2001 FORD F-250 Complaints

2001 F250 DIESEL STALLED WITHOUT WARNING TODAY. IT DID RESTART, THEN STALLED AGAIN. THEN RESTARTED AND STALLED A THIRD TIME. I'M ATTEMPTING TO DRIVE IT TO THE FORD DEALERSHIP TOMORROW. I UNDERSTAND THERE HAS BEEN SIMILAR RECALL ON A LATER MODEL. THE VEHICLE DID SEEM TO HESITATE SEVERAL TIMES YESTERDAY BUT DID NOT STALL. *NM

DT*: THE CONTACT STATED WHILE DRIVING VARIOUS SPEEDS, THE ENGINE STALLED WITHOUT WARNING. AFTERWARDS, THE ENGINE RESTARTED WITHOUT INCIDENT. THE VEHICLE WAS SEEN BY A DEALER FOR INSPECTION WHO DETERMINED THE CRANKCAM SENSOR NEEDED TO BE REPLACED.

WHILE DRIVING AT APPROXIMATELY 50 MPH TRANSMISSION SHIFTED INTO SECOND GEAR. TRANSMISSION IS AN AUTOMATIC. TRANSMISSION WOULD NOT SHIFT OUT OF SECOND GEAR. THE VEHICLE WOULD NOT MOVE AT ALL WHEN PUT IN REVERSE. THERE WAS NOTHING ABNORMAL NOTICED WITH TRANSMISSION PRIOR TO THIS OCCURRENCE EXCEPT A UNEXPLAINED THUD NOISE THAT I HAD TAKEN THE VEHICLE IN FOR DURING THE INITIAL WARRANTY PERIOD. I WAS TOLD THAT THIS WAS A NORMAL CHARACTERISTIC OF THE VEHICLE. TRANSMISSION HAD TO BE REPLACED PER FORD DEALERSHIP. FORD DEALERSHIP INSTALLED REMANUFACTURED TRANSMISSION. THIS TRANSMISSION WAS FAULTY AND HAD TO BE REPLACED WITH ANOTHER REMANUFACTURED TRANSMISSION.

DRIVER SIDE SEAT BELT UNSNAPS WHILE DRIVING, WAS CHECKED UNDER RECALL IN 2001 AND CHECKED OK, NOW I AM HAVING PROBLEMS. THIS PROBLEM HAS BEEN GOING ON FOR ABOUT THE LAST SIX MONTHS. *NM

AS I WAS DRIVING MY FORD F-250 SD TAKING MY CHILD TO SCHOOL, THERE WAS A LOUD BANG AND THE TRUCK FELT LIKE IT HIT A BRICK WALL. IT WOULD ONLY DO THIS WHEN SHIFTING OUT OF 2ND GEAR. POWERSTROKE WITH A 4R100 TRANSMISSION. DEALER STATES THAT THE DRUM OR "MECHANICAL DIODE" HAS WENT OUT, SO THEY REPLACED WITH A "SPRAGUE DIODE", AT A COST OF 1500.00. THERE HAVE BEEN NUMEROUS REPORTS OF THIS "MECHANICAL DIODE" BREAKING DUE TO FORD USING BAD PARTS. I CALLED FORD AND ASK FOR REIMBURSEMENT, BUT WAS DENIED. TRUCK HAD 64,000 MILES WHEN THIS HAPPENED. IT IS VERY WELL DOCUMENTED ON VARIOUS WEBSITES ABOUT THIS DEFECT, BUT FORD SEEMS TO DENY IT. THE DEALER WAS VERY GOOD TO WORK WITH AND IS THE SAME DEALER THAT I HAVE DO ALL MY SERVICE WORK. *NM

FAULTY ENGINEERING ON A 2001 FORD EXPEDITION. SPARK PLUGS UNDER PRESSURE JUST POP RIGHT OUT OF THE HEAD. THE FORD BARELY HIT A 100,000 MILES. FORD BOASTS THAT TUNE UPS ARE NOT NECESSARY UNTIL A 100,000 MILES. WELL ANYWAYS THE SPARK PLUG SHOT OUT OF THE HEAD AND THE END RESULT IS THAT IT WILL COST ME $2,000 DOLLARS TO REPLACE THE ENTIRE ALUMINUM HEAD. AFTER TALKING WITH OTHER OWNERS AND DOING SOME INTERNET HOMEWORK WITH ON CONSUMER AFFAIRS, I NOTICED AT LEAST A HUNDRED OTHER PEOPLE WITH THE EXACT SAME MODEL FORD AND THAT HAVE HAD THE SAME EXACT PROBLEM. *NM

