2004 FORD F-150 Complaints

TL* THE CONTACT OWNS A 2004 FORD F150. WHILE DRIVING APPROXIMATELY 40-45 MPH, THE AIR BAG WARNING LIGHT ILLUMINATED INTERMITTENTLY. THE VEHICLE WAS NOT TAKEN TO THE DEALER FOR REPAIRS. THE FAILURE PROGRESSED AND ONCE THE VEHICLE WAS STARTED, THE AIR BAG WARNING LIGHT WOULD REMAIN ILLUMINATED. THE MANUFACTURER WAS CONTACTED AND WAS ADVISED THAT THERE WERE NO RECALLS FOR THE FAILURE. THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS 51,000 AND THE CURRENT MILEAGE WAS 51,700.

I HAVE A 2004 FORD F150. THE DRIVERS AIRBAG LIGHT FLASHES INTERMITTENTLY. I FOUND THAT THERE IS AN UPCOMING RECALL BY FORD TO FIX THE PROBLEM FOR 05' AND 06' BUT NOT 2004. I READ IN AN ARTICLE THAT NHTSA HAS RECOMMENDED THAT FORD INCLUDE THE 2004 MODELS. I CONTACTED MY LOCAL DEALER AND THEY SAID THE DID NOT KNOW OF ANY RECALLS FOR THE F150 AIRBAG PROBLEM. I OFFERED TO EMAIL THEM THE ARTICLES BUT THEY SAID THEY DID NOT HAVE EMAIL. I TOLD THEM THE LIGHT WAS FLASHING AND THEY TOLD ME IT WOULD COST 49.95 TO LOOK AT THE PROBLEM AND I WOULD HAVE TO PAY FOR THE TOTAL REPAIR. I AM CONCERNED THAT THE DEALER DOES NOT HAVE THIS KNOWLEDGE AND ARE UNWILLING TO DEAL WITH SOMETHING SO OBVIOUSLY DANGEROUS. IN ONE ARTICLE IT SAID THAT IF THE WARNING LIGHT WAS FLASHING I SHOULD TAKE MY TRUCK TO THE DEALER IMMEDIATELY. IS THE 2004 MODEL GOING TO BE RECALLED AND WHEN??? IF I PAY FOR THIS EXPENSIVE REPAIR I AM CONCERNED I WILL NOT BE REIMBURSED ONCE THE RECALL OCCURS. HOW LONG WILL IT TAKE FOR NHTSA TO FORCE FORD TO STEP UP BEFORE A FATALITY OCCURS?? I HAVE A TEXTBOOK SITUATION OCCURRING THAT NHTSA HAS IDENTIFIED AND I CAN NOT GET ANYTHING DONE ABOUT IT! *TR

2004 FORD F150 WITH 5.4 LITER V-8. ENGINE PROBLEMS, STALLING WHEN SLOWING DOWN, HESTITATION, SPARK PLUGS RATCHETED DOWN THAT THEY BREAK WHEN REMOVING. ENGINES THAT NEED TO BE REPLACED BECAUSE OF DESIGN. FORD AWARE OF PROBLEM BUT TECHS AT FORD TELL PEOPLE ITS BAD GAS UNTIL IT IS TOO LATE. CHECK F150FORUM.COM AND YOU WILL SEE HOW BIG THE PROBLEM REALLY IS. I BELIEVE FORD KNEW OF THIS PROBLEM AND IS TRYING TO BURY IT. MY ENGINE FAILED IN A SNOWSTORM GOING UP HILL. I WAS ALMOST IN A TERRIBLE ACCIDENT WITH SNOW COVERED ROADS. MECHANICS KNOW ITS A FLAWED ENGINE, AND I WANT TO KNOW WHY THE NHTSA DIDN'T DO ANYTHING ABOUT IT. YOU ARE TOLD IT IS BAD GAS AND TO KEEP CHANGING YOUR FUEL FILTER. MY TRUCK WOULD NOT GO OVER 85 MILES AN HOUR SINCE I BOUGHT IT NEW. I WAS TOLD IT WAS BAD GAS. I KEPT CHANGING THE FILTER EVERY SIX MONTHS AS I WAS TOLD. I THINK THEY KNEW THIS ENGINE HAD A BAD DESIGN AND KEPT PEOPLE IN THE DARK HOPING THE ENGINE WOULD LAST UNTIL IT WAS OUT OF WARRANTY. *TR

I OWN A 2004 FORD F150 AND HAVE HAD 3 WINDOW REGULATOR FAILURES, 2 WHILE DRIVING. THE DANGEROUS ONE WAS ON THE DRIVERS SIDE AT NIGHT DURING A RAIN STORM. FORD DEALER STATES HE REPLACES 1-2 A WEEK BUT IS NOT YET A RECALL. HE SAYS IT WONT GET A RECALL UNTIL SOMEONE DIES. I THINK IT IS A KNOWN DANGEROUS PROBLEM THAT FORD NEEDS TO TAKE CARE OF BUT WONT UNTIL A RECALL IS MANDATORY. PLEASE RECALL THIS PROBLEM BEFORE "SOMEONE DIES" AND "ONLY THEN" MANDATES A RECALL. THANK YOU FOR YOUR TIME. *TR

