2008 FORD F-250 SD Complaints

2008 FORD F250 SUPER DUTY: IGNITION SWITCH WHEN TURNED TO START/CRANKING POSITION DOES NOT RETURN TO NORMAL RUN POSITION. THIS LEAVES INSTRUMENTS BLANK AND INOPERATIVE, AND ALL POWER ACCESSORIES FAIL TO OPERATE UNTIL TRUCK IS SHUT OFF & RESTARTED. *TR

TL*THE CONTACT OWNS A 2008 FORD F250 SUPER DUTY. THE CONTACT STATED THAT WHILE DRIVING AT 70 MPH OVER AN UNEVEN SURFACE, THE FRONT END OF THE VEHICLE WOULD SHAKE AND VIBRATE. THE STEERING AND TRACTION CONTROL ALSO FAILED. UPON DECELERATION THE FAILURE WOULD STOP. THE PROBLEM OCCURRED THREE TIMES. THE VEHICLE WAS TAKEN TO AN AUTHORIZED DEALERSHIP BUT THE DEALER COULD NOT DUPLICATE THE FAILURE. THE DEALER INFORMED THE OWNER THAT SOME OF THIS YEAR AND MODEL HAD THE "DEATH SHAKE" BUT THERE WAS NOTHING THEY COULD DO ABOUT IT; SHE WAS ADVISED TO NOT DRIVE THE VEHICLE. THE FAILURE MILEAGE WAS APPROXIMATELY 15,000. THE CURRENT MILEAGE WAS APPROXIMATELY 24,000.

TANK FULL OF DIESEL FUEL CONTAMINATED WITH WATER AND SOME DEBRIS. FORD WILL NOT WARRANTY BUT SEVERAL PARTS OF THE FUEL SYSTEM DEVELOPING RUST. THIS VEHICLE IS EQUIPPED WITH A FUEL WATER SEPARATOR AS STANDARD EQUIPMENT. SO FORD HAS EQUIPPED THE TRUCK WITH A FUEL WATER SEPARATOR BUT SEVERAL OF THE PARTS IN THE FUEL SYSTEM ARE VERY SUBJECT TO RUST IF THERE IS ANY EXPOSURE TO WATER. SO AS SOON AS THE VEHICLE IS EXPOSED TO WATER IN THE FUEL THERE ARE PARTS THAT WILL FAIL AND ARE NOT COVERED BY WARRANTY. *TR

BOTH FRONT WHEELS ON MY 2008 FORD KING RANCH F-250 PICK-UP ARE CRACKING AND NEED TO BE REPLACED. THE CRACKS ARE IN THE WELD AREA ON THE FLAT PART OF THE WHEEL UNDER THE TIRES CAUSING THE TIRES TO NO LONGER HOLD AIR. FORD CUSTOMER SERVICE CLAIMS THE PROBLEM IS MINE SINCE THE TRUCK RECENTLY SURPASSED WARRANTY MILEAGE HOWEVER I AM CERTAIN THIS IS A SERIOUS SAFETY ISSUE. THE WHEELS ARE READY TO COME APART AND COULD HAVE CAUSED A SERIOUS ACCIDENT . IF THE TIRES HAD NOT BEGUN TO LOSE AIR I WOULD HAVE NEVER KNOWN THEY WERE CRACKING. THIS TRUCK HAS HAD THE BEST OF CARE AND HAS NEVER HIT ANYTHING OR BEEN IN ANY KIND OF ACCIDENT. FORD DENIED RESPONSIBILITY WITHOUT EVEN EXAMINING THE CRACKED WHEELS. THE TIRE SHOP BELIEVED THE SITUATION WAS SO UNSAFE THAT THEY RECOMMENDED TOWING INSTEAD OF DRIVING THE TRUCK. THIS CASE # 1526770470 WITH FORD WAS DENIED AND THEY QUOTED OVER 800 DOLLARS PER WHEEL TO REPLACE THE CRACKED WHEELS. ALL AFTER MARKET WHEELS I CHECKED ON WERE AROUND 250 DOLLARS WITH A LIFETIME GUARANTEE. I HAVE WORKED IN CONSTRUCTION FOR OVER 30 YEARS AND HAVE OWNED SEVERAL VEHICLES AND HAVE NEVER ENCOUNTERED ANYTHING LIKE THIS. *TR

