2011 FORD F-250 SD Complaints

TL* THE CONTACT OWNS A 2011 FORD F-250 SD. THE CONTACT HEARD AN ABNORMAL RATTLING NOISE COMING FROM THE VEHICLE WITHOUT WARNING. THE CONTACT OBSERVED UNDER THE VEHICLE THAT THERE WAS MULTIPLE RUBBER MOUNTING PIECES THAT WERE MISSING OR DETACHED DUE TO DETERIORATION. THE VEHICLE WAS TAKEN TO THE LOCAL DEALER (BOGGUS FORD MCALLEN, 1400 E EXPY 83, MCALLEN, TX) WHERE IT WAS DIAGNOSED AND CONFIRMED THAT THE RUBBER MOUNTS FAILED AND/OR WERE MISSING, AND NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER INFORMED THE CONTACT THAT THERE WAS NO RECALL AT THE TIME AND NO ADDITIONAL ASSISTANCE WAS OFFERED. THE FAILURE MILEAGE WAS APPROXIMATELY 133,000. .. .UPDATED 10/04/17 *BF *TT

7/7/17 - 2011 FORD F250, 6.7L DIESEL ENGINE, MILEAGE 79530. (PURCHASED DECEMBER 2010). I WAS PULLING A SMALL TRAILER UP AN INCLINE (8%) ON I-64 IN WV. ON THIS PORTION OF THE INTERSTATE THERE WAS NO EMERGENCY PULL OFF SHOULDER. THE TRUCK OPERATED NORMALLY FOR THE FIRST 3 MILES ASCENDING THE HILL. DURING THE 4TH MILE, THE TRUCK BEGAN TO GRADUALLY, BUT PROGRESSIVELY LOSE POWER, GOING FROM 70 MPH DOWN TO 0. AT APPROXIMATELY 30 MPH, THE TRUCK BEGAN TO SHUTTER SLIGHTLY, AND CONTINUED TO DO SO UNTIL IT STOPPED IN THE LANE OF TRAFFIC AND STALLED. THERE WERE NO WARNING LAMPS OR CHIMES THAT WENT OFF BEFORE THE ENGINE STALLED. THIS VEHICLE IS EQUIPPED WITH A 'STOP SAFELY NOW' WARNING, ALONG WITH MANY OTHER WARNING INDICATORS ' BUT IT DIDN'T ILLUMINATE. THE TRUCK WOULD NOT RESTART. I IMMEDIATELY CALL 911 TO REPORT THAT MY VEHICLE WAS DISABLED IN THE ROADWAY. AFTER BEING STUCK IN THE LANE OF TRAFFIC FOR ABOUT 10 MINUTES, I WAS ABLE TO DRIFT THE TRUCK AND THE TRAILER BACKWARDS SAFELY, OFF OF THE ROADWAY, INTO THE DRAINAGE DITCH, AFTER A BREAK IN TRAFFIC. UPON HAVING IT TOWED TO A FORD DEALERSHIP, I WAS INFORMED THAT IT WAS GOING TO NEED A MOTOR, AND IT SOUNDED LIKE IT HAD SPUN THE BEARINGS ON ONE OF THE ENGINE RODS. THE ENGINE WOULD RESTART AT THE FORD DEALERSHIP, BUT IDLED VERY ROUGH. I CONFIRMED THAT THERE WERE IN FACT METAL SHAVINGS IN THE OIL. THE FUEL WAS NOT CHECKED FOR CONTAMINATION. THIS VEHICLE HAS BEEN MAINTAINED ACCORDING TO FORD'S RECOMMENDED SERVICE GUIDELINES. BECAUSE OF THE COST TO ME TO REPAIR ($16,000 OR MORE), I'VE ELECTED NOT TO CONTINUE WITH DIAGNOSIS (AT $120 PER HOUR) TO DETERMINE REASON FOR FAILURE. AGAIN, THERE WAS NO WARNING SYSTEMS ACTIVE AT THE TIME THE ENGINE STALLED. THIS WAS AN ORIGINAL OWNER, PERSONAL VEHICLE, AND ONLY TOWED A TRAILER ON OCCASION. I HAVE VIDEO FROM DASH CAM W/AUDIO OF THIS EVENT.

