2008 FORD F-250 Complaints

1/1/10 ISN'T THE FIRST SMOG-OUT, BUT DEFINITELY THE WORST & MOST DANGEROUS. WHILE DECENDING FROM THE TOP OF THE MOUNTAIN IN GATLINBURG IN BUMPER TO BUMPER TRAFFIC WHERE IT TOOK 45-60 MINS TO GO 2 MILES, THE EXHAUST CLEANING WAS BLOWING SUFFOCATING AND BLINDING BLUE SMOKE CONTINUOUSLY. THEN GOING THROUGH TOWN WHERE PEOPLE ARE WALKING UP & DOWN BESIDE THE ROAD (STILL IN BUMPER TO BUMPER TRAFFIC) IT WAS STILL SMOGGING THE PEOPLE WALKING AND PEOPLE DRIVING BEHIND ME COULD NOT SEE. IF A MOTORCYCLE OR PERSON ENDED UP BESIDE US WHEN WE HAD TO STOP FOR TRAFFIC LIGHTS, THEY WOULD HAVE BEEN SEVERELY BURNED. IT CONTINUED TO CLEAN DOWN TO PIGEON FORGE FOR A TOTAL OF 1-1/2 TO 2 HOURS. FORD ENGINEER WAS SUPPOSED TO RECALIBRATE TO MAKE SURE IT DIDN'T CLEAN IF UNDER 35 MPH, BUT IT DOES IT ALL THE TIME, SOMETIMES DAY AFTER DAY FOR HOURS. *TR

TL* THE CONTACT OWNS A 2008 FORD F-250 EQUIPPED WITH CONTINENTAL CONTITRAC TR SIZE LT275/70/R18 TIRES. THE CONTACT STATED THAT THE VEHICLE BEGAN TO SHAKE WHILE DRIVING 70 MPH. THE VEHICLE WAS TAKEN TO AN AUTHORIZED DEALER AND THE CONTACT WAS INFORMED THAT THE TREAD WAS SEPARATING ON THE FRONT DRIVER'S SIDE TIRE. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE AND INFORMED THE CONTACT THAT THE TIRES WERE NOT INCLUDED IN THE RECALL ASSOCIATED WITH NHTSA CAMPAIGN ID NUMBER 11T002000 (TIRES:TREAD/BELT). THE MANUFACTURER OFFERED TO REPLACE THE FAILED TIRE, BUT NOT THE REMAINING TIRES. THE FAILURE MILEAGE WAS 23,800.

ALL 4 TIRES ON MY TRUCK HAVE SUBSTANTIAL CRACKING ALL THE WAY AROUND WHERE THE TREAD IS ATTACHED TO THE TIRE CARCASS. THE TREAD HAS CRACKS IN IT AS WELL. THE TIRES HAVE BEEN IN SERVICE 30 MONTHS. *TR

