2012 FORD F-250 Complaints

WHILE DRIVING THE TRUCK GOING OVER 50 MILES PER HOUR, IT GOES INTO A WOBBLE, SHAKING, VIBRATION MODE. I FEEL LIKE I'M IN A EARTHQUAKE. SOME TIMES IT COMES ON JUST NORMAL DRIVING AND MOST OF THE TIMES HAPPENS DRIVING OVER BUMPY UNEVEN SURFACE AND POTHOLES ROAD DOING OVER FIFTY MILES PER HOUR. I HAVE TAKEN IT TO THE DEALERSHIP RED MCCOMBS IN SAN ANTONIO TEXAS ABOUT THREE OR FOUR TIMES BEFORE WITH THIS PROBLEM. THEY CAN'T FINE THE PROBLEM. THE SURVICE ADVISER DID STATE THAT ONE OF THERE TECHNICIAN DID KNOWDICE A SLIDE VIBRATION WHILE TEST DRIVING IT BUT OTHER THEN THAT NO PROBEMS. THEY DID REPLACE A PART AT ONE TIME BUT IT DID NOT SOLVE THE PROBLEM. I HAVE AN APPOINTMENT [RED MCCOMB] ON 6TH OF FEBRUARY TO DROP OFF THE TRUCK TO CHECK OUT AGAIN. I DON'T KNOW WHAT TO DO ANY MORE. THIS LAST TIME THE VIBRATION WAS REAL BAD. HAD HARD TIME GETTING IT UNDER CONTROL ON A MAJOR CITY HIGHWAY. I THOUGH I WAS GOING TO GET KILL. I FEAR FOR MY LIFE AND SAFETY DRIVING THAT TRUCK. I DON'T WANT TO SELL IT AND PUT SOMEBODY ELSE LIFE IN DANGER. I CALLED FORD MANUFACTURE ON AROUND THE 17 OR 18 OF JANUARY AND INFORMED THEM ABOUT IT. THE CONVERSATION WAS RECORDED ACCORDING TO THEM. THEY ACTED LIKE THERE HAS BEEN NO PROBLEM WITH THOSE TRUCKS. THEY CONTACTED ME BACK WITH THE DEALERSHIP. THATS WHEN I MADE THE APPOINTMENT. I BOUGHT THAT TRUCK NEW IN TEMPLE TEXAS FROM THE JOHNSON BROTHERS DEALERSHIP IN JUNE 2012. RED MCCOMB HAS MAINTAIN ALL OF THE REQUIRED MAINTANACE AND MECHANICLE PROBLEMS SINCE I BOUGHT IT NEW. JUST ABOUT EVERYTHING IS DOCUMENTRED THERE.

Ford previously issued warranty extension for this vehicle 18-M-01 related to the replacement of the reductant heater unit. I acquired the subject vehicle above and had the repair done at my expense on September 9, 2015 with 115,710 miles on the vehicle using an OEM part. Eventually, Ford would reimburse me for this expense. The truck currently has 150,000 miles and once again the DEF heater failed . So, roughly 35,000 miles on a single unit. That seems ridiculous to me that an emissions part would fail after a mere 35,000 miles. My experience is far from being alone and others have reported similar experiences on internet forums. I will preserve this unit that failed for 60 days after the submission of this claim in case Ford or you would like to inspect it. Unfortunately, the result of having to perform repeated repairs is that people decide to remove and bypass the DEF system completely. That seems to be a terrible outcome for the environment. However, in communities where there is no emissions testing, no one will find out. Please require Ford to extend the warranty on this part again.

The truck will shake violently and uncontrollably at speeds above 45mph...thought I was going to crash into on coming traffic...very scary and life threatening not only for myself but also my passengers oncoming traffic ... I'm pretty sure I would have been the one with a lawsuit if I was to crash into something or someone...instead of ford ..please fix

Known Ford Superduty "death wobble"...violent shaking of truck's front end at highway speed. Happens randomly and usually after hitting a bump or going over uneven road surfaces. Only way to stop wobble is to slow down to below about 50 mph, putting myself and others on the road at risk. Known Ford issue.

The contact owns a 2012 Ford F-250. The contact stated that while driving approximately 20 MPH, the vehicle suddenly experienced a death wobble causing the vehicle to violently shake and vibrate. During the failure, the steering column failed as a result the driver lost control of the steering and drove off the road, and crash into a ditch. During the crash, the vehicle sustained damage to the subframe bracket. No injuries were reported. No police report was taken. The vehicle was towed away from the scene. The cause of the failure was not yet determined. The local dealer and manufacturer were not notified of the failure. The VIN was not available. The failure mileage was 206,000.

the diesel particulate filter is failing on a lot of 2011-2016 ford f-250 f-350, f-450, and f-550 Part 6D20000. Leaving vehicles stranded on the road while driving at 75 MPH. The safety was impacted by a sudden vehicle slowing down with no acceleration. It had also tried doing a lot of regins. This particular truck has not been inspected by a ford dealer nor insurance, but it has been inspected by me and a private mechanic. there weren't any prior problems with this truck. On top of this situation, diesel particulate filters are back ordered by about 3 months and cost about $4,700.00 for replacements. I do forget what the exact day was but it was somewhere in august of 2022

Today, September 6, 2022, is the first time I experienced the so called death wobble. I was traveling along at 55 mph when I went over a bump in the road and my truck began to shake like a dog shaking water off. I slowed down to 40 mph before it stopped. The shaking caused the turbocharger intake hose to break away from the engine causing an undrivable condition.

The truck is experiencing what is commonly referred to as the "Death Wobble." At around 55 mph, the vehicle starts to violently shake. It shakes the whole vehicle, especially the steering--the steering wheel severely shakes until I slow the vehicle slows down below 40 mph. From my research, I've found this is a common issue among other Superduty owners. It seems like there are faulty front end suspension and/or steering parts at play: pitman arm, drag link, tie rod ends (and their bushings/ball joints), etc. The shaking happens on the freeway and is frightening to experience as it could potentially lead to losing control if unable to slow down in time to stop the shaking. Being at freeway speeds, my family and I are at risk as well as other vehicles on the road if we were to lose control. This issue did occur 1.5 years ago. I took it into a Ford dealership where they replaced the steering dampener/stabilizer. Now the death wobble is happening again. From what I've learned, this is a band-aid fix that doesn't address the root cause of the death wobble. No warning lamps or error codes are present before, during, or after the shaking.

The contact owns a 2012 Ford F-250. The contact stated that while driving at various speeds, the vehicle would shake abnormally without warning. Upon investigation, the contact linked the failure to the death wobble. The contact also stated that the EGR cooler was defective, causing the vehicle to downshift while driving at various speeds. The contact had the EGR cooler repaired by the dealer. The vehicle was not repaired for the death wobble. The manufacturer was not notified of the failure. The approximate failure mileage was 136,700.

Very intermittently, when I brake this vehicle to bring it to a stop, the engine will start to rev uncontrollably. I have to practically "stand" on the brake to keep it from charging forward. I have to turn off the truck to stop this high speed revving. After this happened 3 times in 2 months we took it to the dealer to check. There was nothing on the floor that could cause the gas pedal to accelerate. The dealer in Kingwood, WV could not duplicate, and found nothing wrong when inspected. We only use the truck once or twice a month so it is a low use vehicle. For this reason the problem does not occur frequently enough to replicate "on demand". While there was not a crash, it almost revved through an intersection and almost ran into another vehicle. Fortunately I was able to throw it into park (Not Good for the vehicle) and then turn it off.