2012 FORD F-250 Complaints

AT APPROX 60 TO 75 MPH UPON HITTING UNEVEN PAYMENT OR BUMPS IN ROAD THE FRONT WHEELS START AN UNCONTROLLABLE WOBBLE , STEERING WHEEL SHAKES SO BAD CAN KEEP HANDS ON TO STEER AND NO STEERING IS POSSIBLE, IF BRAKES APPLIED ONLY GETS WORST, MUST COAST DOWN TO A STOP , U CANNOT STEER. I REPLACE ALL SHOCKS AND STEERING DAMPENER, STILL HAD WOBBLE AFTER WARDS. FORDS ANSWER IS TO CARRY WEIGHT IN THE REAR, AND NOT TO DRIVE ABOVE 60 MPH. THIS IS UNSAT. I HAVE BEEN ADVISED THE CASTER SETTING WHICH IS NOT ADJUSTABLE IS ONLY 1 DEGREE FORWARD AND NEEDS TO BE 3 DEGREES FORWARD. FORD SAYS THIS MAKES IT HARDER TO TURN IN A PARKING LOT. PLEASE HELP FORD DO AM RECALL BEFORE SOMEONE GETS KILLED. IN ALL 8 OF MY WOBBLES THREE I CAME ACROSS THE CENTER LANE BEFORE I COULD STOP AND THE OTHERS OFF ROAD IN THE DITCH.

DEATH WOBBLE - HAVE BEEN EXPERIENCING VIOLENT SHAKING AND INSTABILITY WHILE AT SPEEDS OF 55-65 MPH. STEERING WHEEL CAN ALMOST BE SHAKEN OUT OF MY HANDS WITH A TIGHT GRIP. SOLUTION IS TO SLOW TO BELOW 25MPH. THEN START OVER. WOBBLE STARTS SOMETIMES ON ITS OWN OR IF HITTING SMALL UNEVEN SURFACE SUCH AS BRIDGE/ROAD JOINT.

STARTED MY TRUCK TO LET IT WARM UP BEFORE I TOOK IT IN TO TOWN. WENT INSIDE FOR AROUND 150 MIN, COME OUTSIDE AND I SEEN SMOKE COMING FROM MY DOORS AND AS SOON AS I OPENED IT FEOM THE PASSENGER DOOR IT WAS FULL OF SMOKE AND I SEEN A FIRE ON MY DRIVER SIDE FEINT SEAT. IT COMPLETELY BURNT MY TRUCK AND ANOTHER F250 THE WAS PARKED NEXT TO IT.

VEHICLE HAS HAD RANDOM TIMES WHEN IT JUST CUT OFF COMPLETELY OR IT IS UNABLE TO START. THIS HAS BEEN ONGOING SINCE THE VEHICLE WAS PURCHASED USED IN 2015. DEALER HAS RECENTLY IDENTIFIED A DEFECT IN THE BRB BUT THE REPAIR EXPENSE IS EXORBITANT DUE TO TIME INVOLVED.

EXPERIENCING A SEVERE FRONT END SHIMMY, ALSO KNOWN AS THE DEATH WOBBLE. I'VE REPLACED TIRES AND ALMOST ALL FRONT END COMPONENTS. THIS HAS BEEN GOING ON SINCE I BOUGHT THE TRUCK USED, AND NO ONE CAN SEEM TO CURE IT. HAPPENS WHENEVER I HIT A SMALL BUMP ON THE HIGHWAY AND IS EXTREMELY DANGEROUS AS THE TRUCK MUST BE BROUGHT TO A COMPLETE STOP TO END THE WOBBLE

TL* THE CONTACT OWNS A 2012 FORD F-250. WHILE DRIVING 45 MPH OVER A DIP IN THE ROAD, THE FRONT END OF THE VEHICLE SHOOK VIOLENTLY (DEATH WOBBLE) AND THE VEHICLE WAS UNCONTROLLABLE. ONCE THE VEHICLE WAS RESTARTED, IT OPERATED NORMALLY. THERE WERE NO WARNING INDICATORS ILLUMINATED. THE VEHICLE WAS TAKEN TO PRESCOTT BROTHERS FORD LINCOLN OF PRINCETON (1502 W PERU ST, PRINCETON, IL, (815) 875-1180) WHERE IT WAS DIAGNOSED THAT THE TIE ROD WAS WORN OUT AND THE STEERING DAMPER NEEDED TO BE REPLACED. THE VEHICLE WAS REPAIRED; HOWEVER, THE FAILURE RECURRED. THE MANUFACTURER WAS CONTACTED AND REFERRED THE CONTACT TO THE LOCAL DEALER. THE CONTACT REQUESTED THAT THE MANUFACTURER BUY BACK THE VEHICLE. THE CONTACT RESEARCHED THE FAILURE ONLINE AND FOUND THAT THE FAILURE WAS COMMON IN SEVERAL VEHICLES. THE FAILURE MILEAGE WAS 29,000. THE VIN WAS NOT AVAILABLE.

TRAVELING AT VARIOUS SPEEDS THE TRUCK FRONT VIBRATE VIOLENTLY. I HAVE TO PULL OFF THE ROAD AND STOP TO GET THE VIBRATION TO STOP. THE TIRES HAVE BEEN BALANCED AND REBALANCED. THE VEHICLE IS STILL IN THE STOCK CONFIGURATION. I HAVE APPROXIMATELY 140K MILES NOW.

OWNED TRUCK FOR LESS THAN A YEAR, I HAD LESS THAN 50,000 MILES ON TRUCK AND HAD 'DEATH WOBBLE' ON HIGHWAY MULTIPLE TIMES. AFTER A $1000+ BILL FROM THE DEALERSHIP, IT STILL HAPPENS BUT NOT TO THE SAME EXTENT AS ORIGINALLY.

MY REAR WINDOW SHATTERED ON A COLD MORNING WITH NO IMPACT. I SUSPECT THE REAR DEFROSTER WAS FAULTY. GLASS GUY SAID HE REPLACED THIS WINDOW ALL THE TIME WITH THAT COMPLAINT.

WHILE DRIVING IN SPEEDS BETWEEN 55-70 AND DRIVING OVER A BUMP, BRIDGE OR POTHOLE, MY FRONT END WOULD SHAKE VIOLENTLY; RESULTING IN NEARLY LOSING CONTROL OF THE TRUCK. I WOULD NEED TO COME TO A COMPLETE STOP IN ORDER TO END THE VIOLENT SHAKING. THIS HAPPENED NEARLY 15 TIMES WHEN DRIVING EASTBOUND ON I-40 BETWEEN NASHVILLE AND KNOXVILLE TN. I WAS LUCKY ENOUGH TO HAVE AN EMERGENCY SHOULDER AND LIGHT TRAFFIC OR ELSE IT MAY HAVE CAUSED A DEADLY ACCIDENT. I HAVE RESEARCHED THIS ISSUE AND MOST CALL IT 'DEATH WOBBLE' AND IT IS CAUSED BY THE CASTOR ANGLE OF FORDS FRONT END SUSPENSION. IT IS KNOW TO RAPIDLY WEAR BUSHINGS, JOINTS AND BEARINGS THAT COULD ULTIMATELY CAUSE LOSS OF TOTAL CONTROL OF A HEAVY DUTY VEHICLE. MULTIPLE TSB HAVE BEEN ISSUES FOR OTHER YEAR OF SUPERDUTY TRUCKS AND ALL HAVE STATED TO REPLACE WORN TRACK BARS, TIE ROD ENDS, STEERING STABILIZERS AND ADJUST THE CASTOR ANGLE.