DRIVING AROUND AND DIESEL FUEL SMELL CAME INTO THE CAB OF THE TRUCK AND SMOKE FROM ENGINE COMPARTMENT. THIS TRUCK HAS A 6.4L JOB 1 DIESEL. WE HAD THE TRUCK TOWED TO THE FORD DEALERSHIP BECAUSE DRIVING IT MAKES ME SICK TO MY STOMACH AND LIGHT HEADED. FORD TELLS US IT WILL HAPPEN EVERY 100-600 MILES AND LAST 10-40 MINUTES EACH TIME DURING REGENERATION. FORD SAYS THIS IS A 'NORMAL OPERATION CHARACTERISTIC OF THE VEHICLE'. THE DEALERSHIP REFERENCED TSB 09-16-9 AND TOOK THE TIME TO HIGHLIGHT CERTAIN AREAS. #1 - I WAS NOT IN COLD AMBIENT TEMPERATURE AT THE TIME THE SMOKE WAS COMING FROM THE ENGINE COMPARTMENT AND #2 - THIS IS NOT A BRAND NEW TRUCK ALTHOUGH WE DO HAVE LOW MILEAGE. HOW CAN THIS BE CONSIDERED NORMAL IF IT HAD NEVER HAPPENED BEFORE AND NOW MAKES ME SICK WHEN I DRIVE THE TRUCK? THE SMELL IS STILL FAINTLY IN THE HEADLINER OF THE TRUCK. WHAT IS IN THIS STUFF THAT MADE ME LIGHT HEADED AND SICK TO MY STOMACH?*CW

1. DRIVING AT SPEEDS OF 65MPH+ IN A 2008 FORD F-250. 2. HIT A MINOR SEAM IN THE PAVED ROAD. 3. FRONT END WOBBLE (KNOWN ON MANY INTERNET SITES AT THE "FORD DEATH WOBBLE". MY TRUCK WAS UNDER WARRANTY AND I TOOK IT TO FORD DEALER THE NEXT DAY. THEY TIGHTEN THE PITMAN ARM. THERE WAS A FORD TECHNICAL SERVICE BULLETIN ISSUED FOR THIS PROBLEM AND IT INDICATED IMPROPER TIRE PRESSURE. TOTALLY NOT TRUE. THE FRONT END WOBBLE WAS SO SEVERE IT MADE ME CROSS INTO ON-COMING LANES OF TRAFFIC. LUCKILY NO ONE WAS COMING THE OTHER WAY OR THERE WOULD HAVE BEEN A SERIOUS ACCIDENT. THE FORD DEALER ALSO REPLACED THE FRONT STABILIZER SHOCK. THE VERY NEXT DAY THE EXACT SAME THING HAPPENED. VIOLENT FRONT END WOBBLE AT 65MPH+ AND WHEN A SMALL BUMP WAS HIT. I HAD TO SLOW THE TRUCK DOWN TO 20MPH ON AN INTERSTATE FREEWAY IN ORDER TO GET THE WOBBLE TO STOP AND ALMOST CAUSED ANOTHER ACCIDENT. TWO HOURS LATER IT HAPPENED AGAIN! VIOLENT WOBBLING OF THE FRONT END. THE DEALER CLAIMS THERE IS NOTHING WRONG WITH THE TRUCK. HOWEVER, AFTER RESEARCHING THE MATTER ON THE INTERNET THERE ARE HUNDREDS OF CASES OF THIS SAME PROBLEM. CHECK OUT: WWW.SUPERDUTYWOBBLE.COM OR OTHER SITES. THIS HAS GOT TO BE A MANUFACTURING ERROR THAT DESERVES A RECALL NOTICE. THE FORD DEALER CANNOT FIND ANYTHING WRONG! PLEASE HELP! *TR

