2012 FORD F-250 Complaints

TL* THE CONTACT OWNS A 2012 FORD F-250. WHILE DRIVING APPROXIMATELY 40 MPH, THE VEHICLE STALLED AND A "STOP VEHICLE" MESSAGE APPEARED ON THE INSTRUMENT PANEL. THE VEHICLE WAS TOWED TO THE DEALER WHERE IT WAS DIAGNOSED THAT THE EXHAUST SENSOR NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS UNKNOWN.

I HAVE EXPERIENCED TWICE NOW WITH MY 2012 F-250 SUPER DUTY WITH THE 6.7 DIESEL ENGINE. ON FRIDAY JANUARY 22ND AND WAS SIMILAR TO A PREVIOUS EVENT INVOLVING A SUDDEN AND UNEXPECTED ACCELERATION OF MY TRUCK WHILE IN DRIVE. BOTH INSTANCES HAVE OCCURRED FROM THE TRUCK BEING IN A PARKED POSITION WITH THE ENGINE OFF. UPON STARTING THE TRUCK AND SHIFTING INTO DRIVE, I BEGIN TO PULL FORWARD APPROXIMATELY 20 TO 40 FEET AND PREPARE TO STOP PRIOR TO ENTERING TRAFFIC OR REPOSITIONING. THE TRUCK WILL SUDDENLY ACCELERATE AND LUNGE FORWARD. FORTUNATELY IN BOTH INSTANCES MY RIGHT FOOT IS LIGHTLY ON THE BREAK PREPARING TO STOP WHEN THIS HAPPENS. I IMMEDIATELY DEPRESS THE BRAKE WITH A CONSTANT AND HARD PRESSURE AS THE TRUCK'S RPM IS IN THE 2500 TO 3000 RANGE AND I CAN FEEL THE TRUCK WANTING TO SURGE FORWARD. THE FIRST TIME THIS OCCURRED I HAPPENED TO BE PULLING UP BEHIND MY SON WHO WAS IN HIS VEHICLE AND VERY NEARLY MISSED CRASHING INTO HIM. I HAD TO IMMEDIATELY SHIFT INTO NEUTRAL AND SHUT THE TRUCK OFF. ON THE SECOND OCCASION I WAS REPOSITIONING AROUND A VEHICLE WHEN AGAIN THE TRUCK UNEXPECTEDLY ACCELERATED AND I CAME WITH 6 TO 8 FEET OF IMPACTING A CONCRETE LIGHT POST BASE. UPON SHIFTING INTO NEUTRAL THE TRUCK REVVED UP TO APPROXIMATELY 3500 TO 4000 RPM AND AGAIN I SHUT THE TRUCK OFF. AFTER BOTH INSTANCES THE TRUCK WAS RESTARTED AND APPEARED TO DRIVE NORMALLY. IN BOTH CASES THE SERVICE CENTER WAS UNABLE TO IDENTIFY THE CAUSE AND RELATED THAT THEY DID NOT FIND ANY 'ERROR CODES' OR OTHER ELECTRONIC RECORDED EVENTS RELATING TO WHAT I HAVE EXPERIENCED AND AGAIN THE PCM WAS REPROGRAMMED. THE TRUCK IS STILL UNDER WARRANTY AND CURRENTLY HAS ONLY 20064 MILES ON IT.

TL* THE CONTACT OWNS A 2012 FORD F-250. WHILE DRIVING 40 MPH, THE FRONT END OF THE VEHICLE SHOOK AND BECAME DIFFICULT TO CONTROL. THE FAILURE OCCURRED CONSTANTLY. THE VEHICLE WAS TAKEN TO A DEALER WHERE IT WAS DIAGNOSED THAT THE DRAG LINK AND THE BALL JOINTS NEEDED TO BE REPLACED. THE VEHICLE ALSO NEEDED A FRONT END ALIGNMENT. THE REPAIRS WERE DONE; HOWEVER, THE FAILURE RECURRED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 3,000.

EGT FAILURE CAUSES TRUCK TO LOSE POWER AND SHUT DOWN ON SIDE OF ROAD. THIS HAS HAPPENED ON TWO DIFFERENT TRUCKS OF THE SAME MODEL & YEAR.

BOUGHT VEHICLE WITH 89,000 MILES IN 2013; CURRENTLY HAVE 124,000 MILES. ABOUT 3 MONTHS AGO, VEHICLE STARTED A SHAKE IN STEERING, LASTING 1-2 SECONDS, WHENEVER A LARGE POTHOLE/BUMP ON 11/17/2015, WHILE DRIVING APPROXIMATELY 70 MPH, THE VEHICLE STARTED THE "DEATH WOBBLE", LASTING APPROXIMATELY 30 SECONDS, UNTIL THE VEHICLE GOT SLOWED DOWN BELOW 30 MPH. CONTINUED TO WORK, KEEPING THE SPEED BELOW 60 MPH, AND THEN THE SAME ON THE WAY HOME, AND PROBLEM DIDN'T OCCUR. VEHICLE HAS STOCK TIRES, AND NO ADDITIONAL LIFTS.

