2008 FORD F-250 Complaints

TL*THE CONTACT OWNS A 2008 FORD F-250 SD. THE CONTACT STATED THAT HE RECEIVED NOTIFICATION OF A MANUFACTURER'S RECALL AND TOOK THE VEHICLE TO THE DEALER FOR RECALIBRATION. AFTER THE RECALL SERVICE, THE CONTACT WAS DRIVING APPROXIMATELY 50-60 MPH WHEN THE TRANSMISSION STARTED TO SLIP. THE VEHICLE WAS TAKEN BACK TO THE DEALER WHERE THEY ADVISED THE CONTACT THAT HE WOULD HAVE TO DRIVE THE VEHICLE AROUND FOR A WHILE UNTIL IT FUNCTIONED NORMALLY. THE MANUFACTURER WAS CONTACTED AND OFFERED NO ASSISTANCE. THE FAILURE MILEAGE WAS APPROXIMATELY 14,545. THE CURRENT MILEAGE WAS APPROXIMATELY 17,344. THE CONSUMER STATED WHILE DRIVING AT AN ESTIMATED SPEED OF 50-60 MPH AND ATTEMPTING A FORCED DOWN SHIFT, THE TRANSMISSION SHIFTED INTO 3RD GEAR INSTEAD OF 4TH GEAR CAUSING RAPID REAR WHEEL DECELERATION AND HIGH ENGINE RPM TO OCCUR. IT OCCURRED IMMEDIATELY FOLLOWING SERVICING OF THE PCM PER THE MANUFACTURER'S RECALL. THE DEALER ADVISED THE CONSUMER TO DRIVE THE VEHICLE UP TO 500 MILES WHILE THE TRANSMISSION RE-LEARN ITS SHIFT TO POINTS. AFTER COMPLYING WITH THE DEALERS REQUEST, THE CONSUMER CONTINUED TO EXPERIENCE THE PROBLEM. THE DEALER INFORMED THE CONSUMER THERE WAS NOTHING WRONG WITH THE TRANSMISSION AND IT WAS PERFORMING AS DESIGNED. UPDATED 12/19/12.. UPDATED 12/31/12 *BF UPDATED 1/3/2013 *JS

I WAS ON MY WAY TO THE BUILDING SUPPLY WITH THE TRUCK. I WAS TOWING A SMALL UTILITY TRAILER. AS I APPROACHED A FAIRLY SHARP CURVE I APPLIED THE BRAKES AND THE PEDAL WENT TO THE FLOOR. THE TRUCK BRAKES WERE GONE WITHOUT WARNING. THE TRAILER BRAKES LOCKED AND SLOWED THE VEHICLE ENOUGH TO GET SAFELY THROUGH THE TURN. I RELIED ON THE TRAILER BRAKES AND THE TRANSMISSION TO COMPLETE THE TRIP AND GET THE VEHICLE SAFELY HOME. WHEN I GOT HOME I CALLED THE DEALER AND HAD THE TRUCK TOWED THERE FOR REPAIR. THE DEALER SAID THAT THE FAILURE WAS DUE TO BADLY WORN BRAKE PADS CAUSING THE CALIPERS TO OVEREXTEND AND A CALIPER PISTON SEAL HAD FAILED. PADS ON ALL 4 WHEELS WERE BADLY WORN. IT WAS THE LEFT REAR CALIPER THAT FAILED. I DO NOT UNDERSTAND HOW THE BRAKES CAN BE THIS BADLY WORN AFTER ONLY 21,000 MILES.

DRIVING 65MPH AND CHANGING LANES POWER STEERING WAS LOST AS WELL AS POWER BRAKING. AFTER FIGHTING THE WHEEL HARD TO STRAIGHTEN OUT AND BRAKING HARD I FINALLY EASED OVER TO A STOP. WHEN STOPPED DISCOVERED THE SERPENTINE BELT HAD BROKEN, SECOND ISSUE IN 20K MILES WITH SAID BELT. BELT AND TENSIONER WERE REPLACED 1.5 YEARS AND 20K MILES PRIOR. TENSIONERS DESTROYING BELTS ARE A KNOWN FAULT WITH 6.4L ENGINES. I AM NOT A SMALL GUY AND I FEEL MANY WOULD NOT HAVE BEEN ABLE TO GET THE TRUCK UNDER CONTROL WITH NO POWER STEERING OR BRAKES. LUCKILY I WAS NOT TOWING AT THE TIME OR I WOULDN'T HAVE HAD CONTROL. *TR

TL* THE CONTACT OWNS A 2008 FORD F-250 SD. THE CONTACT STATED THAT WHILE DRIVING APPROXIMATELY 10 MPH, HE NOTICED THE STEERING WHEEL FELT LOOSE AND MOVED TO THE SIDES INDEPENDENTLY. THE VEHICLE WAS TAKEN TO THE DEALER WHO STATED THAT THE STEERING BOX NEEDED TO BE REPLACED. THE VIN WAS NOT AVAILABLE. THE VEHICLE WAS NOT REPAIRED. THE APPROXIMATE FAILURE MILEAGE WAS 29,107.

