2011 FORD F-250 Complaints

MY TRUCK STARTS SHAKING VIOLENTLY AT 40-60 MPH. STEERING CONTROL IS LOST AND CAN ONLY BE REGAINED BY COMING TO A COMPLETE STOP. TRUCK WILL NOT SWITCH LANES AND PULLING OVER TO THE SHOULDER IS IMPOSSIBLE DUE TO LOSS OF STEERING. SHAKING IS VIOLENT TO THE POINT OF LOOSENING BOLTS. TAKEN TO DEALER TO BE CHECKED UNDER WARRANTY. THEY CLAIMED IT WAS AIR PRESSURE OR THE NEED FOR NEW TIRES. THE VEHICLES TIRES ARE IN GOOD CONDITION AND AIR PRESSURE IS SET AT FACTORY RECOMMENDED LEVELS. FORD SAYS THIS BEHAVIOR IS NORMAL. A SERIOUS ACCIDENT EXTREMELY POSSIBLE. AN INDEPENDENT SUSPENSION SHOP CLAIMS ISSUE IS DUE TO DEFECTIVE BALL JOINTS, LACK OF STEERING DAMPER, AND DEFECTIVE CONTROL ARMS. *TR

THIS SAFETY CONCERN OCCURRED ON A 2011, FORD F250, WITH "26,400" MILES ON IT. UPON LEAVING MY RESIDENCE, THE TRUCK FELT SLUGGISH, AS IF THE EMERGENCY BRAKE WAS ON. I NEVER USE THE EMERGENCY BRAKE, BUT CHECKED ANYWAY TO CONFIRM IT WAS NOT SET. I PULLED OVER AND EXISTED THE VEHICLE, AND IMMEDIATELY NOTICED A BURNING ODOR. THE ODOR CAME FROM THE DRIVER SIDE FRONT WHEEL. I REACHED IN TO FEEL THE ROTOR AND BURNED MY FINGER TIPS FROM THE HEAT. AS A PRECAUTION, I CHECKED THE REMAINING WHEELS AND ALL EXHIBITED VERY HIGH HEAT WITH A BURNING ODOR. LUCKILY, I WAS WITHIN AN 1/8 MILE OF S SERVICE STATION. THE MECHANIC INSPECTED AND DETERMINED ALL FOUR BRAKES HAD SEIZED DUE TO CORROSION. TWO CALIPERS WERE SALVAGEABLE, TWO WERE NOT. THE REPAIR WAS MADE WITH THE CALIPERS HELD FOR THE LOCAL FORD DEALER FOR REVIEW, AND DISPOSITION, BUT THE FORD DEALER SHOWED NO INTEREST, AND HAD DECLINED TO PERSONALLY EXAMINE THE CORRODED CALIPERS. THE TRUCK WAS 21 DAYS OUT OF CALENDAR WARRANTY. *TR

CATASTROPHIC ENGINE FAILURE AT 3 YEARS OLD AND 124,000 MILES. THIS $60,000 2011 FORD F-250 SUPER DUTY WITH 6.7 DIESEL ENGINE IS TOTALED. DRIVING DOWN THE ROAD AT NORMAL CRUISE THE ENGINE STARTED MAKING A TERRIBLE BANGING NOISE AND SHUDDERING SO VIOLENTLY THAT I WAS FORCED TO IMMEDIATELY LEAVE THE ROAD. I STOPPED AND TURNED THE ENGINE OFF. GOT OUT AND THE GROUND WAS COVERED IN OIL. STRANDED.. DEALERSHIP QUOTED ME $24,233.67 TO REPLACE THE ENGINE. ALTHOUGH THIS ENGINE IS FALSELY ADVERTISED TO BE RIGIDLY TESTED FOR 250,000 MILES, FORD HAS SENT EMAIL STATING THAT THEY WILL NOT STAND BEHIND THE PRODUCT. THIS TRUCK IS STILL FINANCED AND QUITE FRANKLY I CANNOT AFFORD AND SHOULD NOT HAVE TO AFFORD THIS REPAIR. I HAVE HAD EXHAUST ISSUES WITH OVERHEATING AND BURNING SENSORS WHICH WERE REPLACED BY WARRANTY A COUPLE TIMES AND OUT OF POCKET A COUPLE TIMES. I HAVE READ MANY REVIEWS THAT THE HEAT THAT IS BUILT UP DURING A REGEN EXHAUST CLEANING CYCLE DAMAGES THE VALVES WITHIN THE ENGINE. I ALSO READ THAT FORD FIXED THIS PROBLEM IN 2012 BUT THAT LEAVES PEOPLE LIKE MYSELF, WHO PAID FORD $60,000+ STRANDED WITHOUT A VEHICLE IN JUST 3 SHORT YEARS. I HAVE SERVICE THE TRUCK AS REQUIRED AND HAVE NEVER ABUSED IT NOR PUT IT IN MUD, ETC. PLEASE LOOK INTO THIS AND SEE IF THERE IS ANYTHING I CAN DO. IT APPEARS I MAY BE WITHOUT A VEHICLE AND HAVE TO DEFAULT ON MY LENDER WITH THE COST OF THIS. *TR

WHEN HITTING A BUMP OR POT HOLE AT HIGHWAY SPEED THE FRONT TIRES WOBBLE UNCONTROLLABLY UNTIL YOU ALL BUT STOP. THIS COULD CATCH SOMEONE OFF GUARD TO CRASH INTO SOMEONE ON THE HIGHWAY. *TR

