1999 FORD F-250 SD Complaints

I WAS DRIVING ON THE FREEWAY AT 65 MPH WHEN THE TRUCK SUDDENLY SHUT DOWN AND THEN TURNED BACK ON ALMOST INSTANTLY. THE AMOUNT OF TRAFFIC AND FREEWAY SPEEDS MADE THIS A VERY DANGEROUS SITUATION. I GOT OFF THE FREEWAY AND MY TRUCK PROCEEDED TO SHUT OFF TWO MORE TIMES BEFORE I ARRIVED AT HOME. I CALLED THE FORD DEALER AND DESCRIBED WHAT HAD HAPPENED AND THE FIRST THING THE SERVICE ADVISOR STATED "ITS THE CPS WE SEE IT ALL OF THE TIME". I REPLACED THE CPS AND SURE ENOUGH IT RAN GREAT AGAIN. THE COST OF THE NEW CPS WAS $180.00. *TR

TL*THE CONTACT OWNS 1999 FORD F250 SUPER DUTY. WHILE DRIVING 25 MPH ON A CLEAR DAY THE CONTACT SUDDENLY LOST CONTROL OF THE VEHICLE'S ACCELERATION SPEED. THE VEHICLE WAS TOWED TO THE DEALER, WHO STATED THAT THE ELECTRONIC SENSOR THAT CONTROLLED ACCELERATION HAD NO LINK TO THE ACCELERATOR PEDAL. THEREFORE, WHEN THE SENSOR FAILED, IT NEEDED TO BE REPLACED. THIS FAILURE HAS OCCURRED THREE TIMES. *AK UPDATE 05/10/07*TR

MY 1999 FORD F-250 SUPER DUTY 7.3 POWER STROKE DIESEL ENGINE HAD INTERMITTENT ENGINE FAILURE WHILE DRIVING. THIS CAUSED THE VEHICLE TO DIE IN PRECARIOUS LOCATIONS, SUCH AS INTERSECTIONS AND FREEWAYS. THIS ORIGINALLY OCCURRED WITHIN TWO WEEKS OF THE VEHICLE PURCHASE DATE WHEN IT WAS NEW IN OCTOBER 1998. I HAVE RESEARCHED THIS PROBLEM, AND THE CPS WAS THE KNOWN CAUSE. I HAVE OWNED THE VEHICLE SINCE IT WAS NEW. I HAVE NOT RECEIVED A RECALL NOTICE FROM FORD, AND HAVE BEEN UNABLE TO LOCATE A RECALL ON THEIR POWER STROKE WEBSITE. ACCORDING TO THE MANY WEBSITES DEALING WITH THE POWER STROKE DIESEL, BOTH THE 7.3 AND THE 6.0 LTR MODELS, THIS PROBLEM WAS CONSISTENT THROUGHOUT THE MARKETPLACE. I AM REPORTING THIS BECAUSE THE PROBLEM WAS DANGEROUS AND ACCORDING TO FORD'S SAME POWER STROKE WEBSITE - WWW.POWERSTROKEDIESEL.COM "SINCE 1994 OVER 2,000,000 POWER STROKE ' DIESEL EQUIPPED FORD TRUCKS HAVE BEEN PRODUCED '' AND AN ASTONISHING 98.5%* ARE STILL ON THE ROAD!" AS OF TODAY'S DATE. CAN NHTSA TELL ME IF THIS PROBLEM HAS BEN IDENTIFIED PREVIOUSLY, AND WHETHER OR NOT RECALL RECOMMENDATIONS HAVE BEEN MADE?*AK

THE MAIN FORE-AFT BRAKE LINE RUSTED THROUGH WHERE IT FOLLOWS THE FRAME RAILS ON MY 1999 FORD SUPERDUTY PICKUP. AS A RESULT, THE LINE FAILED, AND I LOST ALL BRAKING CAPABILITIES. LUCKILY, THIS HAPPENED AT HOME, AND NO INJURY OR CRASH OCCURED. *JB