I BOUGHT MY TRUCK IN NOVEMBER 2008 BRAND NEW. AT APPROXIMATELY 13000 MILES I HAD MY RIGHT FRONT BRAKE CALIPER FREEZE UP. I WAS ON MY WAY HOME FROM WORK PULLED IN MY DRIVEWAY GOT OUT AND SAW SMOKE COMING FROM AROUND MY LEFT FRONT WHEEL. I TOOK IT IN TO THE DEALERSHIP THE FOLLOWING DAY AND THE DEALERSHIP HAD TO INSTALL A NEW CALIPER, PADS AND ROTOR. THIS WAS ALL DONE UNDER WARRANTY, UNFORTUNATELY THIS SAME THING HAS HAPPENED 3 MORE TIMES - ONCE ON THE RIGHT FRONT,ONCE ON THE RIGHT REAR, AND AGAIN ON THE LEFT FRONT. THE LAST TIME WAS AT 48000 MILES AND I HAD TO PAY FOR THE REPAIRS BECAUSE I WAS OUT OF WARRANTY. EVERY INCIDENT WAS THE SAME WITH THE RESULTING REPAIRS BEING THE SAME (NEW CALIPER, NEW ROTOR,AND NEW PADS. I HOPE THAT SOMETHING CAN BE DONE TO MAKE FORD REMEDY THIS SITUATION BEFORE SOMEONE GETS HURT. LIVING IN MICHIGAN I DRIVE ON SLIPPERY ROADS AND IF THIS WERE TO HAPPEN ON SLIPPERY ROADS I FEAR WHAT THE OUTCOME OF THE INCIDENT MAY BE. THIS I FEEL IS A VERY UNSAFE CONDITION, I PULL A 34 FOOT FIFTHWHEEL CAMPER AND WOULD NOT WANT TO EXPERIENCE THIS WHILE PULLING IT. I KNOW OF AT LEAST 5 OTHER TRUCKS WITH THIS SAME PROBLEM RANGING IN YEARS FROM 2005 TO PRESENT. IRONICALLY FORD HAS ISSUED A TSB ON THE 2010-2011 FORD SUPERDUTY FOR THIS EXACT PROBLEM. I BELIEVE THEY NEED TO EXPAND THE TSB OR ISSUE A RECALL ON ALL OF THESE TRUCKS. I AM ON THE VERGE OF GETTING RID OF MY TRUCK BECAUSE I FEEL IT IS NOT REAL SAFE TO DRIVE.HOPEFULLY SOMETHING WILL BE DONE ABOUT THIS. *TR

TL* THE CONTACT OWNS A 2008 FORD F-250. WHILE PARKED, THE CONTACT ATTEMPTED TO REFUEL THE VEHICLE BUT THE VEHICLE WOULD NOT ACCEPT THE FUEL. THE FUEL DID NOT SPILL. THE VEHICLE WAS TAKEN TO THE DEALER FOR DIAGNOSTICS. THE TECHNICIAN STATED THE FUEL VENT FUEL TUBE FAILED AND HAD TO BE REPLACED. THE PART WAS UNAVAILABLE FOR REPAIR. THE VEHICLE WAS NOT REPAIRED. THE APPROXIMATE FAILURE MILEAGE WAS 40,000.

TL* THE CONTACT OWNS A 2008 FORD F-250 SD EQUIPPED WITH GOODYEAR WRANGLER AT/S TIRES, LINE SIZE LT275/65R20, AND DOT NUMBER:MK0TBXWV. THE CONTACT STATED THAT THE MOUNT WAS SEPARATING FROM THE TIRE. THE DEALER WAS CONTACTED AND OFFERED TO DIAGNOSE THE FAILURE BUT THE CONTACT DECLINED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE VEHICLE WAS NOT REPAIRED. THE FAILURE AND CURRENT MILEAGE WAS 44,000.

TL* THE CONTACT OWNS A 2008 FORD F-250 SD. THE CONTACT WAS DRIVING 70 MPH WHEN SMOKE EMITTED FROM THE REAR DRIVER SIDE WHEEL. THE VEHICLE WAS TAKEN TO THE DEALER WHO DIAGNOSED THAT THE BRAKE CALIPERS WERE DEFECTIVE AND CAUSED THE BRAKE SYSTEM TO OVERHEAT. AS A RESULT, THE BRAKE ASSEMBLY HAD TO BE REPLACED. THE CONTACT MENTIONED HE HAD TO REPLACE THE BRAKE ASSEMBLY A TOTAL OF THREE TIMES. THE MANUFACTURER WAS NOT MADE AWARE OF THE RECURRING PROBLEM. THE FAILURE MILEAGE WAS 40,000 AND CURRENT MILEAGE WAS 50,000. UPDATED 10/5/11 *CN UPDATED 10/24/11

ONE OF 4 CONTINENTAL CONTITRAC LT 275/65 R 18 TIRES, DOT # P5B9 1VUB, HAS MULTIPLE (14+) TINY AIR LEAKS THROUGH THE TREAD OF THE TIRE. THERE IS NO APPARENT DAMAGE TO THE TIRE OR TREAD. THE TIRES HAVE JUST UNDER 30,000 MILES ON THEM. THEY ARE THE ORIGINAL EQUIPMENT TIRES THAT CAME WITH MY 2008 FORD F250 2WD MANUAL TRANSMISSION DIESEL CREW CAB PICK UP WHICH WAS PURCHASED NEW. *TR

