2012 FORD F-250 SD Complaints

DEATH RATTLE YOU HIT BUMP IN HIGHWAY AND STARTS TO SHAKE ALL OVER, LIKE THE WHEELS ARE GOING TO FLY OFF.

ON HIGHWAY AT 50 MPH WHEN REAR PASSENGER TIRE EXPLODED. TIRE FRAGMENTS TORE AND BENT FENDER WELL METAL CAUSING $2700 DAMAGE. STEEL BELTS WERE BROKEN ACROSS THE TIRE IN TWO LOCATIONS ON THE CIRCUMFERENCE. FENDER AND TIRE REPLACED. LIKELY WOULD HAVE CAUSED SEVERE BODILY INJURY OR DEATH IF A PERSON HAD BEEN STANDING NEXT TO THE TIRE. (PRIMARY REASON FOR FILING THIS REPORT) JUST PRIOR TO THE EXPLOSION, MY WIFE SENSED A VIBRATION AND STOPPED TO INSPECT TIRES. NO OBVIOUS DEFECTS WERE FOUND. AFTER PROCEEDING APPROXIMATELY 1 MILE, THE INCIDENT OCCURRED. TIRE WAS RETURNED TO BF GOODIIDGE AFTER WHICH THEY CLAIMED NO RESPONSIBILITY. PICTURES OF TIRE AND VEHICLE DAMAGE AVAILABLE

TL* THE CONTACT OWNS A 2012 FORD F-250 SD. THE CONTACT STATED THAT THE EGT 14 SENSOR FAILED TO FUNCTION PROPERLY. THE FAILURE OCCURRED TWICE. THERE WAS NO WARNING INDICATOR OF "STOP SAFELY NOW" ALONG WITH FIVE CHIMES SOUNDING AS INDICATED IN THE OWNER'S MANUAL. WHILE DRIVING APPROXIMATELY 70 MPH, THE VEHICLE STALLED. THE VEHICLE WAS TOWED TO THE DEALER WHO REPLACED THE EGT SENSOR. IN ADDITION, THE VEHICLE STALLED WHILE ON AN OFF RAMP EXITING THE HIGHWAY WITHOUT WARNING. THE DIESEL EXHAUST WARNING INDICATOR STATED THAT THE FLUID WAS LOW; HOWEVER, WHEN THE CONTACT CHECKED, IT WAS FULL. THE VEHICLE WAS TOWED TO THE DEALER AND ALL THE SENSORS WERE REPLACED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURES. THE FAILURE MILEAGE WAS NOT AVAILABLE.

AT SPEEDS BETWEEN 40-60 MPH THE FRONT OF THE TRUCK SHAKES/VIBRATES VIOLENTLY. THE TRUCK BECOMES DANGEROUS AND IS NO LONGER STEERABLE UNLESS YOU STOP COMPLETELY.

RADIATOR LEAK FROM DRIVERS SIDE LOWER PORTION. SAME AS PREVIOUS MODEL YEAR ISSUES. FORD CURRENTLY WARRANTIES EARLIER PRODUCTION, BUT WILL NOT EXTEND TO 2011 AND UP. TRUCK HAS ONLY 56000 MILES ON IT. LEAK OCCURS AFTER VEHICLE HAS REACHED OPERATING TEMPERATURE AND IS PARKED AND/OR TURNED OFF. INSPECTION CONDUCTED BY FORD DISCOVERED TANK CRIMPING HAS FAILED AND TRUCK NEEDS A NEW RADIATOR. I AM NOT THE ONLY ONE WITH THIS ISSUE, BUT STILL NOTHING IS BEING DONE TO CORRECT IT.

ON THE FIRST DAY OF AN EXTENDED TRIP WITH OUR TRUCK AND RV, WE ARRIVED AT CAMP TO DISCOVER A MAJOR COOLANT LEAK. THE TRUCK DID NOT GIVE US ANY WARNING MESSAGES THAT ANYTHING WAS WRONG. WE HAD THE TRUCK TOWED TO THE CLOSEST FORD DEALER. THANK GOODNESS THIS PROBLEM HAPPENED IN CAMP, RATHER THAN ON AN ISOLATED ROAD WHERE WE COULD HAVE BEEN 100+ MILES AWAY FROM ANY SORT OF SERVICE. IT TURNED OUT THAT BOTH THE WATER PUMP AND RADIATOR HAD FAILED, WITH UNDER 29,000 MILES ON THE TRUCK. THE WATER PUMP WAS COVERED UNDER WARRANTY, BUT THE RADIATOR WAS NOT. THE FORD SERVICE MANAGER ADVISED US THAT THEY HAD ALREADY REPLACED SEVERAL RADIATORS THIS YEAR, WITH LEAKS IN THE SAME PLACE (DRIVER'S SIDE LOWER CORNER). WE ALSO DID SOME CHECKING ON THE INTERNET AND LEARNED THAT THIS FAILURE SEEMS FAIRLY COMMON. THE RADIATOR SHOULD NOT HAVE FAILED IN SUCH A SHORT AMOUNT OF TIME, WITH LIMITED MILES ON OUR TRUCK.

