2000 FORD F-250 SD Complaints

I WAS JUST SECONDS AWAY FROM GETTING ON THE HIGHWAY WHEN THE STEERING WENT COMPLETELY OUT!! IT HAPPENED IN THE FOLLOWING WAY. AFTER MAKING A LEFT TURN, FORTUNATELY I LOOKED DOWN AND NOTICED THE STEERING WHEEL WAS ABOUT 90 DEGREES OFF FROM CENTER. WITH MY MECHANICAL BACKGROUND I KNEW THAT THIS WAS SERIOUS AND PULLED OFF THE ROAD. I CHECKED THE TIE RODS, SUSPENSION, TIRES LOOKING FOR ANYTHING OBVIOUS AND DIDN'T FIND ANYTHING. GOT BACK IN THE TRUCK TO TEST THE STEERING WHEEL AND AS I TURNED THE WHEEL THERE WAS A SLIGHT RESISTANCE THEN POP AND THE WHEEL SPUN FREELY. OPENED THE HOOD AND THE SHAFT WAS CONNECTED TO THE BOX SPINNING FREELY. I WAS SECONDS AWAY FROM GETTING ON THE HIGHWAY!

BOUGHT THE TRUCK 2000 FORD F250 USED IN 2006 AND THE SEAT BELT RETRACTOR WOULD NOT RETRACT THE BELT WHEN NOT IN USE. THE BELT WOULD GET CAUGHT IN THE DOOR WHEN IT WAS CLOSED. I WOULD HAVE TO OPEN THE DOOR TO GET THE SEAT BELT LOOSE SO IT COULD BE USED. THIS PROBLEM MAKES USING THE SEAT BELT A MAJOR PROBLEM EACH TIME I GET INTO THE TRUCK. I BOUGHT A NEW BELT AND RETRACTOR FROM FORD FOR ABOUT $120 AND IT WORKED FOR ABOUT A MONTH AND IT BECAME THE SAME AS THE OLD SEAT BELT. THIS IS A PROBLEM ON ALL 2000 MODEL TRUCKS AND FORD WILL NOT CORRECT THE PROBLEM. THIS PROBLEM CAUSES YOU NOT TO WANT TO USE THE SEAT BELT BECAUSE OF HOW MUCH TROUBLE IT IS TO BE USED. *TR

DATE: SEPTEMBER 18, 2011 DRIVING SOUTH ON THE 605 FREEWAY REAR LEFT TIRE BLEW OUT THE TREAD BELT PORTION OF THE TIRE TORE OF AND CAUSED BODY AND PAINT DAMAGE TO THE REAR FENDER. I CAN PROVIDE PICTURES OF THE TIRE AND BODY DAMAGE IT CAUSED. I RECEIVED A RECALL NOTICE AND I MAILED THE DOCUMENTS REQUESTED. BF GOODRICH NOTIFIED ME THAT MY TIRES ARE OUT OF WARRANTY DUE TO AGE AND MY TIRES ARE NOT PART OF THE RECALL NOTICE. I TOLD THE PERSON ON THE PHONE THE INCIDENT IS THE SAME AS NOTED "TIRE TREAD SEPARATION" AS ON THE RECALL NOTICE. I ONLY HAD APPROXIMATELY 10,000 MILES ON THE TIRES WHEN IT HAPPENED. *TR

I OBSERVE THE VOLUNTARY RECALL ISSUES BY GOODYEAR (NHTSA 12T0030000) AND SINCE I OWN A 4 WHEEL SET OF THOSE TIRES ON MY FORD F-250 SUPER DUTY, I NOTICED THAT MY SIZE WASN'T LISTED. I HAVE HAD TROUBLE WITH MY SET OF SILENT ARMOR TIRES IN THAT THEY CAN NOT BE BALANCED AS THEY SHOULD BE AND VERY PRONOUNCED CRACKS HAVE APPEARED ON THE SIDE WALLS CLOSE TO THE TREAD LINE. I LIMIT MY SPEED TO NO MORE THAN 50MPH. MY TIRES WERE PURCHASED IN SEPTEMBER, 2009 AND IF I COULD CRAWL UNDER MY TRUCK IN SEARCH OF THE PRODUCTION DATES, I'M SURE THEY WOULD BE IN OR CLOSE TO THE LISTED PRODUCTION DATES. THE PROBLEM APPEARS TO BE WITH THE SILENT ARMOR PRODUCTION TECHNOLOGY AND SHOULD NOT BE RECALLED IN SUCH A NARROW DATE RANGE OR SIZE RANGE. PLEASE EXPAND THE RECALL TO ALL SIZES AND A BROADER PRODUCTION DATE RANGE. *TR