AFTER A 10 MILE TRIP , GOT TO MY HOME AND REAR DRIVER BRAKE WAS SMOKING. I HAD CONTINUALLY COMPLAINED TO LOCAL FORD DEALERSHIP ABOUT EXCESSIVE HEAT I.E. YOU COULD HEAR CRACKLING AFTER PARKING THE VEHICLE. I BOUGHT A CENTEC HAND LASER HEAT TEMPERATURE LCD GUN AND DEMONSTRATED TO THE FORD SERVICE MANAGER THAT ALL DISCS HAD EXCESSIVE HEAT. THEY CLAIMED THEY SERVICED THE BRAKES. CONTINUALLY BLAMED THE NEW YORK WINTER AND SALT. SINCE I GOT MY LAST SERVICE SATISFACTION SURVEY SHORTLY AFTER THIS SMOKING INCIDENT, I WROTE THAT FORD SHOULD RECALL THESE TRUCKS FOR THIS PROBLEM SINCE THE DEALERSHIPS EITHER CANNOT FIX THE PROBLEM OR WAIT TILL THE WARRANTY IS UP(IS FORD ITSELF COVERING UP?) I REPLACED THE CALIPER MYSELF IN MY YARD SINCE I FELT IT WAS UNSAFE. THE PISTONS IN THESE CALIPERS FREEZE UP DUE TO A MANUFACTURER DEFECT. *TR

TL* THE CONTACT OWNS A 2008 FORD F250. THE CONTACT STATED THAT WHILE DRIVING 65 MPH, THE VEHICLE BEGAN MAKING NOISES AND STALLED PERIODICALLY. THE VEHICLE WAS TAKEN TO A DEALER FOR DIAGNOSIS AND THE CONTACT WAS INFORMED THERE WAS A COOLING SYSTEM LEAK AND THE RADIATOR AND HOSES WOULD NEED TO BE REPLACED WITH HIGHER GRADE HOSES AND TANKS. THE VEHICLE WAS REPAIRED. THE MANUFACTURER WAS NOTIFIED BUT OFFERED NO ASSISTANCE. THE FAILURE MILEAGE WAS 67,730 AND THE CURRENT MILEAGE WAS 68,000.

TL* THE CONTACT OWNS A 2008 FORD F-250 SD. WHILE DRIVING APPROXIMATELY 50 MPH, THE TURBO ENGINE STALLED WITH AN ILLUMINATION OF A WARNING INDICATOR. THE VEHICLE BEGAN TO PERFORM ROUGHLY WITH SMOKE AND FLAMES EMITTING FROM THE EXHAUST. WHEN THE ENGINE WAS TURNED OFF THE FLAMES WERE NO LONGER VISIBLE. THE VEHICLE WAS TOWED TO AN AUTHORIZED DEALER WHO STATED THE TURBO CHARGER WOULD NEED TO BE REPLACED AND INCLUDING OTHER DEFECTIVE PARTS. THE FAILURE WAS RELATED TO THE RECALL ASSOCIATED WITH NHTSA CAMPAIGN ID NUMBER 07V139000 (POWER TRAIN: AUTOMATIC TRANSMISSION: CONTROL MODULE (TCM, PCM)). THE CONTACT EXPERIENCED THE IDENTICAL DEFECT AS STATED IN THE RECALL. THE MANUFACTURER WAS NOTIFIED AND THEY INFORMED THE CONTACT THAT THE VIN WAS NOT INCLUDED IN THE RECALL. THE VEHICLE WAS NOT REPAIRED. THE APPROXIMATE FAILURE MILEAGE WAS 70,000. UPDATED 11/01/12*LJ