THE CAMSHAFT POSITION SENSOR ON MY 1999 FORD 7.3L POWERSTROKE DIESEL WENT OUT UNEXPECTEDLY TWICE. *NM

1999 F250 SUPER DUTY 7.3L DIESEL. CPS SENSOR FAILED AND CAUSED THE ENGINE TO STALL WHILE DRIVING 65 MPH ON FREEWAY. THERE WAS NO POWER STEERING OR BRAKES. VEHICLE VERY HARD TO CONTROL. I REPLACED THE CPS SENSOR(F7TZ-12K073-A- SYNCHRONIZER) AND REPAIRED THE PROBLEM. VERY SIMILAR TO THE THICK FILM IGNITION ISSUES FROM THE PAST. THE OLD PART IS AVAILABLE TO THE NHTSA. *NM

DT*: THE CONTACT STATED WHILE BACKING DOWN A HILL AT 4 MPH, SMOKE WAS NOTICED COMING FROM UNDER THE HOOD. THE VEHICLE WAS STOPPED, THE HOOD WAS RAISED, AND FLAMES WERE NOTICED COMING FROM THE PASSENGER SIDE OF THE ENGINE. THE CONTACT EXTINGUISHED THE FIRE BY PUTTING SNOW ON THE ENGINE COMPARTMENT. THERE WAS NOTHING UNUSUAL ABOUT THE WAY THE VEHICLE HAD OPERATED PRIOR TO THE FIRE. THE CONTACT EXPRESSED THAT THE FIRE COULD HAVE BEEN CAUSED DUE TO TRANSMISSION FLUID LEAKING ONTO THE CATALYTIC CONVERTER. THE DEALER OR MANUFACTURER WERE NOT CONTACTED. THE AUTOMATIC TRANSMISSION WAS REPLACED 3 TIMES PRIOR TO THE INCIDENT. UPDATED 12/28/2006 - *NM

TRUCK STOPPED RUNNING ON FREEWAY. NEEDED TOWING. MISSED WORK. FORD 7.3 DIESEL "CPS" SENSOR FAILURE. THESE PARTS DON'T LAST AND CAUSE THE TRUCK TO STOP RUNNING. NEEDED $200.00 PART TO FIX. SECOND TIME. HAVE THE OLD PARTS. *JB

I OWN A 1999 FORD F250 7.3 TURBO DIESEL. I HAVE HAD THE CAM POSITIONING SENSOR GO OUT ON THE TRUCK. WHEN THIS HAPPENS, THE TRUCK JUST STOPS RUNNING. I WAS TRAVELING ON THE FREEWAY IN LOS ANGELES. WHEN THIS HAPPENS, THERE IS NO POWER STEERING, POWER BRAKES AND THE ENGINE MAY OR MAY NOT START UP AGAIN. THIS IS CERTAINLY A SAFETY HAZARD. I KNOW THAT THIS IS NOT UNCOMMON FOR THIS TO HAPPEN WITH THIS ENGINE. I THINK FORD SHOULD RECALL THIS PART AND REPLACE IT WITH SOMETHING BETTER. *JB

1999 FORD F-250 SD (SUPER DUTY DIESEL) PICKUP TRUCK. ON 11/07/06, THE PICKUP TRUCK WAS BEING OPERATED ON A PAVED HIGHWAY IN MISSOURI. WHEN THE DRIVER ATTEMPTED TO NEGOTIATE A CURVE, THE STEERING FAILED, THE TRUCK CONTINUED STRAIGHT (OFF-COURSE), BUT DRIVER WAS ABLE TO GENTLY BRING VEHICLE TO A ROLLING STOP. THERE WAS NO IMPACT OR HARSH DRIVING INVOLVED. INSPECTION REVEALED THAT THE HARDENED ("NEVER SUPPOSED TO BREAK") STEEL BOLT THAT CONNECTS THE LONG TIE ROD TO THE PITMAN ARM WAS COMPLETELY BROKEN IN TWO. THE FAILURE OF THIS BOLT CAUSED THE COMPLETE LOSS OF STEERING TO THE ENTIRE VEHICLE, CAUSING THE VEHICLE TO CONTINUE ON ITS STRAIGHT COURSE, UNTIL BEING BROUGHT TO A HALT BY THE DRIVER. INSPECTING MECHANIC WAS SURPRISED BY THE COMPLETE FAILURE OF THE VEHICLE'S STEERING SYSTEM. *JB