TIRE SEPARATED LIKE A RETREAD AND CAUSE OVER $3500 DAMAGE TO THE BED OF THE PICKUP ON THE DRIVER'S SIDE. *TR

APPROXIMATELY 1 HOUR AFTER BEING PARKED IN PARKING STALL AT MY RESIDENCE, NEIGHBORS NOTICED FIRE COMING FROM THE HOOD AND UNDERNEATH THE VEHICLE (THE FIRE ORIGINATED ON THE DRIVER'S SIDE).THEY ATTEMPTED TO PUT OUT THE FIRE AND CALLED 911. SAN JOSE FIRE DEPARTMENT RESPONDED TO THE CALL AND FINISHED PUTTING OUT THE FIRE. THE VEHICLE HAD VISIBLE BURNT WIRING, RIGHT SIDE FENDER DAMAGE FROM HEAT (INSIDE AND OUTSIDE) AND THE RIGHT DRIVER'S SIDE TIRE SUSTAINED DAMAGE DUE TO MELTING DEBRIS FALLING ON TIRE. THE FIRE DEPARTMENT TOOK A REPORT OF THE INCIDENT. AS I HAVE RELAYED THIS EVENT TO OTHERS, THEY HAVE MENTIONED THAT THIS IS PROBABLY A "RECALL FIRE" AND THAT I SHOULD REPORT THIS INCIDENT. *TR

THE REAR BRAKE LINE FAILED DUE TO CORROSION. THE FAILED BRAKE LINE ALLOWED THE BRAKE FLUID TO TOTALLY DRAIN THE RESERVOIR ON THE MASTER CYLINDER. THE RESERVOIR FOR THE REAR BRAKES IS SHARED WITH THE FRONT BRAKES SO THAT THE FRONT BRAKES WERE NO LONGER ABLE TO FUNCTION AS WELL. THE OPERATOR THEN HAS NO BRAKES AT ALL ON THE VEHICLE WITH THE EXCEPTION OF THE PARKING BRAKE. IN THE CASE OF THE FIRST FAILURE, I WAS ABLE TO USE THE MANUAL TRANSMISSION TO SLOW THE VEHICLE AND THEN SHIFT INTO REVERSE (IT HAS SYNCHROS IN REVERSE AS WELL) TO STOP THE VEHICLE. IN THE CASE OF THE SECOND FAILURE, THE VEHICLE WAS IN MY DRIVEWAY WHEN THE FAILURE OCCURRED. EVEN THOUGH THE BRAKE PEDAL WAS ONLY PUSHED ONCE, THE RESERVOIR STILL COMPLETELY DRAINED LEAVING ABSOLUTELY NO BRAKES. I FEEL THAT THIS BRAKE FAILURE MODE DOES NOT COMPLY WITH THE INTENT OF WHAT I UNDERSTAND THE LAW TO BE, THAT REQUIRES A SPLIT BRAKE SYSTEM THAT ENABLES THE OPERATOR TO STOP THE VEHICLE WHEN EITHER FRONT OR REAR BRAKES FAIL. THE CURRENT BRAKE SYSTEM DOES HAVE A SPLIT MASTER CYLINDER BUT THE COMMON RESERVOIR FEATURE PREVENTS THE SPLIT MASTER CYLINDER FROM OPERATING AS INTENDED/REQUIRED.

I WAS TRAVELING ON I-90 IN ERIE,PA AND A SPARK PLUG BLEW OUT OF THE MOTOR. I LOST ALL POWER AND WAS NEARLY HIT FROM BEHIND. THE TRUCK IS A FORD F-250 WITH A TRITAN 5.4 L MOTOR. *TR

I HAVE A 2000 FORD F250 3/4 TON 5.4 GAS 2 WHEEL DRIVE LONG BED EXTENDED CAB PICKUP. THE TRUCK SHAKES AND CUPS TIRES BADLY AT HIGHWAY SPEED IF WEIGHT IS PUT ONTO THE RIGHT FRONT WHEEL. I HAVE HEARD OF SEVERAL INCIDENTS OF THE DEATH WOBBLE ON THE F250 BUT MOST WERE 4X4 TRUCKS. I THINK THAT THIS IS DANGEROUS. MY TRUCK ONLY HAS 60K MILES ON IT. *KB

WAS PULLING MY BOAT OUT OF THE WATER AND WHEN STOPPING HEARD A LOUD BANG. STOPPED TRUCK AND SAW FLUID LEAKING ON TO THE GROUND FROM JUST FORWARD OF THE DRIVERS SIDE REAR TIRE. FOUND FLUID TO BE BRAKE FLUID. BRAKE STEEL LINE THAT RUNS DOWN THE LEFT FRAME RAIL HAD BURST NEAR FUEL TANK. THIS AREA HARD TO SEE UNLESS USING A MIRROR AND LIGHT. THE BRAKE LINE WAS VERY CORRODED AND HAD RUSTED THRU IN THE AREA THAT IS HARDEST TO SEE. REPLACED THE STEEL BRAKE LINE TO REPAIR. I AM THE ORIGINAL OWNER OF THIS TRUCK. I HAVE PICTURES AND HAVE THE OLD BRAKE LINE. *TR