2004 FORD F-150 Complaints

MY FORD F 150 HAS THROWN A ROD & THE MOTOR IS KNOCKING BADLY, TO MY UNDERSTANDING ALL 2004 FORD F150 3V HAVE A BAD MOTOR IN ALL TRUCKS, EVERY TRUCK I KNOW HAVE THIS PROBLEM. YOU EXCHANGE THIS MOTOR TO A LATER OR EARLY MOTOR IT WON'T WORK I BEING TOLD BY THE DEALERSHIP MECH. I BELIEVE FORD SHOULD BE HELD TO RECALL & REPLACE THESE MOTORS. *JS

2004 FORD F150. VEHICLE SHUT OFF WHILE DRIVING WITH A BOAT IN TOW AND WOULD NOT RE START. HAD TO HAVE VEHICLE TOWED. DEALER DIAGNOSED AS FAILED FUEL PUMP DRIVER MODULE. I WAS STRANDED IN TRAFFIC, VERY DANGEROUS. THIS IS A KNOWN PROBLEM WITH FORD F150 2004-2008. THE MODULE CORRODES AND CAUSES A SHORT CIRCUIT THAT BLOWS THE FUSE TO THE PCM AND RESULTS IN TOTAL FAILURE OF THE PCM, THUS RENDERING THE VEHICLE INOPERABLE. THIS SHOULD BE A RECALL ITEM!!!

CAM PHAZER IS OUT LEANING OUT THE TIMING, CAUSING THE MOTOR TO KNOCK AND IDLE AT 500 RPMS CAUSING THE VEHICLE TO COMPLETELY STOP IN TRAFFIC OR AT A STOP LIGHT. I AM TOLD AT MINIMUM A TIMING CHAIN KIT, PHASER, MIGHT FIX THE PROBLEM IF NOT I WOULD NEED A NEW ENGINE AT 5000.00 DOLLARS THIS NEEDS TO BE A RECALL FIX MY TRUCK ONLY HAS 116454.MILES ON IT AND SHOULD NOT NEED THIS KINK OF REPAIRS YET. OR SHOULD BE COVERED BY FORD THROUGH A MALFUNCTION OF EQUIPMENT THAT WAS INSTALLED AND THERE FOR MALFUNCTIONED PREMATURELY

BROUGHT MY 2004 F150 XLT TO HAVE SOME SERVICE WORK DONE, THE TRUCK NEEDED A MUFFLER AND A NEW FRONT UPPER CONTROL ARM, I WAS ADVISED BY THE SERVICE MANAGER THAT I SHOULD HAVE MY FRAME LOOKED AT BEFORE GOING ANY FURTHER, BOTH RIGHT AND LEFT SIDES OF THE FRAME IN THE MIDDLE OF THE TRUCK HAVE SEVERE RUST AND I BELIEVE THE STRUCTURE IS DOOMED TO FAIL, I HAD PLANNED ON DRIVING THIS TRUCK FOR SEVERAL MORE YEARS AS IT IS MY DAILY DRIVER. I AM NOW LEFT WITH A TRUCK THAT CANNOT BE CERTIFIED FOR RESALE AND HAS LOST ITS VALUE AND FURTHER IT IS NO LONGER SAFE. BY THE WAY THE TRUCK ONLY HAS 190 THOUSAND KMS ON IT.

TL* THE CONTACT OWNS A 2004 FORD F-150. WHEN THE VEHICLE WAS STARTED, THE AIR BAG WARNING INDICATOR ILLUMINATED AND REMAINED LIT. THE FAILURE RECURRED. THE DEALER (CREST FORD FLAT ROCK IN FLAT ROCK, MI, 734-782-2400) STATED THAT THERE WAS NO RECALL. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE FAILURE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS 159,000.

2004 FORD F150 STARTED UP FINE, DROVE IT FOR 10 MINUTES, SLOWED DOWN AND IT STALLED IN THE MIDDLE OF AN INTERSECTION. WOULD NOT START BACK UP, CALLED A TOW TRUCK TO GET THE TRUCK HOME. NEXT DAY, STARTED UP AND DID THE SAME THING, STALLED OUT. THE FUEL PUMP DRIVER MODULE IS CAUSING THIS, ALONG WITH A LOT OF OTHER FORD F150'S. THIS IS A SAFETY ISSUE! I HAD MY CHILD IN THE TRUCK WHEN IT STALLED IN THE MIDDLE OF AN INTERSECTION. THE FPDM GETS CORRODED DUE TO THE BAD POSITIONING OF THE PART.

TRUCK DIED, LOST ALL POWER WHILE DRIVING DOWN THE ROAD. THIS HAS HAPPENED 5 - 6 TIMES THROUGH THE YEARS STARTING AROUND 2010. SOMETIMES DRIVING DOWN FREEWAY SOMETIMES DRIVING SLOWLY INTO DRIVEWAY. BATTERY WAS CHECKED, IT WAS OKAY AND CONNECTED FINE. VARIOUS OTHER ENGINE PROBLEMS LATER INCLUDE A RATTLE NOISE AND LOW RPM. RUNNING HOT, CHUGGING ALONG LIKE RUNNING OUT OF GAS, ETC. HAVING TO PULL OVER TILL IT COULD GO AGAIN. CURRENTLY JUST A LITTLE OVER 100,000 MILES.

