2011 FORD F-250 Complaints

TL* THE CONTACT OWNS A 2011 FORD F-250. WHILE DRIVING OVER 60 MPH, THE VEHICLE SHOOK AND THE STEERING WHEEL LOCKED. WHILE THE BRAKE PEDAL WAS DEPRESSED, THE VEHICLE SHOOK UNCONTROLLABLY. THERE WERE NO WARNING INDICATORS ILLUMINATED. THE VEHICLE WAS TAKEN TO THE DEALER (KOONS SILVER SPRING FORD, 3111 AUTOMOBILE BLVD, SILVER SPRING, MD 20904 (301) 890-6100) WHERE IT WAS DIAGNOSED THAT THE BALL JOINT, BRAKE PADS, AND STABILIZER BAR NEEDED TO BE REPLACED. ALSO, FLUID WAS LEAKING ON THE SHOCKS AND THE STRUT NEEDED TO BE REPLACED. THE VEHICLE WAS REPAIRED, BUT THE FAILURES RECURRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURES. THE FAILURE MILEAGE WAS 58,100.

TL* THE CONTACT OWNS A 2011 FORD F-250. WHILE DRIVING 35 MPH, THE VEHICLE SLOWED DOWN AND THE REAR PASSENGER AND DRIVER SIDE WHEELS SEIZED. IN ADDITION, THE TRANSMISSION WARNING INDICATOR ILLUMINATED. THE DEALER DIAGNOSED THAT THE TRANSMISSION WAS LOSING LINE PRESSURE AND NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE VIN WAS INCLUDED IN NHTSA CAMPAIGN NUMBER: 16V248000 (POWER TRAIN). THE CONTACT STATED THAT THE VEHICLE WOULD NOT ACCELERATE PAST 35-40 MPH. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS APPROXIMATELY 133,600. UPDATED 06/29/17*LJ *AS

WHEN DRIVING THIS TRUCK, IF YOU HIT A POTHOLE OR ANY UNEVEN SURFACE, THE TRUCK WILL SHAKE VIOLENTLY AND IT'S ALL OVER THE ROAD. IT TAKES ALL THE STRENGTH IN MY BODY JUST TO HOLD ONTO THE STEERING WHEEL, AND THE ONLY WAY TO STOP IT IS COME ALMOST TO A COMPLETE STOP. SOMEONE'S GOING TO GET KILLED, BECAUSE WHEN IT START TO SHAKE, YOU HAVE KNOW CONTROL OVER THE DIRECTION IT'S GOING TO GO. FROM WHAT I'VE READ ON THE NET, THIS SHAKE IS CALLED THE DEATH WOBBLE AND FOR GOOD REASONS. I ALSO HEARD THAT FORD HAD KNOWN ABOUT THIS DEFECT FOR YEARS, BUT WANT DO ANYTHING EXCEPT GIVE YOU THE RUN AROUND.

DRIVING 60 - 65MPH,WHEN I RAN OVER DIPS OR BUMPS IN THE HWY MY STEERING WHEEL AND FRONT END STARTED SHAKING AND SHIMMING VIOLENTLY AND IT WAS EXTREMELY DIFFICULT TO MAINTAIN CONTROL OF THE STEERING WHEEL. I DID NOT APPLY BRAKES BUT DID TAKE FOOT OFF GAS PEDAL AND WHEN TRUCK SPEED REACHED 40MPH VIOLENT SHAKES STOPPED. THIS IS NOT AN ISOLATED INCIDENT HOWEVER IT DOES NOT ALWAYS HAPPEN OVER ALL BUMPS OR DIPS. IT JUST HAPPENED TODAY FEB-19 2017 WHEN WE WERE PULLING OUR HORSE TRAILER AT A SPEED OF 62MPH. THIS TRUCK ONLY HAS 50,200 MILES SO IT SHOULD NOT BE WORN OUT. I CAN NOT BELIEVE THAT THE FORD ENGINEERS DO NOT KNOW ABOUT THIS PROBLEM SINCE IT IS SO DANGEROUS AND COULD CAUSE SOMEONE TO LOOSE CONTROL WHICH WOULD BE DISASTROUS WHEN PULLING A HORSE TRAILER LIKE WE DO. I WILL TAKE IT TO THE FORD DEALER HOWEVER I BET THEY WILL CHARGE ME HUNDREDS OF DOLLARS TO TRY TO FIX WHATEVER AILS THIS TRUCK WHICH I BELIEVE IS UNFAIR SINCE FORD HIRES TOP ENGINEERS TO BUILD SAFE TRUCKS.

DUE TO FAULTY/SNAPPED INJECTOR CLAMP, FORD TSB 14-0233, A FUEL INJECTOR WAS BLOWN OUT OF MY ENGINE AN SPRAYED FUEL ALL OVER THE ENGINE BAY. FORTUNATELY FOR ME I HAD JUST STARTED THE TRUCK IN MY DRIVEWAY SO IT WAS STATIONARY AND NOT HOT.

