2006 FORD F-250 SD Complaints

WHILE DRIVING DOWN A FAIRLY SMOOTH HIGHWAY AT 55 MPH. MY 2006 FORD F250 SD POWERSTROKE STARTED SHAKING, AND THE STEERING WHEEL STARTING MOVING BACK AND FORTH RAPIDLY. I THOUGHT IT WAS A LOOSE WHEEL OR A FLAT, BUT IT WAS NOT. I HAD TO SLOW DOWN TO AROUND 45 MPH AND IT STOPPED. AFTER DOING SOME INVESTIGATING ON THE INTERNET I FOUND THAT THIS IS A VERY COMMON THING FOR THIS MODEL PICK-UP, AND THAT NOTHING IS BEING DONE TO CORRECT IT BY FORD. THIS HAS HAPPENED TO ME TWICE NOW, AND IT IS VERY SCARY. I HOPE THAT IT DOES NOT HAVE TO TAKE SOMEONE HAVING A FATAL ACCIDENT FOR FORD TO DO SOMETHING ABOUT THIS. *JB

WHEN HITTING AN EXPANSION JOINT ON THE HIGHWAY THE FRONT END WILL SHAKE VIOLENTLY AND THE TRUCK WILL JUMP UNCONTROLLABLY INTO OTHER LANE. VERY UNSAFE. *TR

MY 2006 FORD F250 HIT A POT HOLD IN I-15 NEAR KAYSVILLE, SOUTHBOUND ON THURS. OCTOBER 4, 2007. I WAS TRAVELING AT 65 MPH IN THE MIDDLE LANE WHEN IT STARTED SHAKING VIOLENTLY AND ALL I HEARD WAS CAR TIRES SCREECHING. I THOUGHT I WAS GOING TO DIE. I WAS ABLE TO PULL THE TRUCK TO THE SHOULDER AND STOP. THIS HAS NOT BEEN THE FIRST TIME. THIS WAS THE EIGHTH TIME THIS HAS HAPPENED. THEN ABOUT TEN MINUTES LATER, ALMOST TO WORK, IT DID IT AGAIN ON I-80 WESTBOUND ALMOST TO 5600 WEST. I HAVE TAKEN IT IN TO TWO DEALERS WHO ONE, WILLEY FORD IN BOUNTIFUL, SAID THERE WAS SOME LOOSE BOLTS. THE OTHER DEALER ED KENLEY FORD IN LAYTON, SAID THERE WAS SOME BROKEN PARTS ON THE FRONT END. IT HAS SHOOK A LITTLE BUT NOW IS WORSE THAN EVER. I AM AFRAID TO DRIVE THIS VEHICLE ANY MORE AS IT WILL EITHER KILL ME OR ANOTHER DRIVER. I SUSTAINED A HEADACHE AND PULLED MUSCLE IN MY NECK AND A SORE BACK FROM YESTERDAYS INCIDENT. FORD NEEDS TO PULL THESE VEHICLES AND GET THEM REPAIRED OR REPLACED. *TR

MY 2006, 5.3 GAS ENGINE, 4 WHEEL DRIVE, F250 SUPER DUTY HAS HAD EXCESSIVE WHEEL HOP, BOUNCING, VIBRATION, AND SOMETIMES, VIOLENT SHAKING OF THE WHOLE FRONT OF THE TRUCK, WHEN GOING OVER EXPANSION JOINTS, BUMPS AND ROAD DEFECTS SINCE IT WAS NEARLY NEW. THIS RESULTS IN THE STEERING WHEEL SHAKING AND MAKES THE TRUCK HARD TO CONTROL. WHEN NEW WITH 300 MILES ON IT IN FEB. 2007, I DROVE IT FROM MA TO FL AND NOTICED THAT SOMETIMES IT SHUDDERED, WHEN GOING OVER A BUMP AT SPEEDS OVER 50. THAT IS, IT DID NOT JUST GIVE ONE HARD JOLT, BUT BOUNCED A FEW TIMES. THE BOUNCING GOT WORSE AS MILEAGE ON THE VEHICLE WENT UP. SOMETIMES THE TRUCK WOULD MOVE LATERALLY AFTER A HARD BUMP, THAT IS, MOVE TO THE EDGE OF THE TRAVELED LANE, OR PARTIALLY INTO ONE OF THE ADJACENT LANES. NOW, WITHIN THE LAST 2 WEEKS, AT ITS EXTREME OF VIBRATIONS AND BOUNCING, THE VIOLENT SHAKING HAS HAPPENED TO ME TWICE, BOTH TIMES WHEN TRAVELING ON A HIGHWAY AT 60-68 MPH, AFTER GOING OVER AN EXPANSION JOINT COMING OFF OR GOING ON TO A BRIDGE. FIRST TIME, ON SEPT 16, 2007, WITH ABOUT 9000 MILES ON THE F250, SHAKING LASTED ABOUT 5 SECONDS, ON I64 IN VIRGINIA BEACH, VA, AND THEN, ON SEPT. 28, 2007, FOR ABOUT 10 SECONDS, OR ABOUT 1000', ON THE NEW JERSEY TURNPIKE. DURING THESE LAST 2 INCIDENTS, I THOUGHT THAT I MIGHT EASILY HAVE LOST CONTROL OF THE VEHICLE AND HAVE EITHER INJURED SOMEONE ELSE OR MYSELF. BOTH OF THE SERIOUS VIOLENT SHAKING EPISODES HAPPENED ON A DRY INTERSTATE HIGHWAY IN DECENT CONDITION WITH OTHER TRAFFIC TRAVELING AT THE SAME SPEED AND MANY, MANY OTHER VEHICLES GOING OVER THE SAME BUMPS. I HAVE CHECKED THE TIRE PRESSURE AND ALL THE TIRES READ ABOUT 50#, THE SAME AS WHEN I GOT THE TRUCK ON JAN. 31, 2007. THERE ARE NO OBVIOUS DEFECTS IN THE TIRES. NOW, IT SHUDDERS WHEN GOING OVER VERY MINOR BUMPS, SOMETIMES EVEN AT BELOW 45 MPH. I'VE MADE IT BACK FROM MY TRIP AND THERE ARE ABOUT 9500 MILES ON THE TRUCK AND I AM TAKING IT TO THE DEALER THIS WEEK. THIS PROBLEM COULD RESULT IN THE LOSS OF LIFE. *JB

