1997 FORD F-250 SD Complaints

WENT TO START MY TRUCK ONE MORNING AND SMOKE CAME OUT FROM UNDERNEATH THE HOOD. THE CRUISE CONTROL SWITCH ON TOP OF THE BRAKE MASTER CYLINDER BURNED. I TURNED OFF THE IGNITION, OPENED THE HOOD AND PULLED THE WIRE FROM THE SWITCH. TRUCK IS 1997 FORD F250. I AM THE ORIGINAL OWNER OF THE TRUCK. I TOOK THE TRUCK TO CLINTON FORD IN ROCK HILL, SC AND THEY PUT A CRUISE CONTROL SWITCH IN AT A COST OF $292.09. NOW I SEE THAT THERE WAS A RECALL 05S28 THAT APPLIES TO THE TRUCK THAT I NEVER RECEIVED NOTICE FOR. MY COMPLAINT IS THAT FORD DID NOT NOTIFY ME OD THIS SAFETY RECALL. THEN WHEN THE RECALL REPAIR WAS PERFORMED, I WAS BILLED FOR THE REPAIR. *TR

MY CMP SENSOR STARTED GOING OUT WHEN ON THE FREEWAY AT 65 MPH AND DIED AND LOST STEERING AND BRAKES. IT WAS A CLOSE CALL AND WENT TO FORD AND THEY WANTED 200.00 FOR A SENSOR SO I CALLED INTERNATIONAL IT WAS 114.00 SAME PART. I AM NOT HAPPY ABOUT FORD AND THERE PRICES. *JB

TL* THE CONTACT OWNS A 1997 FORD F-250HD. THE OIL PAN RUSTED AND CAUSED THE OIL TO LEAK. THE CONTACT OBSERVED THAT THERE WAS NO OIL IN THE ENGINE. THE CONTACT ADDED OIL TO THE ENGINE DAILY AND NOTICED THE FOLLOWING DAY THAT THE OIL GAUGE INDICATOR WAS LOW. THE CONTACT ATTEMPTED TO DRIVE THE VEHICLE TO THE DEALER AND HEARD A NOISE IN THE ENGINE. THE FAILURE MILEAGE WAS 63989. THE DEALER INFORMED THE CONTACT THAT THE OIL PAN DETERIORATED. THE MANUFACTURER ADVISED THE CONTACT TO CALL NHTSA. PER THE CONTACT, IT WAS UNUSUAL FOR AN OIL PAN TO RUST AND IT WAS A SAFETY CONCERN. THE CURRENT MILEAGE WAS 64,000. *AK UPDATED 06/15/07 *TR

ON MARCH 2ND,2007 MY F250 DIESEL PICKUP, THAT WAS IDLING IN THE DRIVEWAY CAUGHT ON FIRE. THE FIRE STARTED ON THE DRIVER'S SIDE OF THE VEHICLE AND IT MELTED THE BRAKE FLUID RESERVOIR AND BURNT UP THE AREA SURROUNDING IT. MY 11 YEAR OLD SON NOTICED THE BLAZE AND SHUT OFF THE TRUCK AND POPPED THE HOOD AND TRIED TO SHOVEL SNOW TO PUT OUT THE FIRE. I QUICKLY OPENED THE HOOD AND PUT THE FIRE OUT WITH THE SURROUNDING SNOW. I CONTACTED FORD ABOUT A RECALL THAT THEY HAVE ON THE GASOLINE PICKUPS AND THEY TOLD ME THERE WERE NO RECALLS ON MY VEHICLE. I TALKED TO A LOCAL FORD MECHANIC THAT SAID IT SOUNDED LIKE THE CRUISE CONTROL IS WHAT STARTED THE FIRE. HE THEN GAVE ME THE PHONE NUMBER FOR CUSTOMER SERVICE AND THEY SENT ME A LETTER THAT STATED THERE WAS NOTHING THEY COULD DO. I AM NOT SURE WHAT MY NEXT STEP SHOULD BE, BUT I AM OUT A TRUCK AND I WOULD HATE TO SEE ANY ONE GETTING HURT BECAUSE OF AN OVERSIGHT BY THE FORD MOTOR COMPANY. *JB

1. NO EVENT PRIOR TO THE FAILURE. FAILURE OCCURRED WITHOUT WARNING. 2. FAILURE OF THE CRANK POSITION SENSOR ON FORD F250 WITH 7.3 LITER NAVISTAR DIESEL WITH RESULT THAT TRUCK WOULD NOT START OR RUN. 3. CALLED A FORD MECHANIC WHO SAID THIS HAPPENS REGULARLY AND I SHOULD CARRY A SPARE CPS. REPLACED CPS AND TRUCK STARTED AND RAN PROPERLY. PART COST ABOUT $190. NB: I HAVE TO SEARCH RECORDS FOR THE DATE - ABOUT TWO YEARS AGO. DATE BELOW IS NOT ACCURATE. *JB

