1999 FORD F-150 Complaints

I BROUGHT IN MY 1999 FORD F150 TO GET AN INSPECTION AND GET A RECALL PERFORMED ON THE STRAPS THAT HOLD THE GAS TANK ON. THE GARAGE HAD THE VEHICLE FOR 6 DAYS BEFORE THEY INFORMED ME THAT THEY IN FACT COULD NOT PERFORM THE SAFETY UPGRADE BECAUSE THE FRAME OF THE TRUCK HAS TOO MUCH RUST. I BELIEVE THAT FORD MOTOR COMPANY IS RESPONSABLE FOR NOT PROVIDING ADEQUETTE PROTECTION FRO THE ELEMENTS ON THE FRAMES OF THIS MAKE/MODEL OF VEHICLE. I CALLED THE FORD MOTOR COMPANY AND WAS TOLD THAT THEY WERE ONLY RESPONSABLE FOR THE GAS TANK STRAPS AND NOT THE FRAME SO THEY WERE NOT REQUIRING THEIR DEALERSHIP TO DO THE UPGRADES. WHEN MY BEST FRIENDS 1999 TOYOTA TACOMA HAD THE SAME EACT PROBLEM ON HIS TRUCK THE TOYOTA COMPANY PAID TO PUT A NEW FRAME ON HIS TRUCK DUE TO A RECALL OF THE FRAME. THE REST OF MY FORD TRUCK IS IN GREAT CONDITION AND HAS AROUND 120,000 MILES ON IT. I HAVE HAD NO OTHER ISSUES WITH THE TRUCK EXCEPT FOR THE FRAME. BECAUSE OF THIS ISSUE THE ONLY REAL CHOICE I HAVE AT THIS POINT IS TO SCRAP THE TRUCK AND BUY ANOTHER VEHICLE. *TR

WHILE USING THE CRUISE CONTROL A FEW TIMES....WHEN I TAP IT ONCE TO DISENGAGE, MY VEHICLE SPEEDS UP! THEN I HAVE TO HOLD THE BUTTON DOWN & GENTLY TAP ON THE BRAKES TO DISENGAGE THE CRUISE CONTROL. IT'S NOT REALLY A BIG DEAL BECAUSE I'M EXPECTING THIS TO HAPPEN, BUT THERE COULD BE THAT ONE TIME WHERE I MIGHT NOT BE ABLE TO DISENGAGE THE CRUISE CONTROL! *TT

TL* THE CONTACT OWNS A 1999 FORD F-150. THE CONTACTED STATED THAT WHILE REFUELING THE VEHICLE, FUEL LEAKED FROM UNDER THE VEHICLE ABNORMALLY. THE VEHICLE WAS TAKEN TO A PRIVATE MECHANIC. THE MECHANIC STATED THAT THE FILLER NECK WAS DETACHED FROM THE TANK. THE MANUFACTURER WAS CONTACTED AND THE VEHICLE WAS REPAIRED. THE FAILURE MILEAGE WAS 127,847 AND THE CURRENT MILEAGE WAS UNKNOWN.

FORTUNATELY, I WAS UNDER 1/2 MILE FROM MY HOUSE. MY ROAD DEAD ENDS ONTO ANOTHER. I APPLIED THE BRAKES AND THE PEDAL WENT TO THE FLOOR AS I APPROACHED THE STOP SIGN. I WENT THROUGH THE STOP SIGN AND INTO THE DRAINAGE DITCH ON THE OTHER SIDE OF THE ROAD. BECAUSE MY VEHICLE IS 4 WHEEL DRIVE, I WAS ABLE TO GET OUT OF THE DITCH AND RETURN HOME. UPON INSPECTION, I FOUND THAT THE BRAKE LINE THAT GOES FROM THE FRONT TO THE REAR WAS RUSTED AND FAILED. THERE WAS LITTLE DAMAGE FROM THE CRASH, JUST A FENDER THAT NEEDS REPLACED. I AM ANAL WITH REGARD TO MY VEHICLES CONDITION AND MAINTENANCE. TO HAVE A FAILURE LIKE THIS ON A WHAT IS SUPPOSED TO BE THE BEST BUILT TRUCK IS ABSURD AND TOTALLY UNACCEPTABLE! MY BROTHERS 1999 HONDA, MY STEP SON'S 1991 NISSAN STANZA (RECENTLY SOLD) A 1993 GEO PRIZM (I.E. TOYOTA COROLLA!!!) RECENTLY SOLD HAD ZERO RUST ON ANY BRAKE FITTING, BRAKE LINE OR FUEL LINE. *KB

TL* THE CONTACT OWNS A 1999 FORD F-150. THE CONTACT STATED THAT WHEN DEPRESSING THE BRAKE PEDAL, THE PEDAL WOULD FEEL SPONGY AS IF THE VEHICLE WAS NOT GOING TO STOP. THE CONTACT WOULD HAVE TO CONTINUOUSLY PUMP THE BRAKE PEDAL FOR THE VEHICLE TO COME TO A COMPLETE STOP. THE CONTACT REFERENCED NHTSA CAMPAIGN ID NUMBER: 05V388000 (VEHICLE SPEED CONTROL) AND STATED THAT THE VEHICLE WAS REPAIRED UNDER THE RECALL BUT TO NO AVAIL. THE DEALER ALSO REPAIRED THE LEAK IN THE BRAKE LINE BUT NOT THE AIR THAT WAS BEING RELEASED AND CAUSING THE BRAKES TO NOT PERFORM PROPERLY. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE BUT ADVISED THE CONTACT THAT THE DEFECT WAS NOT DIRECTLY RELATED TO THE RECALL. THE FAILURE AND THE CURRENT MILEAGE WAS 204,000.