TRUCK DEVELOPED A VIOLENT SHAKE IN THE FRONT END AND BECAME UNCONTROLLABLE. HAVE TO STOP IMMEDIATELY BEFORE VEHICLE WILL STOP SHAKING. THE ISSUE IS REFERRED TO THE "FORD DEATH WOBBLE" WITH MANY RECORDED INSTANCES OF THIS ON THE WEB AND YOUTUBE. ISSUE HAS GOTTEN WORSE AND IS UNSAFE TO DRIVE. HAS BEEN IN THE FORD DEALER AND MANY NEW PARTS REPLACED BUT PROBLEM PERSIST. FORD DEALER CANNOT SEEM TO CORRECT SO IT HAS BEEN IN TWO OTHER GARAGES FOR SECOND OPINIONS. CONTACTED FORD MOTOR COMPANY AND THEY HAVE NO RECALLS OR ANY KNOWLEDGE OF THIS PROBLEM. VEHICLE IS A DANGER TO THE HIGHWAY. *TR

VEHICLE PRIMARY COOLING SYSTEM (RADIATOR) BEGAN LEAKING WHERE THE ALUMINUM COILS ARE ATTACHED TO THE PLASTIC TANK. I TOOK VEHICLE TO FORD DEALER FOR INSPECTION AND THEY VERIFIED. LEAK WAS SLOW FOR FIRST COUPLE OF WEEKS, THEN PROGRESSED. REPLACEMENT WAS INSERTED BEFORE RADIATOR LEAK COULD CAUSE FURTHER DAMAGE TO VEHICLE OR PERSONS. THIS IS A VERY COMMON OCCURRENCE WITH THIS YEAR/MODEL AND OWNERS FEEL THIS SHOULD BE ADDRESSED WITH A RECALL FROM FORD MOTOR COMPANY DUE TO INADEQUATE TESTING OR PRODUCT SPECIFICATIONS. THE PUBLIC RATE OF OCCURRENCE IS VERY HIGH. OF COURSE FOMOCO WILL NOT PUBLISH DATA UNTIL FORCED. REPORTS OF RADIATORS FAILING < 50,000 MILES IS NOT UNCOMMON. *TR

I HAD A PROBLEM WITH MY 2011 F250'S TRANSMISSION. THE PROBLEM WAS COVERED UNDER TSB 11-5-19. WHEN TRYING TO ACCELERATE, THE TRANSMISSION WOULD RANDOMLY DEVELOP A PROBLEM WHICH SEEMED LIKE IT WAS TRYING TO FIND THE RIGHT GEAR. THERE WOULD BE A SEVERE LOSS OF POWER WHICH WOULD RESULT, AT TIMES, LEAVING MY VEHICLE IN TRAFFIC GOING AT A MUCH HIGHER SPEED AND CLOSING RAPIDLY FROM BEHIND. THE PROBLEM WAS RESOLVED BY DOING THE SERVICE PRESCRIBED IN THE SERVICE BULLETIN BUT I WAS NOT AWARE OF THAT BULLETIN UNTIL THE PROBLEM BECAME SEVERE. *TR

TL* THE CONTACT OWNS A 2011 FORD F-250. THE CONTACT STATED THAT WHILE DRIVING 60 MPH, THE VEHICLE BEGAN SHAKING ABNORMALLY. THE CONTACT TOOK THE VEHICLE TO THE DEALER, WHO STATED THAT THEY WOULD BALANCE ALL FOR TIRES AND PERFORMED AND ALIGNMENT CHECK. THE VEHICLE WAS REPAIRED HOWEVER, THE PROBLEM PERSISTED. THE MANUFACTURER WAS NOT CONTACTED. THE APPROXIMATE FAILURE MILEAGE WAS 22,500. *TR

THE 6.7 CID DIESEL ENGINE DRIVEN VACUUM PUMP SUDDENLY BEGINS LEAKING MOTOR OIL. FAILURE OF THIS PUMP WILL AFFECT 4 WHEEL DRIVE SYSTEMS INCLUDING AUTO LOCKING HUBS AND ALL INTERIOR CLIMATE CONTROLS. LOSS OF MOTOR OIL COULD CAUSE ENGINE FAILURE. FAILURE OF 4 WHEEL DRIVE SYSTEM DURING ADVERSE WEATHER COULD RESULT IN A VEHICLE CRASH OR LOSS OF CONTROL. RESEARCH INDICATES MULTIPLE FAILURES OF THIS PART, INDICATING A SYSTEMIC FAILURE. *TR

PURCHASED 2MTH AGO. WOULD NOT START. REPLACED BATTERIES. 4 WKS LATER "PULL OVER SAFETY" ON & SHUT DOWN ON A WINDY ROAD AT 6PM. VEHICLE TOWED TO AUTO PLACE. $1500 FIX ELECTRICAL PROBLEM. 1 MTH LATER IT DOES IT AGAIN DOWN BUSY FREEWAY ALMOST CAUSING NEAR COLLISIONS. TOAD AGAIN. FIXED AND SAME AFTERNOON PULLING OUT TO STATE HIGHWAY AND SAME SIGNAL TO PULL OVER COMES ON & VEHICLE SHUTS DOWN & BACKING UP 5PM TRAFFIC BEFORE BEING TOWED AGAIN. *TR