TRUCK WAS PARKED ON STREET FOR APPROXIMATELY 2 HOURS. NOTICED AN ORANGE GLOW THROUGH THE TREES. RAN OUT AND DISCOVERED MY TRUCK TOTALLY ENGULFED IN FLAMES. POLICE AND FIRE COMPANY ARRIVED ON SCENE. FIRE WAS EXTINGUISHED. INSURANCE HAS TOTALED THE TRUCK. *JB

DT: CONSUMER STATES THAT THE STEEL BRAKE LINES WERE RUSTED. CONSUMER NOTICED THE PROBLEM WHEN HE STEPPED ON THE BRAKES AND THEY WENT TO THE FLOOR IN AUGUST 2004. THEN , IN JUNE 2005 THIS HAPPENED AGAIN ON THE FRONT LINES. IN AUGUST 2004 CONSUMER REPLACED THE BRAKE LINE HIMSELF IN THE REAR, WHICH WAS STILL GOOD. *AK

DT: 5TH WHEEL CAMPER HAD A TOTAL OF 8 BLOW OUTS IN LESS THAN 3 YEARS. CONSUMER'S VEHICLE HAD 3 BLOW OUTS IN THE LAST 3 MONTHS WITH LESS THAN 2,000 MILES ON THE TIRES. THE TIRES WERE MANUFACTURED BY CARLISLE. CONSUMER WAS WORRIED ABOUT 2 PLY TIRES. CONSUMER WAS CHANGING THE TIRE SIZE TO AN UPGRADED SIZE AND TO 8 PLY TIRE. TIRES THAT BLEW OUT WERE CARLISLE AND GOODYEAR. CONSUMER HAD A 1997, DAMON, CHALLENGER. . THEY FIRST SET OF TIRES HAD KNOTS ON THEM. CONSUMER HAS NOT CONTACTED ANY OF THE DEALERSHIPS THAT SOLD THE TIRES. CONSUMER WANTED THE MANUFACTURER TO STOP SELLING THE TIRES TWO PLY SIDEWALLS WERE NOT ENOUGH TO CARRY THE WEIGHT OF THE TRAILER. CONSUMER THOUGHT THAT THE TWO PLY TIRES WERE A SAFETY HAZARD. THE SPEEDS WAS FROM 55-60 MPH WHEN THE TIRES BLEW OUT. THE FAILURE LOCATION INCLUDED ALL FOUR LOCATIONS, ON BOTH AXLES. *AK

DT: APPROXIMATELY 4 MONTHS AFTER PURCHASING A TRAVEL TRAILER CONSUMER SET OUT FOR A TRIP AND THE TIRES BEGAN BLOWING OUT ABOUT 200 MILES AFTER THEY STARTED. THREE OF THE TIRES BLEW OUT ON THIS TRIP FROM KENTUCKY TO NEVADA. THE SIDEWALLS BLEW OUT, AND ONLY THE RIMS WERE LEFT. CONSUMER CONTACTED GOODYEAR, AND WAS TOLD THERE WAS NO RECALL. BUT THERE WAS A BETTER TIRE HE COULD PURCHASE. DEALERSHIP WHERE HE PURCHASED THE VEHICLE TOLD HIM THEY WEREN'T RESPONSIBLE FOR THE TIRES. BEFORE THIS HAPPENED CONSUMER MADE SURE THERE WAS ENOUGH AIR IN THE TIRES, AND THE LOAD WASN'T TOO HEAVY. THE FENDER WAS TORN UP DUE TO THIS PROBLEM.*AK

DT: CONTACT OWNS A 1997 FORD F250. HE SAID THE VEHICLE STARTED RUNNING ROUGH SO HE TOOK IT TO THE SHOP, AND THEY CLEANED HIS FUEL INJECTION. THE TRUCK HAS TWO FUEL TANKS. THE FRONT FUEL TANK COMPLETELY QUIT WORKING THE REAR TANK WORKED. NOW HE SAYS THAT THE REAR TANK KEEPS ON FILLING THE FRONT TANK WITH GAS AND THERE IS SO MUCH PREASSURE FROM THE TANKS THAT GAS JUST STARTS RUNNING DOWN THE SIDE OF HIS VEHILCE AND WHEN HE OPENS THE GAS CAP FUEL STARTS SQUIRTING OUT HE SAID IT WOULD SQUIRT OUT ABOUT A HALF GALLON OF GAS. HIS SMOG CHECKEDWAS DO LAST WEEK AND SINCE HIS CHECK ENGINE LIGHT CAME ON THEY WILL NOT DO THE SMOG. THE DEALER SAID HE WAS MISSING A CHECK VALUVE BETWEEN THE FUEL TANKS AND THE DEALER TOLD HIM BOTH FUEL PUMPS HAD TO BE REPLACED.*AK