TL* THE CONTACT OWNS A 1999 FORD F-150. THE CONTACT WAS DRIVING 45 MPH WHEN THE DIMMER SWITCH CAUGHT ON FIRE AND MELTED THE WIRES. THE CONTACT MENTIONED THAT THE HEADLIGHTS WERE INOPERABLE. THE VEHICLE WAS NOT TAKEN TO THE DEALER AND THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE VEHICLE WAS NOT REPAIRED. THE FAILURE AND THE CURRENT MILEAGE WAS 171,000.

TL* THE CONTACT OWNS A 1999 FORD F-150. THE CONTACT RECEIVED NOTIFICATION OF NHTSA CAMPAIGN ID NUMBER: 11V385000 (FUEL SYSTEM, GASOLINE:STORAGE:TANK ASSEMBLY:MOUNTING) AND TOOK THE VEHICLE TO THE DEALER FOR REPAIRS. DURING THE RECALL REPAIRS, THE FUEL TANK BEGAN LEAKING ABNORMALLY DUE TO CORROSION OF THE FUEL TANK AND STRAPS. THE MANUFACTURER WAS CONTACTED AND THEY ADVISED THE CONTACT THAT THEY WOULD NOT REPLACE THE TANK OR THE STRAPS. THE FAILURE AND THE CURRENT MILEAGES WERE APPROXIMATELY 208,846. UPDATED 01/18/2012*LJ UPDATED 02/29/12

FRONT BRAKES:: GRADUAL UNKNOWN BRAKING DEGRADATION OVER TIME UNTIL IT GOT TO THE POINT I HAD TO PUMP THE BRAKES LIKE AS IF A BRAKE LINE WAS SUCKING AIR OR THE MASTER CYLINDER WAS GOING BAD, IN ORDER TO STOP. UPON INVESTIGATING I FOUND THAT BOTH DUST SHIELDS ON THE FRONT BRAKES WERE EXTREMELY RUSTED AND THE RUST PIECES WERE FALLING BETWEEN THE FRONT INBOARD BRAKE PADS AND REAR ROTOR SURFACES CAUSING EXTREME CONTAMINATION OF THE BACKSIDE OF BOTH ROTORS TO THE POINT THAT LESS THAN 50% CONTACT SURFACE WAS LEFT. SINCE THE INBOARD BRAKE PADS DO MORE STOPPING THAN THE OUTSIDE BRAKE PADS IT'S A VERY DANGEROUS SITUATION. TO ADD TO THE DANGER THE FRONT BRAKING SYSTEM DOES ABOUT 75% OF A VEHICLES TOTAL BRAKING. AND, IF IT HAPPENS ON A LONG DOWN HILL GRADE WITH ALLOT OF BRAKING, IT CAN CAUSE THE FRONT BRAKE FLUID TO BOIL INSIDE THE CALIPERS GIVING SOMEONE ONE HELL-OF-A WILD RIDE. IN FACT, ONE DAY I HAD TO HIT THE BRAKES WITHOUT HAVING TIME TO PUMP THEM AND JUST ABOUT HIT A KID ON A BIKE THAT DARTED OUT FROM BETWEEN 2 CARS. THAT'S WHEN I DECIDED I HAD BETTER DO SOMETHING ABOUT THE PROBLEM. I SUSPECT FORD HAS BEEN LOVING IT BECAUSE NON-MECHANICAL PEOPLE WILL NEVER KNOW OR FIND OUT AND FORD WILL JUST RIP PEOPLE OFF FOR A MAJOR BRAKE OVERHAUL IN THE TUNE OF $600.00 AND THROW EVERYTHING AWAY SO NOBODY WILL EVER KNOW. THIS IS AN EXTREMELY DANGEROUS SITUATION BECAUSE IT'S SUCH A GRADUAL DEGRADATION OF BRAKING. THE FIX IS TO REPLACE BOTH DUST SHIELDS (FORD P/N= 2L3Z - 2K004 - AA) "THE PRIMARY CAUSE" OF THE PROBLEM. I TOOK MANY PICTURES WITH MY DIGITAL CAMERA OF ALL THE COMPONENTS AND CAN E-MAIL THEM TO NHTSA . I ALSO HAVE ALL THE FRONT BRAKE COMPONENTS; 2 ROTORS, 4 BRAKE PADS, 2 DUST SHIELDS. THE ROTORS ARE VERY HEAVY BUT I WOULD BE HAPPY TO PACK EVERYTHING UP AND SEND IT TO NHTSA IF YOU PAY THE SHIPPING. *TR

STARTED THE TRUCK UP AN BLAST OFF! DONT KNOW WHERE THE PLUG WENT BUT IT WAS GONE AFTER I HEARD A LOUD BANG. *KB *TR

TL* THE CONTACT OWNS A 1999 FORD F150. THE CONTACT STATED WHILE DRIVING AT APPROXIMATELY 20 MPH, THE FUEL TANK DETACHED FROM THE VEHICLE. THE VEHICLE WAS TAKEN TO THE DEALER WHO PERFORMED A DIAGNOSTIC. THE FAILURE WAS LOCATED AT THE FUEL TANK STRAP FRAME RAIL, WHICH WAS CORRODED AND CAUSED THE FUEL STRAPS TO CORRODE. THE VEHICLE WAS NOT REPAIRED. THE FAILURE AND THE CURRENT MILEAGE WAS 100,000.