2008 FORD F-150 Complaints

I WAS DRIVING ON ON A CITY STREET WHEN THE TRUCK STARTED TO HESITATED. THE TRANSMISSION SEEMED TO CHANGE HARD. I STOPPED AT A LIGHT AND I NOTICED THAT THE O/D INDICATOR WAS ON. WHEN I STARTED TO MOVE AGAIN, IT SEEMED AS IF THE TRANSMISSION WAS SLIPPING AND THE TRANS FAULT INDICATOR CAME ON. THE TRANSMISSION DID NOT CHANGE SMOOTHLY WHEN I DROVE APPROXIMATELY ANOTHER MILE. I PARKED THE TRUCK IN FEAR OF FURTHER DAMAGING THE TRUCK.

MY TRUCK HAS 80,000 MILES. I NOTICED THAT GRADUALLY THE STEERING WAS BECOMING STIFFER AND HARDER TO TURN FEELING AS IF IT WAS BINDING AT TIMES. IT GOT TO A POINT THAT WHEN MAKING A TURN THE WHEEL WOULD NOT RECOVER AND ACTUALLY HAD TO BE PULLED BACK MAKING IT DANGEROUS TO DRIVE. I TOOK IT TO MY SERVICE SHOP AND THEY REPLACED THE POWER STEERING PUMP WHICH DID NOTHING TO CORRECT THE PROBLEM. I THEN DID SOME RESEARCH ON-LINE AND FOUND VARIOUS FORUMS WHERE OWNERS AND REPAIR TECHS DESCRIBED THE TWO "U" JOINTS ON THE F-150 STEERING SHAFT BECOMING BADLY CORRODED MAKING IT DIFFICULT TO TURN THE STEERING WHEEL AND POINTING OUT THE JOINTS HAVE NO GREASE FITTING. I CHECKED THE JOINTS ON MY TRUCK AND THEY ERE CORRODED. I APPLIED LUBRICANT EXTERNALLY AND IT COMPLETELY ELIMINATED MY PROBLEM, HOWEVER, I HAVE TO REAPPLY LUBRICANT EVERY COUPLE OF MONTHS. THE ATTACHED PHOTO SHOWS THE UPPER JOINT AFTER I LUBRICATED IT. FORD HAS TO KNOW THIS SAFETY ISSUE EXISTS AND THAT THIS IS COSTING OWNERS NEEDLESS REPAIR COSTS.

WHILE THE TRUCK WAS PARKED ON LEVEL GROUND IN A PARKING LOT, I NOTICED WHAT A APPEARED TO BE A HOLE RUSTED THROUGH THE DRIVERS SIDE FRAME. FURTHER INVESTIGATION REVEALED THAT THERE WERE SEVERAL LARGE HOLES BEGINNING IN FRONT OF THE REAR WHEEL AND EXTENDING TO ABOUT THE MIDDLE OF THE CAB. THESE HOLES ARE ALL THE WAY THROUGH, (BOTH SIDES OF THE RAIL), ON BOTH SIDES OF THE TRUCK. SEE ATTACHED PICTURES. I FEEL THIS SIGNIFICANTLY COMPROMISES THE INTEGRITY OF THE FRAME AND MAKES IT LESS SAFE TO OPERATE. I AM ALSO VERY SURPRISED TO SEE SO MUCH CORROSION ON AN 11 YEAR TRUCK. THIS HAS BEEN REPORTED TO THE DEALER THAT SOLD ME THE TRUCK 5 YEARS AGO, TO FORD MOTOR CO., AND TO THE BETTER BUSINESS BUREAU. NONE OF THESE ATTEMPTS HAVE RESULTED IN ANY ACTION. I'M SURE MINE IS NOT THE ONLY F150 WITH THIS PROBLEM AND I WANT TO MAKE SURE THE WORD GETS OUT.