FOR THE PAST 3-4 YEARS MY TRUCK HAS EXPERIENCED THE "DEATH WOBBLE." WHEN DRIVING (STRAIGHT OR IN SLIGHT TURN) APPROXIMATELY 55 MPH OR HIGHER AND HITTING A TYPICAL BUMP IN THE ROAD, MY TRUCK BEGINS A VIOLENT SHAKING THAT STOPS WHEN I REDUCE THE SPEED ENOUGH TO REGAIN CONTROL. I HAVE ATTEMPTED REPAIRS AT TWO LOCAL FORD DEALERSHIPS AS WELL AS A LOCAL REPAIR SHOP, BUT NOTHING DONE HAS CORRECTED THE ISSUE. *TR

WHEN HITTING UNEVEN PAYMENT AT HIGHWAY SPEEDS THE FRONT TIRES AND STEERING STARTS TO SHAKE. AS SPEED DECREASES, THE WOBBLE INCREASES TO THE POINT WHERE THE VIOLENT SHAKING WILL NOT STOP UNTIL ALMOST A COMPLETE STOP. I FOLLOWED THE NHTSA RECOMMENDATION OF 65 PSI AND OTHER PRESSURES AND IT HAS NO AFFECT ON THE WOBBLE. IMO I BELIEVE THAT AS THE TIRES WEAR DOWN, THEY HAVE LESS TRACTION ON THE ROAD SURFACE WHICH ALLOWS FOR THE OSCILLATION OF THE TIRES TO OCCUR. PUTTING ON NEW TIRES IS A BANDAID FOR A DEFECTIVE DESIGN. I HAVE HEARD THAT CHANGING THE POSITION OF THE AXLE (I BELIEVE CAMBER) CAN CORRECT THE PROBLEM. THIS CAN ONLY BE DONE WITH SHIMS. IN MY CASE, I NOTICED THAT THE SHAKING BECAME WORSE AS I SLOWED DOWN. THE NATURAL REACTION IS TO BRAKE WHEN THE WOBBLE BEGINS. I DECIDED THAT THE NEXT TIME IT OCCURRED, I WOULD SPEED UP. IT WORKS. THE WOBBLE CORRECTS ITSELF IN A FEW SECONDS AND IS NEVER NEAR AS SEVERE AS WHEN I SLOW DOWN. THIS IS A DANGEROUS CONDITION AND SHOULD BE LOOKED INTO DEEPER THAN HAS BEEN IN THE PAST. THIS HAS HAPPENED SEVERAL TIMES OVER THE PAST FEW YEARS. FORD, YOU KNOW ABOUT THIS PROBLEM.

OUR LADY OF THE LAKES ROAD IN ST. MARTIN PARISH, LOUISIANA, IS A CURVY ROAD. THE "SERVICE ADVANCE TRACK AND HILL DESCENT CONTROL, CHECK ENGINE LIGHT AND BREAK LIGHT" CAME ON. THE "!" AND THE "ABS" LIGHT CAME ON. BREAK PEDAL WAS HARD TO DEPRESS, WHILE IN MOTION. FIRE STARTED UNDER THE HOOD AND BURNT FRONT SEATS AND ENGINE ON

TL* THE CONTACT OWNS A 2011 FORD F-250 SD. WHILE DRIVING, THE "PULL OVER SAFELY NOW" WARNING INDICATOR ILLUMINATED AND THE ENGINE SHUT OFF WITHOUT WARNING. THE CONTACT WAS ABLE TO MANUALLY BYPASS THE FAILURE. THE VEHICLE WAS TOWED TO THE DEALER WHERE IT WAS DIAGNOSED THAT THE EGT SENSOR WAS DEFECTIVE AND NEEDED TO BE REPLACED. THE VEHICLE WAS REPAIRED. THE MANUFACTURER WAS NOTIFIED. THE FAILURE MILEAGE WAS APPROXIMATELY 65,000.

AT HIGHWAY SPEEDS WHEN MAKING A SLIGHT LEFT TURN WHEN ENCOUNTERING A BUMP IN THE ROAD THE FRONT SUSPENSION BEGINS SHAKING VIOLENTLY. THIS IS COMMONLY KNOWN AS THE "DEATH WOBBLE" FOR WHICH FORD HAS MANY SERVICE BULLETINS. ONCE VEHICLE SPEED IS REDUCED TO APPROXIMATELY 40 MPH SHAKING STOPS. THE PROCESS OF FIXING IS LONG AND CONSISTS OF TRIAL AND ERROR UNTIL THE MANY POSSIBLE REASONS ARE FINALLY ADDRESSED AND SPECIFIC THING FIXED. FORD SERVICE BULLETIN DISCUSSES SPECIFIC BUILD DATES OF 2011 MODEL YEAR FROM LATE 2010 - MID 2011.