2022 FORD F-150 LIGHTNING BEV Complaints

The contact owns a 2022 Ford F-150. The contact stated that while the contact's wife was driving at an undisclosed speed, the vehicle independently accelerated. The contact stated that the vehicle was in line at the car wash when the failure occurred. The vehicle re-ended the vehicle in front, which caused several vehicles to crash into one another. In addition, the vehicle bounced off the curve and crashed into two other parked vehicles before landing on the side of one of the vehicles. The contact stated that the whole incident happened in about five seconds. The contact stated that a parked police vehicle was one of the vehicles involved in the crash. No injuries were sustained. A Police report was filed. The vehicle was towed to the tow yard. The vehicle was scheduled to be towed to the dealer. The vehicle was not diagnosed or repaired by an independent mechanic or dealer. The manufacturer was not made aware of the failure. The failure mileage was approximately 23,000.

The contact owns a 2022 Ford F-150. The contact stated that while attempting to fuel and charge the vehicle, the charging port door failed to open. The vehicle was not taken to a dealer. The vehicle was not diagnosed or repaired. The manufacturer was made aware of the failure and opened a case. The failure mileage was approximately 21,000.

The dash screen where you can see speed fails. Towing required. Fixes itself hours later. Happen repeatedly. Dealer says no error codes, as if it never happened!

While in Adaptive Cruise and self driving the Lightening, dangrously crosses lines and rides too close to the right side. This results in other drivers actively swerving off the road to avoid a collision as well as intervention by me. I have videos of all of the following occurring while operating the vehicle: 1. Riding and crossing the right line (white and dotted when passing) 2. Vehicle crossing the double center lines into oncoming traffic 3. Watch the road warning and cancelling of adaptive cruise even when I show I AM WATCHING THE ROAD I have videos of the activity the truck is experiencing

The contact owns a 2022 Ford F-150. The contact received notification of NHTSA Campaign Number: 23V418000 (Exterior Lighting) however, the part to do the recall repair was not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The contact stated that the tailgate light bar had failed to illuminate. The dealer was contacted. The manufacturer was made aware of the issue. The failure mileage was 28,000. Parts distribution disconnect.

Campaign/NHTSA# 23S30/23V418 Issue Date 2023-06-09 Description On your vehicle, it may be possible that your reversing lamps may not function due to microscopic cracks that can develop in the vehicles rear lightbar. If a microscopic crack is present, condensation can potentially enter the reversing lamp lens through these cracks and cause electrical failure to the reverse lamps. Safety Risk This may result in inoperative reverse lamps which can reduce the awareness of other motorists or road users of the drivers intention to operate the vehicle in reverse gear, increasing the risk of injury or crash. Remedy Ford Motor Company has authorized your dealer to replace the rear lightbar free of charge parts and labor. Campaign/NHTSA# 23C38/23V801 Issue Date 2023-11-28 Description Affected vehicles may have software logic that does not reset the electronic stability control esc system to default operation at the initiation of each ignition cycle. Section 5.4.1 of fmvss no. 126 requires that the vehicles esc system return to the manufacturers original default esc mode at the initiation of each ignition cycle Safety Risk The vehicle operator may not notice that the vehicle operates differently after receiving the ota update 6.3.0 and now remains in off-road mode with a reduced esc state after cycling the ignition. If the vehicle operator does not notice the esc off telltale in the cluster, they may not know the vehicle is in a reduced esc state. For these vehicles, failing to revert back to a normal esc-on state after being in off-road mode makes the vehicles noncompliant to fmvss no. 126, increasing the risk of crash. Remedy The remedy for this program is a software update to accessory protocol interface module apim. Ford began Ford power-up over-the-air deployments to update the apim software for affected vehicles in November 2023. Alternatively, owners will have the option to take their vehicle to a Ford or Lincoln dealer to complete the software update. Campaign# 23B1

Runaway Throttle at least 8 times now: 1. Driving in adaptive cruise control when deactivated by manual braking (to turn into a parking lot, which is a more common scenario for a brake based shutoff) 2. Parked nose first and shut off the truck 3. Start truck and reverse out of parking space 4. Shift to drive, apply throttle gently and truck continues to accelerate when throttle released requiring a PANICKED brake application

On several occasions I have unintentionally pressed the accelerator pedal in addition to pressing the brake pedal. The brake pedal is 2 inches "higher" (closer to the driver) than the accelerator pedal in its full up position. When attempting to quickly place my foot on top of the brake pedal from the accelerator pedal, my foot hits the side of the brake pedal. This issue has resulted in several near-hit accidents with a vehicle in front of me. The rapid acceleration of the Ford Lightning reduces response time to correct the braking disruption. The brake pedal may be placed higher to prevent the driver from also depressing the accelerator when depressing the brake. Other vehicles also have a higher brake pedal, but it feels like an unusually high foot lift is required in the Lightning. There is definitely something unusual about the brake and accelerator geometry in my Ford Lightning.

During a long road trip my truck displayed a message stating that I had a Powertrain Malfunction/ Reduced Power. My truck, while driving, reduced itself to half power. It also would not charge. I was 3 states away from home when this happened. I took the vehicle to my Ford dealership once I was able to get it home. The technician simply cleared a code and said that the issue could not be replicated. Clearly there is an issue. I know several people with the same issue. Frankly, I don't think that I can trust my new truck a significant distance from my residence.

I placed groceries in my front trunk “Frunk” and they shifted while trying to leave. Once shifted they hit the emergency release button inside the frunk which opened the frunk hood unexpectedly. These should be covered or less accessible inside the frunk.