"TAKATA RECALL" I WAS TAKING MY GRANDCHILDREN HOME ON A DIRT ROAD AND HIT A DEER WHICH SPUN ME AROUND AND SMASHED INTO A BIG TREE HEAD ON.THE CRASH WAS SO HARD THAT THE FRONT BUMPER WAS CRUSHED AGAINST THE MOTOR BLOCK,DECLARED TOTALLED FROM MY INSURANCE COMPANY.MYSELF,I HAD A WHIPLASH,MY GREAT NIECE (PASSENGER) BROKE HER WRIST,MY GRANDSON HAS LEG PROBLEMS AND MY GRANDDAUGHTER HIT HER HEAD REAL HARD!MR. (XXXXX) THE OWNER WAS DRIVING!!!!!!! PARTS OF THIS DOCUMENT HAVE BEEN REDACTED TO PROTECT PERSONALLY IDENTIFIABLE INFORMATION PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6).

TL* THE CONTACT OWNED A 2008 FORD F-150. THE CONTACT STATED WHILE DRIVING AN UNKNOWN SPEED, WHEN THE VEHICLE HIT A DEER CAUSING THE CONTACT TO LOSE CONTROL AND HIT A TREE. THE CONTACT STATED THE FRONT OF THE VEHICLE RECEIVED THE MAJORITY OF THE IMPACT. THE AIR BAGS FAILED TO DEPLOY. THE CONTACT STATED MEDICAL ATTENTION WAS PROVIDED FOR 4 PEOPLE BUT THE INJURIES WERE UNKNOWN. A POLICE REPORT WAS NOT FILED. THE VEHICLE WAS TOWED TO AN IMPOUND LOT. THE CONTACT HAS CALLED LOCAL DEALER PHIL LONG FORD OF MOTOR CITY LOCATED AT 1212 MOTOR CITY DR, COLORADO SPRINGS, CO 80905, (866) 947-5647 TO NOTIFY FAILURE OF THE VEHICLE. THE VEHICLE WAS DESTROYED. THE MANUFACTURER HAS NOT BEEN INFORMED OF FAILURE. THE FAILURE MILEAGE WAS 119,401. *BF *JB

TOOK VEHICLE IN FOR ENGINE REPAIR. TECHNICIAN DISCOVERED BOTH FRONT COIL SPRINGS BROKEN. ALMOST NEW TIRES WORN BALD ON THE INNER EDGE. ONLINE RESEARCH INDICATES THIS HAS BEEN A MAJOR COMMON PROBLEM ON THE 04-08 F-150, WITH NO RELIEF FROM FORD.

2008 FORD F-150. CONSUMER WRITES IN REGARDS TO ENGINE FAILURE. *LD THE CONSUMER STATED THE VEHICLE ENGINE WOULD MISFIRE AND LACKED POWER. THE ENGINE ASSEMBLY WAS REPLACED.*JS

THE ENGINE 5.4 TRITON MAKES A SOUND THAT RESEMBLES A DIESEL AND SOUNDS LIKE THE PISTON IS ABOUT READY TO COME THROUGH THE BLOCK. I FIRST EXPERIENCED THIS APPROX. 3 YEARS AGO WHILE AT A DRIVE THROUGH FAST FOOD RESTAURANT. I IMMEDIATELY TURNED OFF THE ENGINE. I THEN RESTARTED AND THE NOISE HAD STOPPED. THE MOTOR NOW STILL HAS THE SAME ISSUE, AND AFTER READING MANY FORUMS STATING THE SAME CONDITIONS, DECIDED TO CALL FORD DIRECTLY. THE RESPONSE FROM FORD WAS THEY KNOW ABOUT THE ISSUE ON THESE TYPES OF MOTORS, BUT ARE NOT ISSUING A RECALL FOR THE FIX. THE ISSUE IS APPARENTLY RELATED TO A KNOW CAM, TIMING CHAIN ISSUE THAT HAS TO HAVE THE GEARS AND TIMING CHAIN REPLACED. AT THE OWNERS EXPENSE OF APPROX. 800-1200M DOLLARS PER SIDE ON THIS TYPE OF V8 MOTOR. I RECOMMEND THAT FORD NEEDS TO DO A RECALL ON THESE, AND FIX THE KNOWN ISSUE, THUS CREATING FURTHER PURCHASES FROM CONSUMERS FOR FUTURE PURCHASES OF THEIR PRODUCT. IF YOU ARE IN DOUBT OF THIS ISSUE, JUST TYPE IN YOUR SEARCH ENGINE, 2008 FORD F150 LOUD KNOCKING NOISE WHILE IDLING, AND SIT BACK AND READ UNTIL YOU ARE TIRED OF READING. PLEASE FEEL FREE TO CONTACT ME WITH ANY QUESTIONS. THANK YOU.

