2006 FORD F-150 Complaints

DT*: THE CONTACT STATED AT VARIOUS SPEEDS, THERE WAS A WHINING NOISE UNDER THE DRIVER SIDE FLOOR BOARD. THE NOISE SOUNDED AS THOUGH IT WAS COMING FROM THE SUSPENSION. THE DEALERSHIP WAS UNABLE TO DETERMINE THE PROBLEM.

DT*: THE CONTACT STATED WHILE APPLYING BRAKE PRESSURE AT 5 MPH IN A PARKING LOT, THE BRAKE PEDAL EXTENDED ALL THE WAY TO THE FLOOR BOARD, AND THERE WAS AN INCREASED STOPPING DISTANCE WHICH RESULTED IN A REAR END COLLISION. NO INJURIES WERE SUSTAINED; THE CONTACT WAS WEARING A SEAT BELT. THE VEHICLE SUSTAINED MINOR DAMAGE. THE POLICE WERE NOT ALERTED. THE VEHICLE WAS TOWED TO THE DEALER WHO WAS UNABLE TO DUPLICATE THE PROBLEM.

DT*: THE CONTACT STATED WHILE STOPPED, THE VEHICLE WAS REAR ENDED BY ANOTHER VEHICLE DURING NORMAL ROAD CONDITIONS. THE FRONT SEATS COLLAPSED, AND THE DRIVER SUSTAINED NECK AND KNEE INJURIES. THE PASSENGER SUSTAINED KNEE INJURIES. THE VEHICLE WAS DEEMED TOTAL, AND A POLICE REPORT WAS TAKEN.

WHILE DRIVING I HEARD A POP AND THE TRUCK JERKED TO THE RIGHT. I HAD NO CONTROL OF THE STEERING. I HIT A LARGE TREE STUMP. IT CAUSED SEVERAL THOUSAND DOLLARS OF DAMAGE. WHILE THE INSURANCE APPRAISER AND BODY SHOP OWNER WERE LOOKING AT THE TRUCK THEY DISCOVERED THAT THE SCREW FROM THE TIE ROD INTO THE RACK AND PINION STEERING WAS STRIPPED. IT FELL APART TAKING AWAY ALL MY CONTROL OF STEERING THE TRUCK. FORD REFUSES TO EVEN LOOK AT THE TRUCK. *NM

NEW 2006 FORD F150 EXTENDED CAB, LESS THAN 2500 MILES, DRIVING IN MODERATE TO HEAVY RAIN WHEN WINDSHIELD WIPERS COMPLETELY FAILED. FORTUNATELY THE DRIVER, MY SON, WAS ABLE TO IMMEDIATELY CROSS 3 LANES OF TRAFFIC AND PULL OFF THE ROAD WITHOUT ACCIDENT OR INJURY. THIS IS A SERIOUS DEFECT / FAILURE THAT COULD HAVE RESULTED IN SEVERE INJURY OR DEATH. WIPER MOTOR WAS REPLACED AT A FORD DEALERSHIP THE NEXT DAY.

DT*: THE CONTACT STATED WHILE ATTEMPTING TO INSTALL A CHILD SAFETY SEAT IN THE VEHICLE, IT WAS NOTICED THAT THE REAR DRIVER SIDE UPPER SEATBELT BOLT WAS NOT TORQUED ALL THE WAY IN. THE CONTACT EXPRESSED THAT THE BOLT LOOKED LIKE IT WAS HAND TURNED 3 RESOLUTIONS. THERE WAS A PLASTIC COVER THAT COVERED THE BOLT HEAD AND USUALLY SAT FLUSH AGAINST THE VEHICLE'S STRUCTURE. IN THIS SITUATION, THE THREADS WERE VISIBLE, AND THE COVER DID NOT SIT FLUSH WITH THE BODY. THE VEHICLE WAS A RENTAL, AND THE CONTACT EXPRESSED THAT THERE MAY BE OTHER VEHICLES WITH THE SAME PROBLEM. THE MANUFACTURER WAS GOING TO BE CONTACTED AFTER FILING A COMPLAINT WITH THE NHTSA.