2011 FORD SUPER [XXX], 6.7L FIRE HAZARD, FUEL INJECTOR HOLD DOWN FAILURE WHILE IDLING IN YARD, SPRAYING FUEL ALL OVER PLACE, TOWED TO DEALER, RECOMMENDS REPLACING ALL HOLD DOWNS DO TO FAULTY PART. TSP ON IT.. 1600.00 NOT COVERED UNDER WARRANTY 86,000 MILES. FIRE HAZARD. GLAD I'M NOT THE ONE THAT'S GOING TO BURN IN THE SUPER [XXX] TRUCK RECOMMEND YOU HAVE FORD RECALL ALL 2011 6.7 LITERS TO REPLACE THE DEFECTIVE PARTS. SELL FORD STOCK. FIRE PROFESSOR AND ENGINEERING STUDENTS. COME ON PEOPLE REALLY!!!!!!!!!!!!!!!!!!!!!!!! INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6). *TR

FOR THE PAST 3-4 YEARS MY TRUCK HAS EXPERIENCED THE "DEATH WOBBLE." WHEN DRIVING (STRAIGHT OR IN SLIGHT TURN) APPROXIMATELY 55 MPH OR HIGHER AND HITTING A TYPICAL BUMP IN THE ROAD, MY TRUCK BEGINS A VIOLENT SHAKING THAT STOPS WHEN I REDUCE THE SPEED ENOUGH TO REGAIN CONTROL. I HAVE ATTEMPTED REPAIRS AT TWO LOCAL FORD DEALERSHIPS AS WELL AS A LOCAL REPAIR SHOP, BUT NOTHING DONE HAS CORRECTED THE ISSUE. *TR

TL* THE CONTACT OWNS A 2011 FORD F-250 SD. WHILE DRIVING, THE "PULL OVER SAFELY NOW" WARNING INDICATOR ILLUMINATED AND THE ENGINE SHUT OFF WITHOUT WARNING. THE CONTACT WAS ABLE TO MANUALLY BYPASS THE FAILURE. THE VEHICLE WAS TOWED TO THE DEALER WHERE IT WAS DIAGNOSED THAT THE EGT SENSOR WAS DEFECTIVE AND NEEDED TO BE REPLACED. THE VEHICLE WAS REPAIRED. THE MANUFACTURER WAS NOTIFIED. THE FAILURE MILEAGE WAS APPROXIMATELY 65,000.

TL* THE CONTACT OWNS A 2011 FORD F-250 SD. WHILE DRIVING VARIOUS SPEEDS OVER A BUMP IN THE ROAD, THE FRONT END OF THE VEHICLE WOBBLED VERY VIOLENTLY. THE VEHICLE WAS TAKEN TO THE DEALER ON NUMEROUS OCCASIONS FOR A DIAGNOSTIC TESTING AND REPAIR. THE CONTACT STATED THAT THE BALL JOINTS, SHOCK ABSORBERS, AND OTHER UNKNOWN COMPONENTS WERE REPLACED OR REPAIRED BY THE DEALER, BUT THE FAILURE PERSISTED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 200,000.

TL* THE CONTACT OWNS A 2011 FORD F-250 SD. WHILE DRIVING VARIOUS SPEEDS, THE VEHICLE WOBBLED UNCONTROLLABLY. THE BRAKE PEDAL HAD TO BE DEPRESSED AND THE VEHICLE HAD TO ALMOST COME TO A COMPLETE STOP TO KEEP IT FROM WOBBLING. THE DEALER CONFIRMED THAT THERE WAS A WOBBLE IN THE FRONT END OF THE VEHICLE AND THAT A WOBBLE BAR WOULD NEED TO BE PLACED ON THE VEHICLE; HOWEVER, THERE WAS NO GUARANTEE THAT THE FAILURE WOULD NOT RECUR. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 90,000. UPDATED 01/26/17*LJ UPDATED 7/12/18*JB *TR

