2007 FORD F-250 Complaints

AT 52000 MILES ENGINE STARTED MAKING TAPPING NOISE? DRIVER SEATBELT NOT RETRACTING. FRONTEND SHIMMY AT SPEEDS OF 45 TO 65 MPH. *TR

EGL COOLER FAILURE, WHITE SMOKE COMING OUT OF THE EXHAUST PIPE CAUSED BY COOLANT ENTERING INTO THE EMISSION SYSTEM. "ON ALL 6.0 ENGINES THE EGL COOLER WILL FAIL." THIS PROBLEM IS SO "MASSIVE" WITH SO MANY "MASSIVE COMPLAINTS FROM CUSTOMERS" THAT FORD HAS DONE TWO THINGS 1) DESIGNED A BY-PASS KIT AND 2) RE-DESIGNED THE ENGINE TO ELIMINATE THE PROBLEM (6.7 ENGINE). WHEN THE EGL COOLER FAILS, FORD OFFERS TWO SOLUTIONS TO THE CUSTOMER 1) INSTALL THE BY-PASS KIT AND THE PROBLEM IS SOLVED (AT A COST OF $4500) OR 2) REPAIR THE EGL COOLER TO BRING IT "BACK TO FACTORY" (AT A COST OF $4300). FORD TELLS CUSTOMERS THAT IF OPTION 2 IS CHOSEN, THE "EGL COOLER WILL FAIL AGAIN". ALL QUOTES USED ARE DIRECT QUOTES FROM FORD'S SERVICE DEPARTMENT. *TR

WE HAVE 3 OUT OF 4 TIRES SEPARATE WITH THE TREAD COMING COMPLETELY OFF OF ONE OF THE TIRES CAUSING MAJOR DAMAGE TO BED AND NUMBER OF OUR TRUCK. THE FIRST TIRE WAS WITH IN A COUPLE OF MONTHS OF PURCHASE. THE OTHER 2 TIRES HAPPEN WITH IN 30 MINUTES OF EACH OTHER. ALL UNDER 10,000 MILES OF USE. YOUR FORM DOESN'T SHOW CORRECT TIRE TYPE. THIS COMPLAINT IS ON THE FEDERAL COURGIA M/T. THANK YOU. *TR

TL* THE CONTACT OWNS A 2007 FORD F-250. THE CONTACT STATED THAT WHILE TRAVELING VARIOUS SPEEDS, THE VEHICLE SHOOK. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS CONTACTED ABOUT THE FAILURE. THE FAILURE MILEAGE WAS 42,000.

PRONOUNCED AND SEVERE SHIMMY AND OSCILLATION IN THE STEERING WHEEL WHEN TRAVELING OVER SMALL BUMPS OR DIPS IN THE ROADWAY AND ON UNEVEN DRIVING SURFACES. FORD DEALER CONFIRMED THE PROBLEM AND REPLACED A TRACKING BAR AND THE STEERING DAMPER. THESE REPAIRS HELPED BUT DID NOT ELIMINATE THE ISSUE. NEW OEM TIRES WERE INSTALLED 2,000 MILES AFTER THE FORD REPAIR. AS OF DEC 2013 THE VEHICLE NOW HAS 78,578 MILES WHICH IS ONLY 5,000 MILES SINCE THE REPAIR AND 3,000 MILES SINCE NEW OEM TIRES AND THE SAME SEVERE SHIMMY AND OSCILLATION IN THE STEERING WHEEL IS OCCURRING AGAIN. IN DEC 2013 I RECEIVED SPECIAL FIELD ACTION LETTER 09L02 FROM FORD CONCERNING THIS VERY ISSUE. HAVING COMPLIED WITH ALL POINTS IN THE SPECIAL FIELD ACTION LETTER 09L02 THE SAME PROBLEM EXISTS AND CONTINUES TO WORSEN. THIS IS CLEARLY A SAFETY ISSUE THAT FORD NEEDS TO ADDRESS WITH A RECALL NOTICE AND THE 09L02 LETTER IS INDICATIVE THAT THIS IS A WIDE-SPREAD ISSUE. *TR

TL* THE CONTACT OWNS A 2007 FORD F250. THE CONTACT STATED THAT WHILE DRIVING APPROXIMATELY 40 MPH, WHITE SMOKE EMITTED FROM THE EXHAUST AS THE CHECK ENGINE WARNING LIGHT ILLUMINATED. THE VEHICLE WAS TOWED TO A DEALER, WHO STATED THAT THE OIL COOLER WAS DEFECTIVE AND THE ERG VALVE WOULD NEED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED. THE FAILURE MILEAGE WAS 37,188.