I OWN A FORD F250, MY COMPLAINT IS ABOUT A 7 PIN TRAILER PLUG, WHAT HAPPENS IS THAT THE PLUG FALLS OFF THE CONNECTOR AS I AM DRIVING. I HAVE NOTICED THAT FORD CHANGED THERE DESIGN ON THE PLUG, THEY TURNED IT TO THE RIGHT SO THE LOCK IS SIDE, INSTEAD OF BEING ON THE TOP. I HAVE TRY TO TALK TO FORD ABOUT THIS AND THEY SAY THERE'S NOTHING THEY CAN DO. I DO BELIEVE THAT THIS IS A SAFETY ISSUE, I LOOSE MY BRAKES TO MY TRAILER EVERYTIME THIS HAPPENS MAKING IT VERY UNSAFE TO DRIVE. *TR

EVERYTIME I DRIVE AND THERE ARE 'WHOOPS' IN THE ROAD, MY TRUCK VIOLENTLY BOUNCES.THIS HAPPENS EVERYTIME. AND MY STEERING FEELS VERY LOOSE FROM IT. I CAN SEE MY FRONT TIRES SHAKING HARD, LIKE THEY'RE ABOUT TO FLY OFF THE WHEEL STUDS. IT STARTED ABOUT A MONTH AGO IN MY NEIGHBORHOOD ROADS. *TR

I HAVE A 2008 F-250 S/D MANUFACTURED 02/08 AT THE KENTUCKY PLANT. THIS VEHICLE WAS PURCHASED NEW IN APRIL 2009 AND NOW HAS JUST UNDER 8000 MILES ON THE ODOMETER. I HAVE TWICE EXPERIENCED UNCONTROLLED INVOLUNTARY ACCELERATION WITH THIS VEHICLE. THE COMMON ELEMENTS OF THIS HAVE BEEN THAT IT OCCURRED AFTER A PERIOD OF EXTENDED DRIVING AT ABOUT 70 MPH, USING CRUISE CONTROL, JUST AFTER AN EXHAUST CLEANING CYCLE, AND WHEN I OVERRODE THE CRUISE CONTROL TO ACCELERATE TO PASS A VEHICLE IN FRONT OF ME. WHEN PULLING BACK IN TO THE TRAFFIC LANE, THE VEHICLE CONTINUES TO ACCELERATE AND CAN BE CONTROLLED ONLY BY MAINTAINING HEAVY PRESSURE ON THE BRAKES UNTIL A SAFE LOCATION CAN BE FOUND TO PULL OFF THE ROAD AND CUT OFF THE IGNITION. A RESTART IN NEUTRAL WILL RESULT IN AN IMMEDIATE RUN-UP IN RPM WHICH REQUIRES A SHUT DOWN OF THE IGNITION. THERE ARE NO "CHECK ENGINE" OR "SERVICE ENGINE" LIGHTS DISPLAYED, AND ACCORDING TO FORD DEALERSHIPS, NO CODES REGISTERED IN THE PCM. IN BOTH CASES I HAVE BEEN ABLE TO CORRECT THE PROBLEM AND CONTINUE TO DRIVE THE VEHICLE (WITHOUT USE OF CRUISE CONTROL) BY PRESSING A "RESET" BUTTON LOCATED ON THE TOP OF A WHITE SENSOR LOCATED IN THE AIR INTAKE DUCT ON THE RIGHT SIDE OF THE ENGINE COMPARTMENT. FORD SAYS THEY ARE UNABLE TO DUPLICATE THE PROBLEM AND CONSEQUENTLY CANNOT "MAKE A FIX". I AM MOST CONCERNED BECAUSE THIS IS A SIGNIFICANT SAFETY ISSUE. *TR

DEFECTIVE RADIATIOR IN 2008 F-250 (AND F-350 THROUGH RESEARCH OF OWNER FORUMS) ARE DEFECTIVE AND LEAK AT OVER 40,000 MILES. DEALERSHIPS ARE REPLACIING THESE AT OWNER COST BY THE HUNDREDS. *TR