2008 FORD F-250 Complaints

I BOUGHT A 2008 FORD F-250 EXTENDED CAB TRUCK AND WHEN I GO OVER A SMALL BUMP IN THE ROAD THE FRONT END SHAKES REAL BAD TO THE POINT I ALMOST LOST CONTROL GOING DOWN A HIGHWAY AT 55MPH. I CHECKED THE AIR PRESSURE IN THE TIRES AND THEY WERE AT 70PSI IN THE FRONT AND 80PSI IN THE BACK. THE DOOR STICKER SAID THE PRESSURES SHOULD BE 70 IN THE FRONT AND 80 IN THE BACK. I HAVE REPLACED THE SHOCKS AND STEERING STABILIZER SHOCK AND IT DID NOT MAKE A DIFFERENCE. THE OLD SHOCKS APPEARED TO BE IN GOOD SHAPE YET. I THEN REPLACED THE TIRES EVEN THOUGH THEY WERE STILL GOOD AND THEY WERE WORN EVENLY. STILL DID NOT FIX IT. I THEN DROPPED MY AIR PRESSURE IN THE TIRES TO 60PSI FRONT AND BACK TO IF IT MADE A DIFFERENCE. STILL DID NOT FIX IT. I HAD THE DEALERSHIP LOOK AT IT AND THEY SAID THEY COULD NOT FIND ANYTHING WRONG WITH IT. I OWNED A 1999 F-250 AND IT NEVER HAD THIS PROBLEM. I HAD 165,000 MILES ON IT WHEN I TRADED IT IN FOR THIS ONE. I GOOGLED MY PROBLEM AND FOUND A LOT OF PEOPLE WITH THE SAME PROBLEM. FORD NEEDS TO COME UP WITH A REPAIR FOR THIS SOON. I WON'T LET MY WIFE DRIVE THIS TRUCK FOR FEAR OF THIS HAPPENING AND HER ENDING UP IN A WRECK. FORD NEEDS TO THINK ABOUT THE PEOPLE AND CHILDREN THAT RIDE IN THERE VEHICLES AND THE LIVES THAT THEY COULD TAKE. I AM A FORD DRIVER ALL MY VEHICLES ARE FORD AND I'M NOT MAD AT FORD YET BUT THEY NEED TO CURE THIS PROBLEM. THIS PROBLEM IS FOR SURE A DESIGN FLAW. *TR

2008 FORD F250 - ALTERNATOR WENT UP ON TRUCK AFTER 41,690 MILES, THIS ALSO BURNED UP THE BATTERY, NOW THE STARTER HAS GONE UP IN THE TRUCK. GOT THE TRUCK STARTED TO TAKE HOME, TRUCK DIED. THERE IS NO POWER, LIGHTS ANYTHING AT ALL. TRUCK HAS BEEN OUT OF SERVICE FOR ALMOST 2 WEEKS. *TR

2008 FORD F250 - RIGHT ROTOR ONLY DISINTEGRATING CAUSING MAJOR DAMAGE TO THE CALIPER AND RUBBER BOOT. HAD TRUCK TO DEALERSHIP TWICE AND THEY COULD FIND NOTHING WRONG WITH THE TRUCK, NOW DEALERSHIP IS SAYING THAT IT IS LACK OF MAINTENANCE ON MY PART. I SERIOUSLY BELIEVE THAT THIS IS A DEFECTIVE PART. BRAKE ON RIGHT HAND SIDE IS COMPLETELY GONE. I THINK IF THE DEALERSHIP WOULD HAVE CHECK THIS OUT BETTER THEY WOULD HAVE FOUND THE PROBLEM WHILE THE TRUCK WAS UNDER WARRANTY. *TR

2008 FORD F250 SUPER DUTY: IGNITION SWITCH WHEN TURNED TO START/CRANKING POSITION DOES NOT RETURN TO NORMAL RUN POSITION. THIS LEAVES INSTRUMENTS BLANK AND INOPERATIVE, AND ALL POWER ACCESSORIES FAIL TO OPERATE UNTIL TRUCK IS SHUT OFF & RESTARTED. *TR

