2000 FORD F-250 Complaints

CERTIFIED LTR REQUESTING NHTSA INITIATE A DEFECT INVESTIGATION RE SELECTED FORD MOTOR COMPANY VEHICLES LEFT FRONT INNER BEARINGS FOR ADVANCED FATIGUE CRACKS. *TS COMPLAINANT WAS RECENTLY ASKED TO CONSULT IN THE MATTER OF A FATAL HIGH SPEED HEAD ON TWO-VEHICLE COLLISION. WHILE DRIVING WESTBOUND 2001 FORD EXPEDITION VEERED INTO THE ONCOMING LANE AND STRUCK AN EASTBOUND 2000 FORD F250 LONG BED TRUCK TOWING A 5TH WHEEL TRAVEL TRAILER. THE RESULTING COLLISION KILLED THE THREE OCCUPANTS IN THE 2001 EXPEDITION AND THE TWO OCCUPANTS IN THE 2000 FORD F250 PICKUP TRUCK. THE PICK UP TRUCK AND TRAILER WERE COMPLETELY ENGULFED IN FLAMES UPON OFFICER'S ARRIVAL. METALLURGICAL ANALYSIS SHOWED THAT THE LEFT FRONT INNER BEARING FAILED ON THE EXPLORER AS A RESULT OF PROGRESSIVE FATIGUE. THE BEARING FAILURE OCCURRED AT APPROXIMATELY 30,000 MILES. PLEASE REFERENCE ODI# 10139931 TO OBTAIN INFORMATION ON THE 2001 FORD EXPEDITION. *NM

FIRST, I LOVE MY TRUCK, BUT IF I DIDN'T HAVE AN EXTENDED WARRANTY, IT BE DOWN THE ROAD. ITEMS EITHER REPAIRED OR REPLACED ALL BEFORE 47K MILES (NOW HAS 49K MILES AS OF 10/2005) WITH ALL WORK BEING DONE AT MY LOCAL FORD DEALERSHIP: AUTOMATIC TRANSMISSION WAS REPLACED ONCE, AND AGAIN REQUIRED REPAIR FOR BROKEN PUMP. REAR END COMPLETELY REPLACED. AUTO FRONT LOCKING HUBS REPLACED TWICE. REAR DRIVELINE WAS REPLACED. AIR BOX BROKEN AND REPLACED. "SUPER DUTY DIESEL" IMPLIES A REALLY TOUGH TRUCK, BUT I BABY MINE - IS THAT WHAT I'M DONE WRONG? *JB

DT: THE CONTACT STATED THE FRONT BALL JOINTS ON FORD, F250 SUPER DUTY WERE DEFECTIVE BACK IN AUGUST. THE TRUCK STARTED WALKING ALL OVER THE ROAD ON AUGUST 1, 2005. CHANGED THE BALL JOINT AT THE END OF AUGUST. THE TRUCK ONLY HAD 68,000 MILES ON IT THEN. HE REPORTED HAVING NO PROBLEMS SINCE CHANGING THEM IN AUGUST. THE DEALERSHIP TOLD THE CONTACT THERE WERE NO RECALLS ON IT. THE CONTACT HAS NOT YET TALKED TO THE MANUFACTURER. THE CONTACT DID HAVE TO PAY FOR THE PARTS, HE DID THE LABOR HIMSELF.*AK

DRIVING HOME IN MY 2000 F250 V10 GAS AND SOUNDED LIKE EXHAUST HAD BROKEN CHECKED UNDER HOOD AND FOUND SPARK PLUG HAD BLOWN OUT OF PASSENGER SIDE FOURTH PLUG FROM FRONT THIS IS THE THIRD PLUG I HAVE LOST IN 194,000 MILES FIRST WAS AT ABOUT 80,000 HAD TO BE HELICOILED SECOND WAS AT ABOUT 125,000 CAME LOOSE ? AND NOW THE THIRD TIME AT 194,000 RIPPED OUT THREADS AGAIN WHAT'S GOING ON WITH THESE FORD TRUCKS IM GETTING TIRED OF PAYING FOR THEIR POOR DESIGN. *NM