TL* THE CONTACT OWNS A 2012 FORD F-250 SD. THE CONTACT STATED THAT THE ACCELERATOR PEDAL FAILED TO RESPOND WHILE THE VEHICLE WAS IN REVERSE. PRIOR TO THE FAILURE, AN UNKNOWN SENSOR WAS REPLACED BY THE DEALER. THE GEAR WAS SHIFTED INTO DRIVE AND THE VEHICLE WAS DRIVEN TO THE DRIVEWAY. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. IN ADDITION, COOLANT LEAKED FROM THE RESERVOIR INTO THE VALLEY OF THE ENGINE AND THE FOUR POWER DOOR LOCKS WOULD INTERMITTENTLY UNLOCK WHEN DRIVING. ON A SEPARATE OCCASION, IN EXTREMELY COLD WEATHER, THE ENGINE FAILED TO START. THE VEHICLE FAILED TO RESTART AND WAS TOWED TO THE DEALER. THE CONTACT WAS UNCERTAIN OF THE REPAIR THAT WAS PERFORMED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURES. THE APPROXIMATE FAILURE MILEAGE WAS 20,000.

BRAKES ARE SPONGY HAVE BLOWN THROUGH STOP LIGHT TWICE WITHOUT TIME TO PUMP BRAKES. DEALER REPLACED FRONT CALIPERS RESURFACED ROTORS AND REPLACED PADS AT MY EXPENSE NO IMPROVEMENT. PEDAL TRAVELS 1/2 TO 3/4 TO FLOOR ON INITIAL BRAKING WITHOUT SIGNIFICANTLY SLOWING VEHICLE, BETTER EACH TIME YOU PUMP BRAKES. WHILE TOWING TRAILER GAIN HAS TO BE ON FULL SO TRAILER BRAKES CAN HELP STOP VEHICLE, VEHICLE BRAKES ARE INSUFFICIENT. TOOK TRUCK BACK TO FORD OF KIRKLAND AFTER SPENDING $1000 AND WAS TOLD BRAKING IS NORMAL, DROVE A FRIENDS 2011 F250 AND BRAKES ARE MUCH BETTER. THE LACK OF RESPONSE ON THE PEDAL HAS CREATED MORE THAN 1 NEAR ACCIDENT AND SHOULD BE ADDRESSED BY FORD FULLY AS A SAFETY ISSUE. THE LACK OF BRAKE PEDAL RESPONSE IS CONSISTENT REGARDLESS OF TYPE OF DRIVING OR SPEED AND HAS BEEN ON GOING SINCE ABOUT 36,000 MILES. TRUCK CURRENTLY HAS 48,000 MILES.

WINDSHIELD WIPERS WERE LOCKED ON WHEN THE VEHICLE WAS ON. INDEPENDENT OF WEATHER. NO WAY TO TURN OFF UNTIL ELECTRONIC SWITCHES THAT CONTROL THE WIPERS, BLINKERS, AND HIGH BEAMS WERE REPLACED. PROBLEM STARTED ON THE HIGHWAY IN MOTION. RT 89 N VERMONT. CONTINUED UNTILLED REPAIRED. PART NUMBER WAS SW-6874.

SEVERAL TIMES, AFTER HITTING A SMALL BUMP IN THE ROAD, GENERALLY AT SPEEDS OVER 50 MPH, I HAVE EXPERIENCED AN EXTREME "SHIMMY" IN THE FRONT END OF THE VEHICLE CAUSING LIMITED CONTROL. I TOOK THE VEHICLE TO THE DEALER FOR REPAIRS, HOWEVER, THEY COULD NOT DETERMINE THE CAUSE AND AFTER REPLACING SEVERAL PARTS THEY WERE STILL NOT ABLE TO RESOLVE THE PROBLEM. I TOOK THE VEHICLE TO A PRIVATE REPAIR SHOP AND HAD SEVERAL OTHER PARTS REPLACED AND STILL NO RESOLUTION TO THE PROBLEM. BALANCING AND TIRE PRESSURE HAVE BEEN MAINTAINED BY THE DEALER AS WELL AS OTHER CERTIFIED MECHANICS. DUE TO THE LOSS OF CONTROL WHEN THIS WOBBLE OCCURS, I AM AFRAID TO DRIVE THE VEHICLE