TL*THE CONTACT OWNS A 2008 FORD F250 SUPER DUTY. THE CONTACT STATED THAT WHILE DRIVING AT 70 MPH OVER AN UNEVEN SURFACE, THE FRONT END OF THE VEHICLE WOULD SHAKE AND VIBRATE. THE STEERING AND TRACTION CONTROL ALSO FAILED. UPON DECELERATION THE FAILURE WOULD STOP. THE PROBLEM OCCURRED THREE TIMES. THE VEHICLE WAS TAKEN TO AN AUTHORIZED DEALERSHIP BUT THE DEALER COULD NOT DUPLICATE THE FAILURE. THE DEALER INFORMED THE OWNER THAT SOME OF THIS YEAR AND MODEL HAD THE "DEATH SHAKE" BUT THERE WAS NOTHING THEY COULD DO ABOUT IT; SHE WAS ADVISED TO NOT DRIVE THE VEHICLE. THE FAILURE MILEAGE WAS APPROXIMATELY 15,000. THE CURRENT MILEAGE WAS APPROXIMATELY 24,000.

TANK FULL OF DIESEL FUEL CONTAMINATED WITH WATER AND SOME DEBRIS. FORD WILL NOT WARRANTY BUT SEVERAL PARTS OF THE FUEL SYSTEM DEVELOPING RUST. THIS VEHICLE IS EQUIPPED WITH A FUEL WATER SEPARATOR AS STANDARD EQUIPMENT. SO FORD HAS EQUIPPED THE TRUCK WITH A FUEL WATER SEPARATOR BUT SEVERAL OF THE PARTS IN THE FUEL SYSTEM ARE VERY SUBJECT TO RUST IF THERE IS ANY EXPOSURE TO WATER. SO AS SOON AS THE VEHICLE IS EXPOSED TO WATER IN THE FUEL THERE ARE PARTS THAT WILL FAIL AND ARE NOT COVERED BY WARRANTY. *TR

BOTH FRONT WHEELS ON MY 2008 FORD KING RANCH F-250 PICK-UP ARE CRACKING AND NEED TO BE REPLACED. THE CRACKS ARE IN THE WELD AREA ON THE FLAT PART OF THE WHEEL UNDER THE TIRES CAUSING THE TIRES TO NO LONGER HOLD AIR. FORD CUSTOMER SERVICE CLAIMS THE PROBLEM IS MINE SINCE THE TRUCK RECENTLY SURPASSED WARRANTY MILEAGE HOWEVER I AM CERTAIN THIS IS A SERIOUS SAFETY ISSUE. THE WHEELS ARE READY TO COME APART AND COULD HAVE CAUSED A SERIOUS ACCIDENT . IF THE TIRES HAD NOT BEGUN TO LOSE AIR I WOULD HAVE NEVER KNOWN THEY WERE CRACKING. THIS TRUCK HAS HAD THE BEST OF CARE AND HAS NEVER HIT ANYTHING OR BEEN IN ANY KIND OF ACCIDENT. FORD DENIED RESPONSIBILITY WITHOUT EVEN EXAMINING THE CRACKED WHEELS. THE TIRE SHOP BELIEVED THE SITUATION WAS SO UNSAFE THAT THEY RECOMMENDED TOWING INSTEAD OF DRIVING THE TRUCK. THIS CASE # 1526770470 WITH FORD WAS DENIED AND THEY QUOTED OVER 800 DOLLARS PER WHEEL TO REPLACE THE CRACKED WHEELS. ALL AFTER MARKET WHEELS I CHECKED ON WERE AROUND 250 DOLLARS WITH A LIFETIME GUARANTEE. I HAVE WORKED IN CONSTRUCTION FOR OVER 30 YEARS AND HAVE OWNED SEVERAL VEHICLES AND HAVE NEVER ENCOUNTERED ANYTHING LIKE THIS. *TR

MY HUSBAND WOKE UP AND WENT OUT TO START HIS TRUCK SO IT WOULD BE WARM FOR OUR 1-YR OLD TWIN BABIES TO GET IN THE CAR. WHEN HE WENT TO PUT THE BABIES IN THE BACK SEAT, THE REAR PASSENGER WINDOW WAS BLOWN OUT FROM THE INSIDE OUT; THE GLASS LOOKED BUBBLED. HE IMMEDIATELY TOOK THE CAR TO THE GLASS SHOP AND WAS ADVISED THAT BECAUSE FORD DOESN'T USE THE PROPER SEAL ON IT'S REAR WINDOWS THAT THIS CAN OCCASIONALLY HAPPEN. THE WINDOW BLEW UP FROM THE HEAT INSIDE THE CAR...IT'S 30 DEGREES HERE THIS MORNING. WE THEN TOOK THE VEHICLE THAT IS STILL UNDER WARRANTY TO OUR LOCAL FORD DEALERSHIP AND WE WERE ADVISED THAT IT'S NOT COVERED UNDER WARRANTY. SO I'M LOOKING AT $800 FOR A WHOLE ENTIRE BACK WINDOW THAT HAS TO BE REPLACED. THIS CONCERNS ME AS IF ONE OF MY BABIES WAS IN THE CAR WHEN THIS HAPPENED, WE WOULD HAVE SOME SERIOUS HEALTH ISSUES....THIS IS A HUGE SAFETY CONCERN. BECAUSE OF THEIR FAULTY SEAL, OUR WINDOW EXPLODED. *TR