DRIVING AT HIGHWAY SPEEDS OF 55 - 65MPH AND HIT A SLIGHT BUMP IN THE ROAD THE ENTIRE FRONT END OF THE VEHICLE SHAKES UNCONTROLLABLY. IN ORDER TO GET THIS TO STOP YOU MUST SLAM ON THE BRAKES TO BRING THE SPEED DOWN TO 15 - 20 MPH. FORD DEALERSHIP SERVICE ADVISER AND MECHANIC ACKNOWLEDGE THIS ISSUE EXISTS AND HAS SINCE 2005 BUT THERE ISN'T ANY RESOLUTION FOR THE ISSUE. MY VEHICLE HAS BEEN IN THE SHOP 3 DIFFERENT TIMES FOR OVER A MONTH IN TOTAL TIME. FORD REGION CUSTOMER SERVICE MANAGER STATES THE ISSUE IS THE ROAD. I FIND IT ODD THERE ARE MAY OTHER FORD TRUCK OWNERS WITH THE SAME ISSUE.

TL* THE CONTACT OWNS A 2012 FORD F-250. THE CONTACT STATED THAT THE DRIVER SIDE DOOR LATCH SENSOR FAILED AND CAUSED THE DOOR TO REMAIN AJAR WHILE THE VEHICLE WAS IN MOTION. THE VEHICLE WAS TAKEN TO THE DEALER TO BE DIAGNOSED. THE CONTACT WAS NOTIFIED THAT THE DOOR LATCH NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 24,989.

THE VEHICLE'S ENGINE WILL STALL (CUT OFF) WITHOUT ANY INDICATION OR NOTICE DURING MOTION OR AT A STOP. THIS HAS HAPPENED AT CITY SPEEDS (LESS THAN 25 MPH) AND AT HIGHWAY SPEEDS (GREATER THAN 55 MPH) THE VEHICLE WILL NOT IMMEDIATELY START BUT MAY START AFTER STANDING FOR SOME TIME. THIS CAUSES POWER STEERING, POWER BRAKES AND OTHER IMPORTANT SAFETY FEATURES TO BE DEGRADED OR LOST.

WHILE DRIVING DOWN STRAIGHT DOWN THE HIGHWAY ABOUT 50 MPH. I CROSSED A BRIDGE EXPANSION JOINT AND THE FRONT OF THE PICKUP SHOOK VIOLENTLY. I HAD TO APPLY THE BRAKES FIRMLY AND PULL TO THE SHOULDER QUICKLY. I THOUGHT THE FRONT END OF THE TRUCK WAS COMING APART AND I WAS GOING TO WRECK. THIS HAD NEVER HAPPENED BEFORE AND THERE WAS NO WARNING PRIOR TO THE EVENT. I HAD BEEN DRIVING ABOUT 20 MILES BEFORE THIS OCCUR. IT HAPPENED AGAIN SEVERAL DAYS LATER. I ONLY HAVE 28K MILES ON IT. MY FRIEND LATER TOLD ME THIS WAS THE 'DEATH WOBBLE' AND THAT HE HAD IT ON HIS F250-2012. HE SAID IT REQUIRED REPLACEMENT OF A SUSPENSION BAR(TRACK BAR) ON THE FRONT OF THE TRUCK WHICH I HAD DONE. NO FURTHER PROBLEM HAVE BEEN NOTED SINCE REPLACED..1 WEEK AGO. THE SHOP WHERE I HAD THE WORK DONE SAID THEY HAVE FIXED ABOUT 70 TRUCKS AND IT WILL OCCUR AGAIN WHEN THE BALL JOINT ON THE BAR WEARS OUT AGAIN. I HAVE A KING RANCH MODEL WITH 20 INCH TIRES THAT MAY BE A CONTRIBUTING FACTOR. OTHER PEOPLE I KNOW WITH F250S AND 18 INCH TIRES HAVE NOT NOTICED THIS PROBLEM.

TL* THE CONTACT OWNS A 2012 FORD F-250. THE CONTACT STATED THAT WHILE DRIVING AT 50 MPH, THE VEHICLE BEGAN TO SHAKE VIOLENTLY. IN ADDITION, THERE WAS OIL COMING FROM UNDER THE VEHICLE. THE VEHICLE WAS TAKEN TO A DEALER WHERE IT WAS DIAGNOSED THAT THE TRACK BAR NEEDED TO BE REPLACED. THE FAILURE MILEAGE WAS 40,000.