2023 FORD F-150 LIGHTNING BEV Complaints

Gear shifter was stuck in the car. Can happen at random times. For no reason at all, the gear shifter refuses to budge out of park, or reverse, or drive, and essentially bricks the car. Car refuses to move. Car refuses to respond to accelerator or brake pedals. Can happen in the middle of the road, or in a parking lot late at night when you are trying to leave a sketchy area. Can be an extremely dangerous circumstance, and Ford is trying to avoid attention to this at all costs.

The contact owns a 2023 Ford F-150. The contact stated while the vehicle was parked, the contact discovered that the rear taillights were inoperative, and the taillight housings were full of water. No warning lights were illuminated. The vehicle was taken to a dealer and was repaired under an undisclosed recall; however, the failure persisted. The manufacturer was notified of the failure. The failure mileage was approximately 9,729.

The part they replace the rear light bar that you have a recall for also fails in the exact same manner causing my reverse lights to stay on while driving.

The contact owns a 2023 Ford F-150. The contact stated that while the vehicle was parked, the contact became aware that the rear lights on the vehicle were inoperable. The contact stated that the rear lights failed to function properly while attempting to reverse. The vehicle was taken to the dealer, where it was diagnosed and determined that the rear light bar had failed and needed to be replaced. The vehicle was not repaired. The manufacturer was made aware of the failure. The failure mileage was approximately 70,000.

I was driving down the interstate and the vehicle was struck by lightning. The vehicle lost all electrical power. As a result, the brakes did not work. Luckily, I was able to safely coast to a stop in the median. If the brakes can be more than 90% compromised during complete electrical failure, the vehicle should have a mechanical emergency brake.

The rear lightbar was replaced under a safety recall with a defective part. The replacement started flickering after 4 months and the reverse lights would strobe due to moisture. The dealership inspected and determined it was defective,not damaged and Ford has agreed to pay 60 percent only. Safety recall 23s30

The front trunk (or frunk) of the electric truck has a power lift as the primary means of opening and closing it and this has a failure warning/dash light stating it requires service. The front trunk is where the travel charger is stored by the manufacturer as well as where the positive and negative terminals for the 12 v battery are located. In the absence of the power open function, there is a tab to "pop the hood" but this requires the tab to be held back while a second person pulls open the hood to get it to open/is not possible to open by just the driver. Ford recognizes this problem under the code CXH-03906163-G5J3D0 "reprogram the front hatch control module FCHM" but is listing it as a recommended repair to the dealerships, not a recall. Ford does not list a mileage restriction on this recommended repair, but dealerships will not repair at their cost past 36000 miles. A non-functioning hood or trunk latch that restricts access to key electronic components is a safety issue, not just an inconvenience.

Driver's side tail light has moisture within the housing and intermittently fails to work. This is a similar issue to the light bar across the tailgate that was recalled and repaired, but Ford has no open recall on the tail lights. Dealership estimated a $3000 repair with no admission of manufacturer's defect. Obviously a non functioning tail light/turn signal is a safety risk and also opens the driver to being stopped/ticketed/fined.

Tailgate light bar was replaced under safety recall due to concern of moisture getting into housing. Replacement bar now shows signs of water in light bar after rain storm. Both red and reverse lights are flickering.

I was leaving my storage unit on Sunday October 6, 2024 at around 7 pm. I was traveling at 5 mph as I approached the exit gate code box. I stopped at the top of the steep hill by depressing the brake. I rolled down the window so I could put the code in that opens the rolling gate below. As I took my foot slowly off the brake, suddenly the vehicle rapidly accelerated, veering slightly left, the steering wheel locked as I pressed the brake pedal twice more it was unresponsive. We flew like a rocket ship knocking down small trees, 2 light posts with 1 light coming down and breaking passenger side windshield. Continuing crashing through 2 iron water main fixtures and through an iron gate. At the bottom of the hill the truck flew into the air and came to a hard landing, the steering wheel unlocked and we came to a stop quickly as the one pedal finally engaged and the computer screen announced " one pedal engaged". Then announced Power Train Malfunctioned. Also airbags never deployed. Prior to the wild ride, the vehicle was awaiting the overdue WiFi update named Power Train system update and prior to approaching the hill, I had tried twice to turn on the one pedal and got the never before seen message " one pedal failure could not engage". Truck was a total loss and my passenger and I were injured. When I contacted a Ford representative and told them about the incident, I mentioned that there was 2 other incidents of a brief steering wheel lock and rapid acceleration without injury or crash, I was told that I should have brought it in, therefore they were not responsible. The 2 brief incidents left me unsure of what had happened so we thought it was a fluke and without out any computer warnings we paid it no mind.