2021 FORD F-150 HYBRID Complaints

The contact owns a 2021 Ford F-150. The contact stated that while driving at undisclosed speeds, the vehicle overheated, lost motive power, and stalled. While driving, there was an abnormal clucking noise detected. The check engine warning light was illuminated. The vehicle was taken to the local dealer, where it was diagnosed that the axle bolt and spacer were missing. Additionally, the exhaust system needed to be replaced. The vehicle was repaired. The manufacturer was not contacted. The failure mileage was approximately 15,500.

The Axle bolts on both sides of the truck sheared off. The passenger rear axle bolt sheared at 15,000 miles into having the new truck. The driver side rear axle bolt sheared at 21,000 miles. This is a large safety concern and is not unique to just me. The first axle bolt sheared and was repaired once I figured out the problem at a Ford dealer. The second bolt is currently being repaired in the same dealer's service department. There was no warning or detection of this problem other than a rattling sound during acceleration and a wizzing sound during braking. I do not have either of the sheared axle bolts. They were kept by the dealer.

In the last year I have taken my F150 powerboost in Autonation Ford Orange Park in Jacksonville, Florida twice for recalls. For recall NHTSA # 22S26/22V250 the service department said they were ordering parts and would contact me when they arrived. Never contacted me, even after follow ups. I have recently taken my there for recall NHTSA 23S35/23V509. They have not contacted me.

- The component that has failed is the right rear axle and retaining bolt (the axle retaining bolt sheared off). The vehicle is currently at the dealership (The Ford Store San Leandro, in San Leandro, CA) waiting for replacement parts. Unknown if the vehicle is available for inspection. -To my knowledge my safety was not at risk, but the vehicle is being retained by the dealership because it is deemed a safety concern. -The broken axle bolt was found by the dealership when they were investigating a noise complaint. -The only symptom that was present was noise.

The contact owns a 2021 Ford F-150. The contact received notification of NHTSA Campaign Number: 22V142000 (Visibility) however, the part to do the recall repair was not yet available. The local dealer was contacted. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was not made aware of the issue. The contact had not experienced a failure. Parts distribution disconnect.

Gear shift lever jammed in reverse and could not be changed. With battery powered motor, the vehicle could possibly take off and cause damage or injury. Vehicle is new and still under warranty. Dealership is evaluating the problem

The contact owns a 2021 Ford F-150. The contact stated that while driving at an undisclosed speed, he heard an abnormal scraping sound coming from the rear driver's side of the vehicle. No warning lights were illuminated. The vehicle was taken to the dealer, who determined that the driver's and passenger's side rear axle bolts had sheared off. The vehicle was repaired, but the failure reoccurred. After investigating the failure, the contact related it to Customer Satisfaction Program: 22B34, but the vehicle was not included. The manufacturer was notified of the failure but referred the contact to the NHTSA Hotline for assistance. The failure mileage was 20,000.

The driver's side rear axle bolt sheared off over the course of normal driving. Ford is aware of this problem, advises to not use/drive the vehicle, yet no recall has been issued. Without a recall, getting this issue fixed will take weeks/months and Ford should pay for a rental vehicle since this is clearly a manufacturing defect.

Active Air Dam: My 2021 Ford F150 XLT truck has an active air dam, (AAD), that is suppose to move downwards at speeds of 40mph or greater to help with aerodynamics. This is to help the truck hug the road better at highway speeds. When the truck slows down to under 40mph, the AAD is suppose to recess back up an be tucked away behind the stationary air dam. They started these AAD's on their trucks in the model year of 2021. It has been a widely known issue that the AAD design is flawed and they malfunction and get stuck on the front air dam. Some have came loose and flown off into other vehicles on the roadways. This presents a safety hazard to the owners and other vehicles on the road. Ford refuses to fix it stating that their extended warranty does not cover the parts. This is NOT a warranty issue, this is a poor design issue and a faulty part issue that is going to cause someone to get seriously injured or worse, killed. Some people have reported that their AAD flew off their truck and they didn't even notice until the service tech at the dealership told them during an oil change. So that means their are people out there that are driving with this hazardous part flying off their truck and where is it going? Into the traffic following behind, and what are those drivers going to do when it comes hurling at them at a high rate of speed? Most likely slam on their brakes, causing a rear end collision, or they serve to avoid it and either hit an on coming vehicle head-on or slam into the vehicle next to them on a multi lane highway or interstate. Please make Ford fix their problem before someone gets killed or seriously injured.

Electronic parking brake activated unexpectedly at low speed after taking off from a stop. From a stop traveling downhill at a low rate of speed, the parking break activated and caused the truck to skid to a halt three times causing a safety issue for drivers around the vehicle. Manually deactivated the electronic parking brake each time and after forward movement at about 5 mph, it activated again. After the fourth attempt to start forward movement, the electronic parking brake stayed off. After doing research, recall 23V-509 came up but this specific VIN does not appear to be tagged under that recall.