1999 FORD F-250 SD Complaints

SPARK PLUG WAS BLOWN FROM THE HEAD. SUBSEQUENT DAMAGE TO THE CYLINDER HEAD AND CYLINDER WALL CREATED ENOUGH MATERIAL AND LABOR COSTS TO JUSTIFY REPLACING THE ENTIRE ENGINE.*AK

WHILE PULLING A TRAILER AT 65 MPH THERE WAS A NOISE IN THE FRONT PASSENGER SIDE . CONSUMER LOST CONTROL OF VEHICLE, AND IT WENT IN THE DIRECTION OF ONCOMING TRAFFIC. CONSUMER THEN TURNED THE STEERING WHEEL HARD TO THE RIGHT AND VEHICLE WENT TO THE RIGHT , DOWN AN EMBANKMENT, AND CRASHED INTO A DITCH. THIS COLLISION OCCURRED BECAUSE THE FRONT PASSENGER SIDE TIRE TREAD SEPARATED. *AK

WHILE APPLYING THE BRAKE PEDAL THE BRAKES FAILED . THIS CAUSED THE VEHICLE TO CONTINUE TO ACCELERATED AND THEN STOP. THE DRIVER WAS ABLE TO MAINTAIN CONTROL OF THE VEHICLE AND DROVE IT TO THE DEALER FOR INSPECTION. THE MECHANIC COULD NOT DUPLICATE THE PROBLEM. PLEASE PROVIDE FURTHER DETAILS. *NM *NM

I WAS MERGING INTO THE RIGHT LANE OF THE FREEWAY TO EXIT THE FREEWAY AND THERE WAS A LOUD BANG AND MY TRUCK DECELERATED AND CAUSED THE PERSON BEHIND ME TO SWERVE TO AVOID RUNNING INTO THE BACK OF ME. I TOOK MY TRUCK TO MY LOCAL ASE CERTIFIED MECHANIC AND WAS TOLD THE THIRD SPARK PLUG ON THE PASENGER SIDE HAD BLOWN OUT OF THE ALUMINIUM CYLINDER HEAD. THE CYLINDER PLUG OPENING WAS BORED OUT AND TAPPED. AN INSERT WAS THEN PUT INTO PLACE AND THE SPARK PLUG REPLACED. THE TOTAL COST OF THIS WAS ~$450. AFTER MUCH RESEARCH I HAVE DISCOVERED THAT THIS IS A VERY COMMON OCCURENCE ON THE FORD TRITON ENGINES AND THAT FORD IS DOING EVERYTHING THEY CAN TO AVOID TAKING ANY RESPONSIBILITY FOR THIS APPARENT DESIGN DEFECT. THIS STINKS!!!*AK

WAS TRAVELING AROUND 55 MPH AND THE PASSENGER'S REAR TIRE SEPARATED. WHEN THE THE TIRE SEPARATED, PART OF THE RUBBER CAME UP AND CAUSED DAMAGE TO THE RIGHT PASSEGERS SIDE BED. I PUT MY SPARE TIRE ON IT TO GET HOME. THE BED HAS NOT BEEN REPAIRED OR TIRE(S) REPLACED. HAVE PICTURES TO DOCUMENT THE DAMAGE. THE TIRE COMPANY WE BOUGHT THE TIRES FROM ADVISED US TO FILE THIS COMPLAINT. THEY ARE WILD COUNTRY, RADIAL RVT, SIZE- M+S 35X12.50R16.5LT 1230. *AK

ON 1999 FORD F250 DIESEL AUTOMATIC TRANSMISSION, SOMETIMES WHEN SHIFTING INTO SECOND AND THIRD GEARS TRANSMISSION WILL SLIP BEFORE GOING INTO GEAR AND SOMETIMES WHEN SHIFTING IT WILL "HUNT." THIS ONLY HAPPENS WHEN TRANSMISSION GETS HOT. HAVE TRIED SEVERAL TIMES TO GET HELP FROM THE DEALER/MANUFACTURER WITH NO SUCCESS.*AK