WHILE DRIVING THE VEHICLE AT HIGHWAY SPEEDS - RPMS ON ENGINE BEGIN TO FLUCTUATE BETWEEN 2000 AND 750. AT NEXT STOP, ENGINE DIES, BUT WILL IMMEDIATELY RESTART. NO ENGINE MALFUNCTION CODES WHEN CHECKED WITH AN OBD II READER, AND THE CHECK ENGINE LIGHT DOES NOT ILLUMINATE.

TL* THE CONTACT OWNED A 2004 FORD F-150. WHILE THE VEHICLE WAS PARKED IN THE DRIVEWAY, A NEIGHBOR ALERTED THE CONTACT THAT THE VEHICLE WAS ON FIRE. THERE WERE NO WARNING INDICATORS ILLUMINATED PRIOR TO THE FIRE. THE FIRE DEPARTMENT ARRIVED AND EXTINGUISHED THE FIRE. A FIRE REPORT WAS FILED. THERE WERE NO INJURIES. THE VEHICLE WAS TOTALED. THE DEALER AND THE MANUFACTURER WERE NOT CONTACTED. THE FAILURE MILEAGE WAS APPROXIMATELY 150,000.

TO BEGIN WITH I HAD TO HAVE ALL 4 WINDOWS REPAIRED. THE MECHANISM THAT RAISES AND LOWERS THE WINDOWS BROKE. SINCE THIS WAS BOUGHT AS A USED VEHICLE, THERE WAS NO WARRANTY. SO I PD. $150. TO $175.00 EACH. WAS TOLD FORD KNEW OF THIS PROBLEM BUT SINCE IT WASN'T A "SAFETY FACTOR" NO RECALL WAS ISSUED. I FEEL LIKE THIS IS QUITE UNFAIR TO THE CONSUMER. WE PURCHASE A VEHICLE THAT HAS A GOOD REPUTATION AND THEN ARE TOLD THAT THIS EXPENSE IS OUR BABY TO TAKE CARE OF. I FEEL LIKE THIS WAS VERY UNFAIR TO THIS CONSUMER. I HAVE PURCHASED FORDS FOR YEARS WITH NO COMPLAINTS UNTIL NOW. ALSO, THE HEADLIGHTS DEVELOPED A LEAK AND FILLED WITH WATER THUS SHORTING OUT MY RIGHT HEADLIGHT,AND IS SLOWLY DOING THE SAME TO THE LEFT ONE. I HAVE BEEN TOLD THAT JUST THE BURNED OUT BULBS CANNOT BE REPLACED,THAT THE WHOLE ASSEMBLY HAD TO BE REPLACED AND THIS IS AT A COST OF APPROX. $175 TO $200. PER ASSEMBLY. THIS IS OUTRAGEOUS. ALSO,THERE IS A PROBLEM WITH WHAT USED TO BE "POINTS & PLUGS" WHICH ARE NOW A "COIL" ASSEMBLY. THIS PROBLEM DEVELOPED APPROX. 6 MONTHS AGO. ACCORDING TO THE READOUTS I HAVE GOTTEN, THE #1 PLUG IS MISFIRING APPROX. EVERY 1,000 REVOLUTIONS WHICH CAUSES A MISS IN THE ENGINE AND WAS VERY ALARMING TO ME SINCE I WAS ON THE HIGHWAY ABOUT 200-250 MILES FROM HOME, TRAVELING BY MYSELF. SO, ANOTHER EXPENSE IS LOOMING. I REALIZE THERE ARE EXPENSES TO OWNING A VEHICLE. I DO NOT EXPECT TO NOT HAVE ANY PROBLEMS OR REPAIRS WITH MY VEHICLE,BUT I DID NOT ANTICIPATE THIS MANY. NOR DID I EXPECT THE COST OF THE REPAIR PARTS ALONE TO BE SO OUTRAGEOUS. I AM ON A FIXED INCOME AND HAD I ANTICIPATED THESE PROBLEMS I WOULDN'T & #8203; HAVE MADE THIS PURCHASE. I TRULY LOVE MY TRUCK, BUT IS THERE ANYWAY THESE OTHER REPAIRS CAN BE DONE FOR A LESSER AMT? I'VE ALREADY PD. TO REPLACE MOTOR & ROTORS IN ALL 4 WINDOWS. ANY HELP YOU CAN GIVE ME WOULD BE GREATLY APPRECIATED. THANK YOU. [XXX] ('PARTS OF THIS DOCUMENT HAVE BEEN REDACTED TO PROTECT PERSONALLY IDENTIFIABLE INFORMATION PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6).'