MY VEHICLE IS ONLY 11 YEARS OLD. I HAVE AN ISSUE WITH THE FRAME. THE FRAME ON MY VEHICLE HAS RUST HOLES ON THE LEFT HAND INNER SIDE. I BELIEVE THERE IS A MANUFACTURING ISSUE IN THE METALWORK FOR THE FRAMES ON 2004-2008 F150 TRUCKS. I WORK AS A SERVICE TECHNICIAN AND MULTIPLE VEHICLES HAVE THIS ISSUE. WE AS CONSUMERS SHOULD NOT BE HAVING TO COVER THE COSTS OF REPAIRING THESE UNSAFE FRAMES DUE TO FORDS NEGLIGENCE TO BUILD THE FRAMES PROPERLY. DUE TO THIS, ANY VEHICLE WITH FRAME ISSUES SUCH AS MINE, IF INVOLVED IN A WRECK, COULD BE CATASTROPHIC. I HAVE SEEN COUNTLESS F150'S OF THOSE YEAR RANGES COME IN WITH FRAMES ROTTED ALL IN THE SAME PLACE AT THE REAR OF THE MAIN FRAME RAIL, NEAR THE GAS TANK. 2009 AND FORWARD DO NOT SEEM TO HAVE THIS ISSUE AS THEY CHANGED THE DESIGN OF THE FRAME. SOMETHING NEEDS TO BE DONE ABOUT THESE FRAME ISSUES.PICTURES ATTACHED ARE OF VARIOUS F150'S, NOT JUST MY OWN.

RECENTLY DRIVING ALONG A COUNTY ROAD; VEHICLE WARNING TONE SOUNDS AND I SEE THE FOLLOWING. BATTERY, CHECK ENGINE, BRAKES, ABS AND TPMS LIGHTS ON. SPEEDOMETER AND TACHOMETER INOPERATIVE, ENGINE TEMPERATURE GAUGE INOPERATIVE. VEHICLE INFORMATION DISPLAY SHOWED TITLES, I.E. TRIP A, MILEAGE ETC., BUT THERE WERE NO VALUES. OIL PRESSURE AND CHARGING SYSTEM AND FUEL GAUGES WORKING NORMALLY. ENGINE PERFORMANCE UNAFFECTED. DROVE 15+ MILES TO HOMETOWN AND MY MECHANIC. AFTER A DAY OF DIAGNOSIS, HE STATED THE INSTRUMENT CLUSTER WAS THE PROBLEM, AND ALSO THAT IT WAS A KNOWN BUT NOT ACKNOWLEDGED ISSUE BY FORD. NEW CLUSTERS ARE $700 TO $900 WHICH IS OUTRAGEOUS. AFTER A QUICK SEARCH ONLINE, THERE AND A LOT; AND I MEAN A LOT OF PEOPLE SELLING 2008 F-150 LARIAT INSTRUMENT CLUSTERS. SURE I COULD PICK ONE UP FOR A COUPLE HUNDRED DOLLARS, BUT AN ADDITIONAL PROBLEM IS THE MILEAGE; WHICH IS STORED IN THE CLUSTER ROM. MY TRUCK ONLY HAD 86K MILES, WHEREAS IF I INSTALL A USED ONE I INHERIT WHATEVER MILEAGE IS ON THERE. CONSIDERING THE POPULARITY OF THE F-150, YOU WOULD LIKE TO THINK THAT FORD WOULD DO THE RIGHT THING; BUT I SUPPOSE I'M BEING NAIVE WITH THAT WISH.