1997 FORD F-250 Complaints

ALL FOUR MICHELIN BRAND TIRES HAD SIDEWALL CRACKS. 2.5 YEARS OLD WITH @ 30,000 MILES ON THEM. THESE CRACKS DEVELOPED IN A MATTER OF TWO TO THREE WEEKS. HAD TO HAVE ALL FOUR REPLACED. *JB

DT*: THE CONTACT STATED AFTER MULTIPLE USES, THE BRAKES WENT TO THE FLOOR WHEN PULLING AN RV IN TOWN. THE DEALERSHIP DETERMINED THE BRAKE FLUID IS BOILING AND THE SYSTEM SHOULD BE FLUSHED, THEN A DIFFERENT TYPE OF BRAKE FLUID PUT IN TO HANDLE THE WEIGHT OF THE RV.

1. NO EVENT PRIOR TO THE FAILURE. FAILURE OCCURRED WITHOUT WARNING. 2. FAILURE OF THE CRANK POSITION SENSOR ON FORD F250 WITH 7.3 LITER NAVISTAR DIESEL WITH RESULT THAT TRUCK WOULD NOT START OR RUN. 3. CALLED A FORD MECHANIC WHO SAID THIS HAPPENS REGULARLY AND I SHOULD CARRY A SPARE CPS. REPLACED CPS AND TRUCK STARTED AND RAN PROPERLY. PART COST ABOUT $190. NB: I HAVE TO SEARCH RECORDS FOR THE DATE - ABOUT TWO YEARS AGO. DATE BELOW IS NOT ACCURATE. *JB

DT*: THE CONSUMER STATED WHILE AT A STOP SIGN, THE STEERING WHEEL TURNED 360 DEGREES AND THE TIRES DID NOT REACT. THE VEHICLE WAS TOWED TO THE DEALERSHIP, WERE IT WAS DETERMINED THIS IS THE SAME PROBLEM AS INDICATED IN NHTSA RECALL # 03V196000, REGARDING THE SHAFT SECTOR. THE VEHICLE IDENTIFICATION NUMBER WAS NOT INCLUDED IN THE RECALL. *JB UPDATED 2/24/2006 - THE CONSUMER CONTACTED THE MANUFACTURER ABOUT THE PROBLEM. THEY EXPLAINED THAT THE FAILURE WAS JUST A COINCIDENCE. *NM

I WAS DRIVING ALONG ON RT 295 DURING A RAIN STORM AND MY WINDSHIELD WIPERS STOPPED WORKING ALONG WITH OTHER ELECTRICAL COMPONETS IN MY TRUCK. I DRIVE A 97 FORD F250 4X4 XLT. LUCKILY I WAS NOT INJURED. I TOOK MY TRUCK TO BE FIXED WHERE I WAS TOLD THAT I NEEDED TO REPLACE MY GEM MODULE AND FUSE BOX. I THOUGHT THAT WAS ODD. THE MECHANIC SAID THAT THE WINDSHIELDS ON THE MODEL OF MY TRUCK IS KNOWN TO LEAK AND DAMAGE THOSE COMPONETS. I COULD OF GOT INTO A SERIOUS ACCIDENT THAT DAY, RESULTING IN DEATH OF ME OR OTHER PEOPLE ON THE ROAD. *JB

DT: THE CONTACT STATES THERE IS A NHTSA RECALL CAMPAIGN 97V171000 CONCERNING THE GEAR POSITION INDICATOR. THIS VEHICLE HAS THE SAME PROBLEMS AS INDICATED IN THE RECALL, BUT IT IS NOT INCLUDED IN THE RECALL DUE TO VIN. THE CONTACT REPAIRED THE VEHICLE AT HIS OWN EXPENSE.*AK

THE TRUCKS ENGINE WILL COMPLETELY STALL WHEN THE FUEL TANK IS LOW ON FUEL AND THE TRUCK COMES TO A QUICK STOP SUCH AS A RED LIGHT OR AT AN INTERSECTION. THE TRUCK WILL ALSO STALL WHEN THE FUEL TANK IS LOW ON FUEL AND THE TRUCK IS SLOWING DOWN OR STOPPING ON A DECLINE. THE STALLED TRUCK MUST BE STOPPED, THE TRANSMISSION MUST BE PUT BACK INTO "PARK," AND THE VEHICLE RESTARTED BEFORE PROCEEDING WITH TRAVELS. ON TWO OCCASIONS, THE TRUCK HAS STALLED UNEXPECTEDLY IN AN INTERSECTION, NEARLY RESULTING IN A COLLISION FROM VEHICLES FOLLOWING TOO CLOSELY BEHIND. THE STALLING DOES NOT OCCUR WHEN THE TRUCKS FUEL TANK LEVEL IS ABOVE A QUARTER TANK AND THE VEHICLE IS BROUGHT TO A QUICK STOP, OR SLOWED AND/OR STOPPED WHILE HEADING DOWN A DECLINE. *JB

TRUCK WAS PARKED ON STREET FOR APPROXIMATELY 2 HOURS. NOTICED AN ORANGE GLOW THROUGH THE TREES. RAN OUT AND DISCOVERED MY TRUCK TOTALLY ENGULFED IN FLAMES. POLICE AND FIRE COMPANY ARRIVED ON SCENE. FIRE WAS EXTINGUISHED. INSURANCE HAS TOTALED THE TRUCK. *JB

WHILE DRIVING, THE SEAT RECLINED WHICH LEFT THE DRIVER LAYING COMPLETELY DOWN. *JB THE SEAT BASE ASSEMBLY HAD BROKEN ON THE DRIVER'S SIDE FRONT SEAT. *SC THE TIE RODS HAD TO BE REPLACED. THE CONSUMER WAS UNABLE TO SHIFT GEARS, BECAUSE THE SHIFTER BOLTS HAD BROKE LOOSE FROM THE DASH MOUNTS, THE HEAD GASKETS FAILED AND THE CHECK ENGINE LIGHT NEVER ILLUMINATED. THE HUB/AXLE SEALS WERE REPLACED. *JB

DT: CONSUMER STATES THAT THE STEEL BRAKE LINES WERE RUSTED. CONSUMER NOTICED THE PROBLEM WHEN HE STEPPED ON THE BRAKES AND THEY WENT TO THE FLOOR IN AUGUST 2004. THEN , IN JUNE 2005 THIS HAPPENED AGAIN ON THE FRONT LINES. IN AUGUST 2004 CONSUMER REPLACED THE BRAKE LINE HIMSELF IN THE REAR, WHICH WAS STILL GOOD. *AK