I DRIVE A 2004 FORD F-150 HERITAGE WITH ONLY 73,000 MILES THAT HAS NEVER BEEN TAKEN OFF ROAD OR TOWED ANY HEAVY WEIGHT AND HAS HAD REGULAR MAINTENANCE. TWO DAYS AGO WHILE I WAS DRIVING DOWN THE STREET, MY PASSENGER SIDE REAR WHEEL LOCKED UP, MAKING IT DIFFICULT TO STEER AND AFTER STOPPING THE TRUCK WOULD THEN NOT MOVE AS THE WHEEL REMAINED LOCKED. THE VEHICLE WAS TOWED TO A LOCAL REPAIR SHOP WHERE THE LICENSED MECHANIC TOLD ME THAT MY EMERGENCY BRAKE SYSTEM HAD ESSENTIALLY FELL APART (EXPLODED) AND THAT ALL THE LOOSE PARTS FLOATING AROUND IN THE WHEEL HAD JAMMED THE WHEEL. HE CLAIMS THAT FORD USED CHEAP PARTS IN THE EMERGENCY BRAKE SYSTEMS AS PEOPLE WHO HAVE AUTOMATIC TRANSMISSIONS RARELY USE THEM. MY VEHICLE IS A MANUAL TRANSMISSION SO THE EMERGENCY BRAKE IS A NECESSITY. I ASKED HIM IF THIS COULD HAVE HAPPENED IF I WERE DRIVING DOWN THE INTERSTATE AT 70 MPH AND HE RESPONDED "ABSOLUTELY". WHICH MEANS I COULD HAVE LOST CONTROL OF MY VEHICLE AND POSSIBLY FLIPPED. HE AND MY HUSBAND INFORMED ME THAT EVEN WITH ANY POSSIBLE WEAR, THESE PARTS SHOULD NOT BREAK. THE MECHANIC HAD ALSO INFORMED ME THAT I WAS NOT THE FIRST CUSTOMER HE HAD SEEN WITH THIS ISSUE. I THEN PROCEEDED TO LOOK ON THE INTERNET AND FOUND SEVERAL COMPLAINTS ABOUT THE SAME ISSUE. FORD REFUSED TO REPLACE THE E-BRAKE AND I HAD TO PAY FOR THE REPAIR AND OTHER DAMAGED PARTS INSIDE THE WHEEL. BUT MY REAL CONCERN IS ONE OF SAFETY AS I NO LONGER FEEL SAFE DRIVING THIS TRUCK SINCE I KNOW IT HAS BEEN BUILT WITH LESS THAN QUALITY PARTS. I BELIEVE THIS IS A SAFETY ISSUE THAT IS GOING TO COST SOMEONE SERIOUS INJURY IF THIS SHOULD HAPPEN AT HIGHER SPEEDS. I SHOULD ALSO STATE THAT I HAD A MULTIPOINT INSPECTION PERFORMED ON THE VEHICLE 1 WEEK PREVIOUS BY A FORD DEALER AND WAS INFORMED THAT THE EMERGENCY BRAKE WAS GOOD. I ALSO FOUND A 2008 TSB FOR THE PARKING BRAKE ON FORD F-150S OF THIS YEAR THAT DEALT WITH THE NOISE THEY MAKE THAT I THINK IS AWARNING THAT THIS IS ABOUT TO HAPPEN. BUT MY TRUCK NEVER GAVE ME A WARNING. *TR

2004 FORD F150 POWER WINDOW REGULATOR FAILURE. I LIVE IN A HOT AND HUMID PART OF TEXAS SO WINDOWS ARE SELDOM ROLLED UP AND DOWN. HOWEVER THIS IS THE THIRD WINDOW REGULATOR TO FAIL ON THIS VEHICLE. EACH TIME THERE IS A LOW POP AND THE WINDOW SUDDENLY DROPS AND YOU CANNOT ROLL IT DOWN. THE 2ND TIME THIS HAPPENED IT WAS THE DRIVER SIDE WINDOW WHILE I WAS DRIVING ON I-30, IN DOWNTOWN DALLAS IN THE POURING RAIN. TRY TELLING ME THAT WASN'T A SAFETY ISSUE! *TR

THE REAR WINDOW PASSENGER SIDE OF MY 2004 F-150 LARIAT SUPER CAB CAME CRASHING DOWN AFTER A LOUD POP WHICH STARTLED MY WIFE DRIVING OUR GRAND DAUGHTER HOME FROM SCHOOL WITH OUR THREE YEAR OLD GRANDSON SITTING IN THE REAR PASSENGER SEAT IN A CAR SEAT SECURELY BUCKED WHICH CAUSED HER TO LEAVE THE ROAD WAY. *TR

WHILE DRIVING IN PARKING LOT (APPROX. SPEED 5MPH) DRIVER SIDE WINDOW FELL INTO DOOR AND WOULD NOT RESPOND TO ELECTRIC WINDOW OPERATION. WINDOW REGULATOR REPLACED BY FORD DEALER. WITHIN THREE MONTHS SAME EXACT THING HAPPENED TO THE DRIVERS SIDE REAR WINDOW, RESULT FAILED WINDOW REGULATOR. AT THIS MOMENT VEHICLE IS AT FORD DEALER BEING REPAIRED. *TR

THE THIRD WINDOW REGULATOR IN MY 2004 FORD F-150 LARIAT JUST FAILED CAUSING THE WINDOW TO FALL. THE DEALERSHIP CLAIMS THAT THIS IS NOT A DEFECT BUT THOUSANDS OF OTHER F-150 OWNERS HAVE HAD THE SAME PROBLEM. THE FIRST TWO FIXES COST $450 EACH. *LN

TL* THE CONTACT OWNS A 2004 FORD F-150. THE CONTACT WAS DRIVING 10 MPH AS THE VEHICLE BEGAN JERKING VIOLENTLY. THE MANUFACTURER WAS CONTACTED WHO ADVISED HIM TO TAKE THE VEHICLE TO THE DEALER FOR DIAGNOSIS. THE VEHICLE WAS TAKEN TO THE DEALER WHO DIAGNOSED THE FAILURE AS THE CAM SHAFT WHICH WOULD NEED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE FAILURE AND CURRENT MILEAGE WAS 120,000.