WHILE PULLING MY FIFTH WHEEL TRAILER, AT 5:30 A.M., 68 DEGREE TEMPERATURE, TRAVELING AT 55 TO 60 MILES PER HOUR, THE RIGHT FRONT TIRE TREAD SEPARATED FROM TIRE AND BENT THE RIGHT FRONT FENDER, BROKE THE RIGHT RUNNING BOARD, AND DAMAGED THE BUMPER. THE TIRE REMAINED INFLATED. I SENT THE DEFECTIVE TIRE TO FIRESTONE/BRIDGESTONE AND THEY SAID THE STEELTEX R4S, LT 265-75R16, HAD BEEN UNDER-INFLATED, CAUSING OVERHEATING AND THE SUBSEQUENT SEPARATION. THEY WOULD NOT REPLACE OR REPAIR ANYTHING IN THIS SITUATION. I DO NOT AGREE WITH THEM IN REGARD TO THE INFLATION PRESSURE THAT THEY SAY CAUSED THE SEPARATION. I AM VERY CONSCIENTIOUS ABOUT MAINTAINING TIRE PRESSURE DUE TO TOWING A 10,000 POUND TRAILER. THE PRESSURES MAINTAINED WERE 55 PSI(NO TRAILER WEIGHT) AND 75 PSI(WITH TRAILER WEIGHT). THIS IS VERY IMPORTANT AND I AM OFFENDED THAT THEY WOULD CLAIM OTHERWISE. I REPLACED THE DEFECTIVE TIRE AND HAVE IT AND THE OTHER THREE TIRES AVAILABLE FOR TESTING. *JB

DT: THE CONSUMER STATED THE BRAKE LINE FAILED AND RUSTED IN TWO. THE OTHER TWO LINES WERE LIKE BRAND NEW. THE ONE THAT WAS RUSTED MUST BE MADE OUT OF DIFFERENT MATERIAL. THE VEHICLE FAILED ON THE HIGHWAY WHILE DRIVING AT 55 MPH. THE BRAKES JUST COMPLETELY FAILED. THIS HAPPENED ON 9-17-05. THE DEALER SAID THAT THERE WAS NOTHING THEY COULD DO ABOUT IT. THE MANUFACTURER SAID THE SAME THING. THE CONSUMER REPORTED NO PROBLEMS PRIOR TO THIS. *AK (11/17/05) *SC

MY VEHICLE BLOWS SPARK PLUGS OUT OF THE ENGINE WHILE DRIVING IN EXTREME HIGH TRAFFIC PUTTING ME AND MY PASSENGERS LIVES IN DANGER. *NM

MY 2000 F-250 SUPER DUTY HAD THE FAULTY CRUISE CONTROL DEACTIVATION BURN UP. THE F150 HAS THE RECALL BUT NOT THE 250, EVEN THOUGH ITS THE SAME FAULTY PART ON BOTH VEHICLES. THERE WAS A LOT OF SMOKE, BUT NO VISIBLE FLAMES. I WAS ABLE THE UNPLUG THE DEVICE BEFORE ANY MAJOR DAMAGE HAPPENED. *NM

DT: THE CONSUMER REPLACED THE WINDSHIELD WIPER MOTOR TWICE. THE DEALERSHIP TOLD HIM THAT THE PROBLEM WAS WITH THE BEARING ON THE MOTOR. THE FIRST WAS REPLACED IN JUNE OR JULY 2003. THE SECOND TIME IT HAD OCCURRED WAS IN AUGUST 2004, THE CONSUMER WAS UNABLE TO GET THE REPAIRS DONE UNTIL OCTOBER 2004. THE PROBLEM OCCURRED AGAIN ON 8-14-05. THE CONSUMER MADE AN APPOINTMENT TO HAVE THE REPAIRS DONE. EACH OF THESE PROBLEMS OCCURRED UNDER NO SPECIFIC CIRCUMSTANCES. AS SOON AS THE WIPERS WERETURNED ON THERE WAS A WINDING NOISE. *AK

WHILE TRAVELING MY LEFT FRONT FIRESTONE STEELTEX R4S II LT265/75/R16 SEPARATED FROM THE TIRE AND THEN BLEW OUT, CAUSING ME TO SWERVE LEFT OF CENTER, LUCKILY THERE WAS NO OTHER TRAFFIC COMING. WHEN I SENT MY TIRE TO FIRESTONE THEY HAD SAID THAT IT LOOKED LIKE SEPARATION. FIRESTONE/BRIDGESTONE STATED IN A LETTER THAT THE TIRE WAS OVER LOADED. THE TIRE IS OEM FOR MY 2000 FORD F-250. THE TIRES ON FRONT WE REPLACED FULL COST TO ME WITH TRANSFORCE. *NM