob wasn't in contact with the truck, then tried 3 times to start the vehicle without success. I waited another 45 minutes outside in a dark and dangerous area before I finally was able to get the vehicle to start. This is the 4th time since purchasing the vehicle in May 2023 that this has happened. I've had it back to the dealer 3x to troubleshoot but they can find nothing, they've told me that it is a known issue at Ford but they have not received a fix yet. Ford owner forums provided guidance to "let it sit and then try again 10 minutes later". This didn't work in my event and again, my personal safety was at risk.

Truck is not capable of intermittent temperature settings. It is either HOT or COLD. Setting manually to 63 degrees and it’s blowing 80 degree air. the final setting, towards the colder option is LO, and that blows ambient air, in this case cold. So. You options are COLD or HOT making maintaining a reasonable temperature in the cabin and clear windows impossible.

The contact owns a 2023 Ford F-150. The contact stated while driving 60-65 MPH, there was a message indicating that the trailer brakes fault light was displayed. Additionally, an alarm sounded persistently, which interrupted the turn signal function. The contact stated that the failure had been recurring while driving. The vehicle was taken to the dealer, where an unknown over-the-air update was performed; however, the failure recurred. The dealer then replaced the trailer brake control module; however, the failure persisted. The dealer informed the contact that there was no fix for the failure. The vehicle was not repaired. The manufacturer was notified of the failure and a case was opened. The manufacturer later advised the contact to retrieve the vehicle from the dealer because there was no fix for the failure. The failure mileage was approximately 12,000.

Sporadically the vehicle will not start. 200 miles on the 2023 powerboost and this has happened 3 times. Vehicle says pull over safely now and will not allow me to put into gear. picture of battery on dash. Vehicle always sitting in heated insulated garage. Waited a day and then it starts. Ford mechanic does not see anything wrong and cannot duplicate the issue so no fix is available.

Loud vibration while driving, similar to passing over a rumble strip, believed to originate from IWES operating in colder weather. Fear of damage from grinding parts effecting operation of 4WD system.

Truck will randomly start making rumble strip or like you have knobby tires noise from front end. You can put it in 4 high and back 2wd an it goes away.this has happened at different speed and differs temp.

Both front IWE’s are in question. When it’s cold out like below 32 degrees, I driving and hear a grinding noise. Sounds like a bearing type noise when they are stuck engage and one free spinning. The dealer told me if I hear noise again to engage/press 4high. The noise went away but not fixed.

Loud humming noise coming from the driver side front end. It comes on randomly when temps are below freezing. It is something near the wheel such, likely the IWE as it grows higher pitch at higher speeds and lower at lower at lower speeds. When you hit the button to go from 2H to 4H or switching to 4 wheel drive, the humming goes away. Switching back to 2 wheel drive and it comes back sometimes. I see a lot of posts online with others having the same similar issue. This is on a 2023 xlt f150 with the 2.7 liter ecoboost. I contacted the dealer and they are aware of the issue but have not heard of any solutions from Ford. It does not appear to be a formal recall issue yet, but my guess is that it is something that should be recalled. This noise is fairly loud, I can send a recording of it. It also makes the steering wheel shake a little bit with it happening, fairly minor, but obviously not good. Sounds like they need a redesign on the electronic IWE.

The sunroof of the vehicle spontaneously shattered. At 65mph Glass rained down on myself (driver) and my occupants. Nothing impacted the roof of the vehicle. The sunroof just exploded, causing a loud bang, and prompting me to break quickly. Sharp shards of glass went all over the vehicle focused on the backseat.