TL* THE CONTACT OWNS A 2008 FORD F250. THE CONTACT STATED THAT WHILE DRIVING APPROXIMATELY 10 MPH, THE CHECK THE EXHAUST FILTRATION SYSTEM WARNING MESSAGE APPEARED ON THE INSTRUMENT PANEL AND SUDDENLY THE ENGINE STALLED. THE VEHICLE FAILED TO RESTART WAS TOWED TO A SAFER LOCATION WHERE THE BATTERY WAS DISCONNECTED AND RECONNECTED. THE VEHICLE WAS ABLE TO RESUME IN OPERATION. THE VEHICLE WAS THEN TAKEN TO AN INDEPENDENT MECHANIC WHO DIAGNOSE THAT THE EXHAUST FILTRATION SYSTEM SENSOR WAS DEFECTIVE AND NEEDED TO BE REPLACED. THE VEHICLE WAS REPAIRED. THERE WAS A RECALL UNDER NHTSA CAMPAIGN ID NUMBER 07V139000 (POWER TRAIN:AUTOMATIC TRANSMISSION:CONTROL MODULE (TCM, PCM); HOWEVER THE VIN WAS INELIGIBLE. THE MANUFACTURER WAS NOTIFIED OF THE PROBLEM. THE APPROXIMATE FAILURE MILEAGE WAS 53,000. UPDATED 11/16/12*LJ UPDATED 11/20/2012 *JS THE CONSUMER WAS INFORMED THE PCM NEEDED TO BE RE-FLASHED. UPDATED 12/19/12

I AM FILING A COMPLAINT HERE AS FORD CUSTOMER CARE REFERENCED YOU IN ONE OF THEIR RESPONSES TO ME. MY PICKUP WITH 24,000 MILES ON IT BLEW OUT THE TANK ON THE RADIATOR. THIS COULD REFLECT AS A SAFETY ISSUE FROM BEING STRANDED. FROM TALKING TO THE SERVICE PEOPLE AT LEWIS AND CLARK FORD IN YANKTON SD WHERE I HAD TO BE TOWED TO IT SOUNDS LIKE THIS IS A COMMON OCCURRENCE. I ALSO HAVE DONE A LITTLE RESEARCH ON LINE AND IN A SHORT TIME FOUND APPROXIMATELY 40 CASE SO I AM SURE THERE ARE MANY MORE. ANY HELP YOU COULD GIVE ME WITH THIS ISSUE WOULD BE APPRECIATED. *TR

WHILE TOWING A 10,000 POUND 5TH WHEEL TRAILER I NEEDED TO SPEED UP TO MERGE INTO THE LEFT LANE. THE TRUCK WAS ON CRUISE CONTROL SET AT 50 MPH. I STEPPED DOWN AND ENTERED PASSING GEAR. AFTER THE MERGE I LET OFF THE THROTTLE BUT THE TRUCK CONTINUED TO ACCELERATE IN PASSING GEAR. I STEPPED ON THE BRAKES BUT THE CRUISE CONTROL WOULD NOT RELEASE AND THE TRUCK CONTINUED TO ACCELERATE. I TRIED REPEATEDLY TO DISENGAGE THE CRUISE USING THE BRAKES. I THEN PRESSED THE CRUISE CONTROL "OFF" BUTTON REPEATEDLY TO NO AVAIL. AT THIS POINT I PRESSED AND HELD THE BRAKE PEDAL AS HARD AS I COULD WHILE THE DIESEL ENGINE CONTINUED TO RACE AT MAX POWER. I WAS ABLE TO SLOW TO ABOUT 30 MPH BEFORE THE ENGINE STARTED TO OVERCOME THE FADING BRAKES. AT THIS POINT I TURNED THE KEY OFF AND COASTED TO A STOP. I TRIED TO RESTART THE ENGINE TWICE AND IT IMMEDIATELY STARTED AT MAX THROTTLE AND I IMMEDIATELY TURNED THE KEY OFF. I CALLED FORD FOR A TOW. AFTER ABOUT 20 MINUTES I TRIED TO RESTART THE ENGINE AND IT STARTED NORMALLY SO I CANCELLED THE TOW. THE TRUCK SEEMS TO BE WORKING NORMALLY AND CRUISE ALSO WORKS NORMALLY. I HAVEN'T TRIED TO ENTER PASSING GEAR WHILE IN CRUISE AND WON'T AS THIS INCIDENT ALMOST CAUSE ME TO HAVE A CATASTROPHIC ACCIDENT. I PLAN TO TAKE THE TRUCK TO THE DEALER TO BE ANALYZED. THIS WAS A MAJOR SAFETY PROBLEM AND COULD EASILY HAVE CAUSED A FATAL ACCIDENT. *TR