HAD A DEFECTIVE FIRESTONE STEELTEX BLOW OUT ON A REAR PASSENGER SIDE 1999 FORD PICKUP WHILE TOWING A BOAT. THE TIRES WERE VERY LOW MILEAGE AND HAD THE PROPER AMOUNT OF INFLATION. THE ENTIRE SIDEWALL OF THE TIRE DISENTEGRATED. THE TIRE HAS BEEN SENT TO FIRESTONE , AKRON FACILITY FOR A REVIEW BY EXPERTS TO TRY AND DETERMINE THE REASON FOR THE FAILURE. THE BLOWOUT WAS VERY VIOLENT CAUSING BODY DAMAGE TO THE WHEEL WELL OF THE TRUCK. IT IS FORTUNATE THAT THE FAILURE OCCURRED ON THE REAR OF THE TRUCK AS A FAILURE ON THE FRONT COULD HAVE CAUSED LOSS OF CONTROL OF THE VEHICLE. THE TIRES WERE IMMEDIATELY REMOVED FROM THE VEHICLE AND I STILL HAVE THEM MINUS THE ACTUAL BLOWOUT WHICH WAS SENT TO THE FIRESTONE FACILITY AS INDICATED ABOVE. *AK

WHILE TOWING A TRAILER (WITH EQUALIZER) THE LEFT REAR EMERGENCY BRAKE CABLE RUBBED AGAINST INSIDE OF LEFT TIRE CAUSING THE BRAKE CABLES RUBBER SLEEVE TO WEAR DOWN TO THE METAL BRAIDING AND THE TIRE TO BE WORN DOWN TO THE SIDEWALL CORDS (CAUGHT BEFORE TIRE RUPTURE) . THERE ISN'T A BRACKET OR RETAINING SYSTEM IN PLACE TO PREVENT THIS FROM HAPPENING. I HAD TO RE-ROUTE THE CABLE SLIGHTLY AND RESTRAIN IT WITH ELECTRICAL CABLE TIES. IT SEEMS THAT THIS CONDITION ONLY HAPPENS WHEN THE VEHICLE IS UNDER A LOAD. THE TIRE AND CABLE NEED TO BE REPLACED, AND ARE STILL ON HAND.*AK

A SPARK PLUG BLEW OUT OF THE ENGINE WHICH IS DUE TO A DESIGN FLAW THAT FORD MOTOR CO. IS WELL AWARE OF. THIS CAN HAPPEN WHEN THE ENGINE IS NEW OR IT HAS MANY THOUSANDS OR, IN MY CASE, HUNDREDS OF THOUSANDS, OF MILES ON IT. FORD IS WELL AWARE OF THE PROBLEM, AND THEY HAVE BEEN FORCED TO MAKE THE NECESSARY REPAIRS ON VEHICLES THAT ARE STILL UNDER WARRANTY. FOR THOSE VEHICLES, LIKE MINE, THAT ARE NO LONGER UNDER WARRANTY, THE FULL COST OF THE REPAIR IS LEFT UP TO THE CONSUMER. THE AVERAGE REPAIR COST FOR THIS MAJOR MALFUNCTION IS $2,500.00-$3,500.00. THIS IS AN UNACCEPTABLE SITUATION FOR THE BASIC FACT THAT FORD IS WELL AWARE OF THIS PROBLEM AND THEY ARE ON THE PUBLIC RECORD STATING THAT THEY WILL NOT ISSUE A RECALL FOR THESE ENGINES BECAUSE OF THE SIGNIFICANT EXPENSE FOR THEM TO FIX THEM ALL, BECAUSE THIS PARTICULAR ENGINE IS THE ONE THAT FORD INSTALLS IN MOST OF IT'S HIGH END TRUCKS AND SUVS. THIS POSITION BY FORD IS JUST NOT FAIR BUSINESS AND IT CERTAINLY IS NOT FAIR TO THE CONSUMER WHO SHOULD BE ABLE TO EXPECT A BETTER PRODUCT WHEN PAYING $25,000.00-$40,000.00 FOR SAID PRODUCT, ESPECIALLY WHEN THE DEFECT IS ONE KNOWN BY THE MANUFACTURER AND THEIR ENGINEERING TEAM WHO FINALLY REDESIGNED THE ENGINE IN THE 2002 MODEL YEAR TO AVOID THIS SPECIFIC PROBLEM. *JB

CONSUMER TRAVELING 65 MPH ON OEM FIRESTONE STEELTEX R4S TIRE WHEN DRIVER SIDE REAR TIRE TREAD SEPARATED CAUSING DAMAGE TO VEHICLE. *JB