RECENTLY, WHILE DRIVING MY FORD F250 TRUCK, I HAVE EXPERIENCED THE FORD'S DEATH WOBBLE' ON THREE SEPARATE OCCASIONS. AFTER DRIVING OVER A BUMP IN THE ROADWAY, THE FRONT END STARTS WOBBLING TO THE POINT THAT I HAVE TO BRAKE AND PULL OVER JUST TO STAY IN CONTROL OF MY VEHICLE. WHEN THIS DEATH WOBBLE' OCCURS, IT CAUSES THE DRIVER HAS TO FIGHT THE STEERING WHEEL AND APPLY BRAKING JUST TO STAY IN CONTROL OF THE VEHICLE. IT IS A REAL SAFETY CONCERN!!!! *TR RECENTLY, I HAVE READ SEVERAL ARTICLES IDENTIFY THE PROBLEMS WITH FORD'S FRONT END AND THEIR SOLUTIONS TO FIX THE FRONTS ENDS. AS USUAL, FORD COMES UP WITH EXCUSES AND NOT A SOLUTION TO REPAIR THEIR PRODUCTS. THERE IS PLENTY OF DOCUMENTATION (U-TUBE VIDEO) ON-LINE DOCUMENTING THE SERIOUS OF THIS COMPLAINT. IT IS TIME THAT YOUR AGENCY TAKES A CLOSER LOOK AT THIS PROBLEM AND SEE THAT FORD ACCEPT RESPONSIBILITY TO REPAIR THEIR VEHICLE. *TR

TL* THE CONTACT OWNS A 2007 FORD F-250. THE CONTACT STATED THAT WHILE DRIVING 70 MPH, THE BATTERY WARNING LIGHT ILLUMINATED. THE CONTACT STATED THAT THE VEHICLE BECAME DIFFICULT TO STEER AND BRAKES ALSO FAILED. THE VEHICLE WAS TAKEN TO THE DEALER FOR INSPECTION WHERE THEY STATED THAT THE AIR COMPRESSOR NEEDED TO BE REPLACED. THE VEHICLE WAS REPAIRED BUT THE FAILURE RECURRED. THE MANUFACTURER WAS NOTIFIED. THE FAILURE MILEAGE WAS 147,000. THE VIN WAS UNAVAILABLE.

I HAVE A 2007 F 250 DIESEL AND EVERY TIME I AM DRIVING OVER SPEED BUMP AT 45MPH TO 65MPH MY TRUCK SHAKES LIKE CRAZY IT HAS BEEN TAKEN TO THE DEALER FOR A FIX BUT NOTHING IS DONE I AM AFRAID THAT ONE DAY THIS WILL COST AN ACCIDENT I HOPE THE THIS MATER IS TAKEN CARE SOON THANK YOU FOR YOUR HELP. *TR

I WAS TOWING A CAR HAULER AT APPROXIMATELY 65 MPH ON I-94 OUTSIDE OF CHICAGO, IL WHEN MY VEHICLE BEGAN TO VEER SLIGHTLY TO THE RIGHT AND CROSS INTO THE OTHER LANE. I TRIED TO CORRECT STEER TO THE LEFT AND MY VEHICLE DID NOT RESPOND. I BEGAN TO CROSS INTO THE NEXT LANE OF TRAFFIC AND I BEGAN TO SPIN THE STEERING WHEEL EVEN HARDER TO THE LEFT WITH NO CHANGE IN DIRECTION. I REALIZED THAT I HAD A LOSS OF STEERING AND BEGAN TO APPLY THE BRAKES TO AVOID HITTING THE BARRIER ON THE SIDE OF THE ROAD. I ENDED UP CROSSING FOUR LANES OF MODERATELY HEAVY LABOR DAY TRAFFIC WITH ZERO STEERING CONTROL AND CAME TO REST WITHIN INCHES OF THE RETAINING BARRIER ON THE SIDE OF THE ROAD. *JS