MY COMPLAINT REGARDS A DEFECTIVE CONTINENTAL CONTITRAC LT275/65R18 TIRE ON A 2008 FORD F250 SUPER DUTY PICK-UP. ONE OF THE ORIGINAL OEM TIRES DEVELOPED A SHIFTED BELT / SEPARATION AT 43,910 MILES W/ 9/32" OF TREAD LEFT ON THE TIRE. CONTINENTAL HAS AN ONGOING VOLUNTARY RECALL PROGRAM FOR LT275/70R18 TIRES ON 2008 TO 2009 FORD F250 AND F350 VEHICLES. THE DEFECT IN MY TIRE IS ALSO ONE OF THE DEFECTS LISTED FOR THE LT275/70R18 TIRE RECALL. I BELIEVE CONTINENTAL HAS ADDITIONAL TIRES OUTSIDE OF THE DOT DATE CODE WHICH, MAY NOT MEET CONTINENTAL'S PERFORMANCE EXPECTATIONS IN THE FIELD AND MAY WARRANT AN ADDITONAL REVIEW FOR SAFETY BY THE NHTSA. *TT

I CAME HOME FROM WORK, SHUT MY VEHICLE OFF, CLIMBED OUT AND NOTICED THAT SOMETHING WAS DRIPPING FROM THE FRONT END. GOT UNDER AND FOUND THAT THE RADIATOR WAS LEAKING AND AT A PRETTY GOOD RATE. I CALLED THE DEALERSHIP TO ASK DETAILS ABOUT IT AND AGREED TO DROP IT OFF THE NEXT DAY. I HAD TO REFERENCE THEM TO A TSB 09-23-1 CONCERNING THE RADIATOR LEAK DUE TO A HYPER EXTENDED THERMOSTAT. A COUPLE OF DAYS LATER I GET A CALL AND WAS TOLD THAT THE THERMOSTAT "SEEMS" TO BE FINE AND THAT I WOULD HAVE TO BEAR THE COST OF THE RADIATOR REPLACEMENT AT $1400. FORD REPLACED THESE RADIATORS IN JOB 1 TRUCKS IF THEY WERE LEAKING AT THE TIME THE VENTURI TEE WAS BEING INSTALLED IN THE COOLING SYSTEM. I HAD THE RECALL DONE BUT IT WASN'T LEAKING AT THE TIME. I HAVE 37K MILES ON IT. I'VE NEVER OVER HEATED IT, OVER SPED IT AND I TAKE CARE OF MY VEHICLE. THE FORD DEALERSHIP IS TELLING ME THAT IF THEY REPLACED THE PARTS, SENT THEM TO FORD AND FORD FOUND THEY WERE STILL GOOD, I WOULD THEN GET BILLED BACK LATER. AS OF RIGHT NOW, I HAVE NOT HAD THEM CONTINUE WITH THE WORK ON THE TRUCK. THE MAIN REASON IS BECAUSE THAT IS A COSTLY REPAIR AND I FEEL THAT FORD SHOULD COVER THIS KNOWING IT'S A PROBLEM. THERE WAS A RECALL AS I STATED EARLIER, AND AT LEAST 2 TSB'S STATING THAT THEY KNOW IT'S A PROBLEM. IT'S DISAPPOINTING THAT FORD IS STICKING IT TO PEOPLE LIKE ME FOR A DEFECTIVE PART. IT'S CRACKED AND NO ONE CAN TELL ME HOW IT CRACKED. WHEN ASKED, THE SERVICE MANAGER STATED, "THAT'S THE MILLION DOLLAR QUESTION." WHAT MAKES THIS EVEN WORSE, I'M ACTIVE DUTY MILITARY AND AM PREPARING FOR A DUTY STATION MOVE IN AUGUST. I BOUGHT THE VEHICLE TO TOW MY RV AND FAMILY OF 5, NOT FOR IT TO BREAK AND NO APPARENT REASON FOR IT BESIDES THE DEFECTIVE PART THAT FORD KNOWS ABOUT. *TR