DRIVING ALONG BUSY ROAD WAY RUNNING FINE, THEN THE MOTOR JUST SHUT DOWN. LEFT STRANDED RIGHT IN THE MIDDLE OF THE ROAD. COULD NOT BE RESTARTED, TRUCK WAS TOWED TO GARAGE. CAM SHAFT SENOR REPLACED. *JB

I HAVE A 2001 FORD F250 SUPER DUTY WITH A 7.3L POWERSTROKE DIESEL ENGINE. OVER THE LAST 18 MONTHS I HAVE HAD NO LESS THAN 4 CAM POSITIONING SENSORS FAIL. ON TWO OF THESE OCCASIONS THE PART FAILED SLOWLY CAUSING INTERMITTENT ENGINE PROBLEMS. THE TRUCK WOULD RUN ROUGH AND LOOSE ALL POWER. ON THE TWO REMAINING OCCASIONS THE PART FAILED IMMEDIATELY AND PUT MY LIFE IN IMMEDIATE DANGER. ON ONE OF THESE FAILURES I WAS TOWING A 12,000 LB FIFTH WHEEL TRAILER, ON THE INTERSTATE AT 65 MPH. MY ENGINE STALLED (STOPPED RUNNING COMPLETELY) WITH NO WARNING AND LEFT ME WITH NO POWER BRAKES AND NO POWER STEERING. THE ONLY THING THAT SAVED ME WAS THE LOCATION OF THE INCIDENT. IT HAPPENED ON A LONG STRAIGHT AWAY. IF IT HAD HAPPENED IN THE MOUNTAINS, ON A HILL OR ON A CURVE I WOULD HAVE SURELY CRASHED. THE SECOND FAILURE OCCURRED JUST BEFORE A STOP LIGHT. MY TRUCK WAS ONLY GOING ABOUT 30 MPH BUT THE ENGINE STALLED, ONCE AGAIN WITHOUT WARNING, JUST AS A LIGHT TURNED RED. I WAS UNABLE TO STOP IN TIME AND NARROWLY AVOIDED AN ACCIDENT AS THE ONCOMING TRAFFIC JUST MISSED ME. AFTER THE INCIDENT ON THE HIGHWAY I WAS ABLE TO RESTART THE TRUCK AND LIMP IT HOME. AFTER THE SECOND INCIDENT I WAS UNABLE TO RESTART THE TRUCK AND HAD TO TOW IT. I BOUGHT MY TRUCK USED, WITH 52,000 MILES IN OCT OF 2003. MY FIRST FAILURE DID NOT TAKE PLACE UNTIL NOVEMBER 2004. WITH IN 6 MONTHS OF REPLACING THE PART WITH A FORD FACTORY PART THE SECOND UNIT FAILED. WITHIN 6 WEEKS OF THAT PARTS INSTALLATION IT FAILED AGAIN. THEN IN JANUARY OF THIS YEAR I REPLACED THE UNIT WITH A NEW PART FROM INTERNATIONAL WHEN IT BEGAN TO INTERMITTENTLY FAIL. THIS PART WAS ON THE TRUCK FOR LESS THAN 4 WEEKS AND LESS THAN 2000 MILES BEFORE IT FAILED THIS PAST WEEKEND. I NOW HAVE A BRAND NEW FACTORY UNIT IN PLACE AND CONSTANTLY WORRY ABOUT TOWING OR DRIVING WITH MY FAMILY. EACH REPLACEMENT PART HAS COSTS MORE THAN 125$ WITH ONE AS MUCH AS $185. ON ONE OCCASION I HAD TO PAY A 50$ TOW BILL. *NM

FORD 2001 BLEW UP INTO FLAMES WHILE PARKED IN DRIVE WAY WHILE VEHICLE WAS OFF. TOTAL LOSS. *NM

DT*: THE CONTACT STATED WHILE DRIVING 45 MPH A VEHICLE PULLED OUT IN FRONT OF THE CONTACT CAUSING A CRASH. THE AIR BAGS DID NOT DEPLOY. A POLICE REPORT WAS FILED AND THE OTHER DRIVER WAS INJURED.