1999 FORD F-250 SD Complaints

1999 FORD SD F250 CREW CAB LONG BED - DIESEL 6 SPD MANUAL: FRONT LEFT BREAK LINE CUT BY ENGINE PLASTIC SPLASH SHIELD. VEHICLE HAS 158K MILES NO RUST ON BREAK LINE BUT YOU CAN TELL THAT THE SPLASH SHIELD HAS BEEN RUBBING AGAINST THE METAL LINE. THERE IS OBVIOUSLY NOT ENOUGH CLEARANCE CREATED IN THE SPLASH SHIELD DESIGN. I AM NOT SURE IF THIS APPLIES ONLY TO DIESEL APPLICATIONS DUE TO THE HYDRAULIC POWER ASSIST . THIS ALMOST CREATED SERIOUS ACCIDENT WHEN THE LINE RUPTURED; WE WERE PULLING A 26 FT TRAILER WHICH HAD ELECTRIC BREAKS THAT HELP STOP THE VEHICLE BEFORE WE REACHED A MAJOR INTERSECTION. THE TRUCK HAD JUST BEEN IN FOR SERVICE AT THE FORD DEALERSHIP TWO DAYS BEFORE FOR VARIOUS SERVICES. THERE WAS NO WARNINGS THE BREAKS WERE FIRM AND THE THEY WENT WITHG ONE STEP OF LAST STEP ON THE BREAK. BREAK LINE WILL NEED TO BE REPLACED, MODIFIED TO MISS SPLASH SHEILD OR SPLASH SHEILD WILL NEED TO BE MODIFIED TO ASSURE CLREARANCE TO BREAK LINE.

THE VEHICLE WAS PARKED FOR TWENTY MINUTES. THERE WAS A LOUD NOISE, THE CONSUMER WENT TO SEE WHAT CAUSED THE NOISE, AND DISCOVERED, THE VEHICLE ENGINE WAS ON FIRE. THE FIRE DEPARTMENT RESPONDED TO PUT THE FIRE OUT. *NM

FAIL TO BRAKE, FOUND HOLE IN BRAKE LINE TO REAR AXLE DUE TO CORROSION . I WILL REPLACE LINE ASAP.

VEHICLE WAS BACKING OUT OF A DRIVEWAY AND THE STEERING WHEEL SNAPPED. THE PITMAN ARM DISENGAGED, CAUSING THE VEHICLE TO LOSE STEERING POWER. OWNER CALLED THE DEALER FOR THE PART, BUT THE DEALERSHIP DID NOT HAVE THE PART. *AK PITMAN ARM WAS REPLACED. CONSUMER ADDS ALL 4 BALL JOINTS NEED TO BE REPLACED. *TT

TOWING AN EMPTY HORSE TRAILER, WHEN I STARTED TO EXPERIENCE THE VEHICLE STRUGGLING TO PULL IT. WHEN I GOT HOME AND WAS BACKING THE TRAILER UP, THE DRIVE WENT OUT ON THE VEHICLE, I WAS LEFT WITH ONLY REVERSE AND DRIVE 1. NOW THE DEALERSHIP SAYS THEY CANNOT FIND ANYTHING WRONG WITH THE TRANSMISSION AND IT'S GOING TO COST AROUND $900.00 DOLLARS FOR THEM TO TEAR IT APART AND TAKE A LOOK. I DO HAVE EXTENDED WARRANTY INSURANCE, BUT THEY WILL NOT COVER THE COST OF THE TEAR DOWN UNLESS THEY DO FIND SOMETHING WRONG, AND LOOKING AT SOME OF THE OTHER PROBLEMS ASSOCIATED WITH THE TRANSMISSION I CANNOT AFFORD TO HAVE THEM TEAR IT DOWN, FIND NOTHING WRONG AND PUT IT BACK TOGETHER AGAIN SEVERAL TIMES BEFORE THEY DO FIND WHAT'S MALFUNCTIONED. *JB

THE HORN HAS NOT BEEN WORKING FOR ALMOST 2 YEARS, I'VE CONTACTED FORD MANY TIMES WHERE I PURCHASED THE TRUCK. THEY SAID I WOULD HAVE TO PAY IF I WANT IT FIXED. ON YOUR WEB-SITE, (NHTSA) MANY COMPLAINTS ALREADY ABOUT THIS ISSUE, ITS A SAFTY ISSUE. BECAUSE WHEN YOU TRY TO USE THE HORN IT SEEMS AS THE AIRBAG IS IN THE WAY. *AK

VEHICLE WAS PARKED FOR THE NIGHT (IGNITION WAS OFF). VEHICLE BURNED DUE TO FIRE FROM UNDER THE HOOD CAUSED BY ELECTRICAL FAILURE. TOTAL LOSS (REPAIRS TO EXCEED VALUE). VEHICLE IS STILL IN MY POSSESSION. I WAS RECENTLY MADE AWARE OF A FORD RECALL FOR CRUISE CONTROL COMPONENTS CAUSING UNDERHOOD FIRES OF SIMILAR NATURE AND CONSEQUENCE ON SIMILAR VEHICLES.*AK

RIGHT SIDE 3RD SPARK PLUG BLEW OUT OF ENGINE, AND FORD NEW AND KNOWS ABOUT IT AND ARE NOT DOING A --- THING ABOUT IT. YOU CANT EVEN GET A REMANUFACTURED ONE BECAUSE THERE NOT GETTING THEM BACK FAST ENOUGH TO FIX THE OLD ONE. SO NOW I AM PAYING $3500, TO FIX THERE PROBLEM. IT IS WRONG. I CANT EVEN PAY MY HOSPITAL BILL AND NOW I HAVE TO COME UP WITH $3500. FORD SHOULD BE STRON - UP. *JB

WHILE TRAVELING ON THE HIGHWAY AT APPROXIMATELY 70 MPH TREAD ON THE REAR DRIVER SIDE TIRE SEPARATED RAPIDLY, RESULTING IN COMPLETE DESTRUCTION OF THE TIRE. ONE WEEK LATER, THE LEFT FRONT TIRE TREAD SEPARATED. FIRESTONE STEEL TEX RADIAL A/T, SIZE LT265/75R16. THE DEALERSHIP REPLACED TIRE AT CONSUMER'S EXPENSE. *AK *SC

TIRES WERE PURCHASED IN DECEMBER, 2001 FROM A GOODYEAR DEALER. TIRES HAVE RECENTLY SEPARATED (TWO FRONT TIRES LAST WEEK) (TWO BACK TIRES THIS WEEK). NO BLOWOUTS HAVE OCCURRED; HOWEVER, WE WERE LUCKY. GOODYEAR AGREED TO REPLACE THE TIRES FOR US AT A DISCOUNTED PRICE, WHICH PRICE WAS FIGURED BASED ON THE "LIFE LEFT ON THE TIRE". THEY HAD NO KNOWLEDGE OF THIS RECALL AND NOW WE ARE OUT OF $232.+ FOR THE REPLACEMENT OF THE FIRST TWO TIRES. THEY ARE CURRENTLY IN THE PROCESS OF REPLACING THE SECOND TWO TIRES AT A RATE OF $96.00 A TIRE. GOODYEAR APPARENTLY HAS NO KNOWLEDGE OF THIS DEFECT/RECALL AND SHOULD BE NOTIFIED IMMEDIATELY OF THEIR INCOMPETENCE. *JB