DT*: THE CONTACT STATED THE SIDE VIEW MIRROR GLASS ON BOTH MIRRORS DID NOT STAY STATIONARY WHILE DRIVING OVER ROUGH ROADS AT ANY SPEED. THE MIRRORS POINTED DOWNWARDS, OBSCURING THE VIEW OF THE DRIVER. THE VEHICLE WAS TAKEN TO A SERVICE DEALER, WHERE THE MIRRORS WERE REPLACED. THE PROBLEMS PERSISTED, SO THE VEHICLE WAS TAKEN TO A SECOND SERVICE DEALER, WHO INFORMED THE CONTACT THAT A SECOND REPLACEMENT WOULD DO NO GOOD. THE MANUFACTURER WAS NOTIFIED. UPDATED 10/31/2006 - THE MANUFACTURER REFUSED ANY ASSISTANCE. *NM

AFTER ONE WEEK OF OWNERSHIP, ON 9/2/06 THE TRUCK DIESELED WHEN STARTED FOR ABOUT 5 MINUTES BEFORE IDLING. IT COULD NOT BE TURNED OFF. WHEN IT FINALLY IDLED, THE CHECK ENGINE LIGHT WAS LIT, IT IDLED ROUGH, KNOCKED WHEN ACCELERATING OR UNDER A LOAD AND THE GAS MILEAGE DROPPED AS I WAS DRIVING ABOUT 2 MILES PER GALLON. FROM THIS POINT ON, IT WAS HARD TO START. THIS HAPPENED WITH 1000 MILES ON THE TRUCK. IT WAS TAKEN FOR SERVICE AND THE DEALER TOLD US THAT THE CATALYTIC CONVERTER AND OXYGEN SENSOR WAS DEFECTIVE? THIS SEEMS TO BE THE RESULT OF THIS PROBLEM AND NOT THE PROBLEM AS UPSTREAM FUEL/AIR MIXTURE PROBLEMS CAUSE LEANING/RICHING WHICH WILL MANIFEST ITSELF AS CAT OR OXY SENSOR DEFECTS. THESE PARTS WERE REPLACED AND 1 WEEK LATER THE CHECK ENGINE LIGHT HAS RE APPEARED. *NM

THE TRUCK WAS DELIVERED ON 8/12 IN LATE EVENING WHEN IT WAS COOL, ON THE NEXT DAY IT WAS DISCOVERED THAT THE AIR CONDITIONING DID NOT COOL PROPERLY. IT SHOWED NO COLDER THAN 60 DEGREES ON MAX AIR IN THE LEFT MIDDLE VENT WITH ALL OTHERS CLOSED AND WITH 95 DEGREES OUTSIDE TEMPERATURE. WHEN RETURNED TO THE DEALER ON THE NEXT MORNING, THE SERVICE ORDER SHOWED "NO TROUBLE FOUND". THEY DO HOWEVER SHOW THAT REFRIGERANT(R134) WAS ADDED WHICH IS ODD AS THERE WAS NO TROUBLE FOUND. LATER IT WAS ADMITTED TO ME THAT THERE IS A PROBLEM WITH THE AIR CONDITIONING IN THESE TRUCKS, PARTICULARLY THE RECIRCULATION SWITCH ON THE AIR CONTROL PANEL IN THE TRUCK WHICH DOES NOT STAY ENGAGED. IT SEEMS THAT YOU MUST RE ENGAGE THE SWITCH EACH TIME THE TRUCK IS STARTED ALTHOUGH THIS DOES NOT ALWAYS WORK. THIS IS DANGEROUS IF YOU ARE UNFAMILIAR WITH THE TRUCK, AS OUTSIDE AIR IS BEING BROUGHT IN AT ALL TIMES THUS KEEPING THE DEFROST FROM WORKING PROPERLY AS WELL. FOUL AIR OR ROAD FUMES COMING INTO THE TRUCK TO AN UN SUSPECTING DRIVER. I WAS TOLD THAT FORD IS AWARE THAT IT IS A PROBLEM, BUT HAS TO THIS DATE OFFERED NO SOLUTION. I BELIEVE BASED ON THE RESPONSE FROM FORD, THAT THIS HAS BEEN A PROBLEM THEY ARE AWARE OF ON 2006 TRUCKS AND THE PUBLIC IS UN AWARE. *NM

DT*: THE CONTACT STATED TWO WEEKS AFTER PURCHASING THE VEHICLE WHILE ACCELERATING, THE ENGINE SPUTTERED AND THE CHECK ENGINE LIGHT ILLUMINATED. THE DEALERSHIP WAS UNABLE TO DETERMINE THE PROBLEM, BUT REPLACED THE FUEL INJECTOR. THE VEHICLE OPERATED WORSE AFTER THE REPAIR. THE MANUFACTURER SENT AN ENGINEER TO TEST DRIVE THE VEHICLE. WHILE DRIVING AT AN UNKNOWN SPEED, SMOKE FLOWED FROM THE ENGINE COMPARTMENT. THE VEHICLE WAS PULLED OVER AND THEN ERUPTED IN FLAMES. A POLICE REPORT WAS TAKEN AND THE FIRE DEPARTMENT EXTINGUISHED THE FIRE. THE TWO REAR TIRES AND TAILGATE WERE THE ONLY SALVAGEABLE PARTS. DUE TO THE EXTENSIVE DAMAGE, THE CAUSE OF THE FIRE WAS UNKNOWN. *AK