DRIVING AROUND AND DIESEL FUEL SMELL CAME INTO THE CAB OF THE TRUCK AND SMOKE FROM ENGINE COMPARTMENT. THIS TRUCK HAS A 6.4L JOB 1 DIESEL. WE HAD THE TRUCK TOWED TO THE FORD DEALERSHIP BECAUSE DRIVING IT MAKES ME SICK TO MY STOMACH AND LIGHT HEADED. FORD TELLS US IT WILL HAPPEN EVERY 100-600 MILES AND LAST 10-40 MINUTES EACH TIME DURING REGENERATION. FORD SAYS THIS IS A 'NORMAL OPERATION CHARACTERISTIC OF THE VEHICLE'. THE DEALERSHIP REFERENCED TSB 09-16-9 AND TOOK THE TIME TO HIGHLIGHT CERTAIN AREAS. #1 - I WAS NOT IN COLD AMBIENT TEMPERATURE AT THE TIME THE SMOKE WAS COMING FROM THE ENGINE COMPARTMENT AND #2 - THIS IS NOT A BRAND NEW TRUCK ALTHOUGH WE DO HAVE LOW MILEAGE. HOW CAN THIS BE CONSIDERED NORMAL IF IT HAD NEVER HAPPENED BEFORE AND NOW MAKES ME SICK WHEN I DRIVE THE TRUCK? THE SMELL IS STILL FAINTLY IN THE HEADLINER OF THE TRUCK. WHAT IS IN THIS STUFF THAT MADE ME LIGHT HEADED AND SICK TO MY STOMACH?*CW

1. DRIVING AT SPEEDS OF 65MPH+ IN A 2008 FORD F-250. 2. HIT A MINOR SEAM IN THE PAVED ROAD. 3. FRONT END WOBBLE (KNOWN ON MANY INTERNET SITES AT THE "FORD DEATH WOBBLE". MY TRUCK WAS UNDER WARRANTY AND I TOOK IT TO FORD DEALER THE NEXT DAY. THEY TIGHTEN THE PITMAN ARM. THERE WAS A FORD TECHNICAL SERVICE BULLETIN ISSUED FOR THIS PROBLEM AND IT INDICATED IMPROPER TIRE PRESSURE. TOTALLY NOT TRUE. THE FRONT END WOBBLE WAS SO SEVERE IT MADE ME CROSS INTO ON-COMING LANES OF TRAFFIC. LUCKILY NO ONE WAS COMING THE OTHER WAY OR THERE WOULD HAVE BEEN A SERIOUS ACCIDENT. THE FORD DEALER ALSO REPLACED THE FRONT STABILIZER SHOCK. THE VERY NEXT DAY THE EXACT SAME THING HAPPENED. VIOLENT FRONT END WOBBLE AT 65MPH+ AND WHEN A SMALL BUMP WAS HIT. I HAD TO SLOW THE TRUCK DOWN TO 20MPH ON AN INTERSTATE FREEWAY IN ORDER TO GET THE WOBBLE TO STOP AND ALMOST CAUSED ANOTHER ACCIDENT. TWO HOURS LATER IT HAPPENED AGAIN! VIOLENT WOBBLING OF THE FRONT END. THE DEALER CLAIMS THERE IS NOTHING WRONG WITH THE TRUCK. HOWEVER, AFTER RESEARCHING THE MATTER ON THE INTERNET THERE ARE HUNDREDS OF CASES OF THIS SAME PROBLEM. CHECK OUT: WWW.SUPERDUTYWOBBLE.COM OR OTHER SITES. THIS HAS GOT TO BE A MANUFACTURING ERROR THAT DESERVES A RECALL NOTICE. THE FORD DEALER CANNOT FIND ANYTHING WRONG! PLEASE HELP! *TR