I PURCHASED A NEW DIESEL 2011 F-250 LARIAT 4X4 CREW CAB 172' WB. I BOUGHT THE TRUCK BASED ON THE CHARTS IN A FORD BROCHURE. ACCORDING TO THE PAYLOAD CHART ON PAGE 39 OF THE BROCHURE, THE PAYLOAD FOR MY TRUCK SHOULD HAVE BEEN 2,210 LBS. ACCORDING TO THE TOWING CHART, THE PAYLOAD FOR MY TRUCK SHOULD HAVE BEEN 15% OF 15,700 LBS., WHICH IS 2,355 LBS. I DID NOT DISCOVER THE DISCREPANCY BETWEEN FORD'S PUBLISHED RATINGS AND THE ACTUAL CAPACITY OF THE TRUCK AT THE TIME OF PURCHASE BECAUSE THERE WERE NO FOOT NOTES IN THE PRINTED BROCHURE INDICATING THE PUBLISHED RATINGS WOULD NOT APPLY TO MY TRUCK AND BECAUSE OF WHERE FORD PLACED THE TIRE AND LOADING INFORMATION LABEL. ACCORDING TO THE NHTSA, FOR 'VEHICLES OTHER THAN MOTORCYCLES OR TRAILERS, THE LABEL MUST BE AFFIXED TO EITHER THE HINGE PILLAR, DOOR-LATCH POST, OR THE DOOR EDGE THAT MEETS THE DOOR-LATCH POST, NEXT TO THE DRIVER'S SEATING POSITION.' FORD PLACED THE LABEL ON THE BODY BELOW THE B PILLAR AND FACING DOWN. THE LABEL COULD NOT BE READ WHEN ENTERING THE VEHICLE AND COULD ONLY BE READ BY SITTING OR KNEELING ON THE GROUND. I DISCOVERED A JULY 30, 2014 ARTICLE IN AUTOMOTIVE NEWS THAT REVEALED STANDARD EQUIPMENT PARTS WERE REMOVED FROM SUPER DUTY TRUCKS BEGINNING WITH THE 2011 MODEL YEAR WHEN DETERMINING THE MAXIMUM PAYLOAD. THE PARTS INCLUDED, BUT WERE NOT LIMITED TO, THE SPARE TIRE, TIRE JACK, RADIO, AND CENTER CONSOLE. THE FORD BROCHURE DID NOT INDICATE THAT THE RATINGS WERE ESTABLISHED BY REMOVING STANDARD EQUIPMENT. WHEN I CONTACTED FORD ABOUT THE ISSUE, I WAS TOLD THAT THE DISCREPANCY BETWEEN THE PUBLISHED RATINGS AND MY TRUCK'S ACTUAL PAYLOAD WAS DUE TO 'OPTIONS.' FORD'S BROCHURE NEITHER FOOT NOTED THE RATINGS CHARTS NOR DISCLOSED THAT FORD HAD REMOVED STANDARD EQUIPMENT TO ESTABLISH THE RATINGS IN THE CHARTS. *TR *TR

WHEN TRAVELLING 45-50 MPH TWICE MY TRUCK HAS EXPERIENCED THE DEATH WOBBLE. NOW AT SPEEDS AT 62 MPH OR GREATER THE WHEELS SHIMMY BACK AND FORTH CAUSING THE STEERING WHEEL TO MOVE BACK AND FORTH ABOUT 4". IT GETS CRAZIER IF I HIT A BUMP. THIS MAKES FOR A SCARY RIDE. IT ONLY HAS 35K MILES ON IT. IT IS COMPLETELY STOCK

TL* THE CONTACT OWNS A 2011 FORD F-250 SD EQUIPPED WITH CONTINENTAL CONTITRAC TIRES, SIZE: LT275/65R18. WHILE DRIVING 55 MPH, A LOUD ABNORMAL NOISE WAS HEARD FROM THE REAR PASSENGER SIDE TIRE. IN ADDITION, THE CONTACT FELT THE TREAD HITTING THE VEHICLE. UPON PULLING THE VEHICLE OVER TO THE SIDE OF THE ROAD, THE CONTACT NOTICED THAT THE TREAD HAD COMPLETELY SEPARATED FROM THE TIRE. THE VEHICLE HAD A SPARE TIRE INSTALLED BY THE TOW COMPANY. THE VIN WAS UNKNOWN. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE VEHICLE AND TIRE FAILURE MILEAGE WAS APPROXIMATELY 56,000.