HIGHWAY DRIVING CONDITIONS AT 65 MPH , VIOLENT SHAKING OF THE TRUCK OCCURRED RESULTING IN DANGEROUS LOSS OF CONTROL OF THE VEHICLE. VEHICLE CAME TO A COMPLETE STOP TO END THE SHAKING. VEHICLE WAS TAKEN TO A FORD DEALER WHERE A STEERING DAMPER KIT WAS INSTALLED. *TR

I OWN A 2006 F250 DIESEL TRUCK THAT SHAKES VIOLENTLY WHEN YOU HIT EVEN THE SMALLEST OF POTHOLES. IT SHAKES SO VIOLENTLY THAT YOU HAVE TO COME TO A COMPLETE STOP, REGAIN CONTROL, AND THEN RESUME DRIVING. THIS IS ESPECIALLY HAZARDOUS ON THE SMALL COUNTY ROADS WE LIVE ON, AND WHEN YOU HAVE TO COME TO A COMPLETE STOP ON THE FREEWAY. WE HAVE TRIED TO GET IT FIXED AT THE DEALERSHIP, WHERE THEY ASSURE US THAT NOTHING IS WRONG WITH THIS DANGEROUS DEATH TRAP. I REFUSE TO ALLOW MY HUSBAND AND MY SON GET INTO A VEHICLE THAT WILL SHAKE VIOLENTLY OUT OF CONTROL INTO ONCOMING TRAFFIC, INTO A DITCH, OR OFF A BRIDGE. I AM ASHAMED THAT FORD WOULD BE AWARE OF THIS ISSUE, AND NOT RECALL THIS PROBLEM VEHICLE AS THERE ARE MANY OTHERS OUT THERE WITH THE SAME PROBLEM. I AM FURIOUS THAT I SPENT $48,000 ON A TRUCK THAT HAS 26,000 MILES ON IT AND HAS BEEN IN THE SHOP 3 TIMES TO HAVE THE SAME PROBLEM FIXED, SO IT IS COMPLETELY USELESS TO ME, NOT TO MENTION A DANGER TO MY FAMILY'S WELL BEING. WHAT IS IT GOING TO TAKE FOR FORD TO ADMIT THEIR TRUCKS ARE A HAZARD? HOW MANY PEOPLE ARE GOING TO HAVE TO DIE OR BE SEVERELY INJURED BEFORE THEY ADDRESS THIS PRESSING ISSUE??? *TR

2006 FORD F 250 SUPER DUTY FRONT END BOUNCES DANGEROUSLY. AUGUST 2007 THE TRUCK DID THIS 2 TIMES WHILE TRAVELING ON I25 IN NEW MEXICO. BETWEEN 9/21/07 AND 9/23/07 THIS HAPPENED 9 TIMES WHILE TRAVELING. THE TRUCK BOUNCES OUT OF CONTROL AND MOVES ACROSS TRAFFIC LANES. ENDANGERING EVERYONE'S LIVES TRAVELING ON THE ROAD. I FOUND OVER 138 CASES OF THIS REPORTED TO FORD AND THEIR RESPONSE IS TO BILL THE CUSTOMER FOR A REPAIR THAT HAS NOT WORKED IN ALMOST ALL OF THE REPAIRS SOME PEOPLE HAVE TAKEN THEIR VEHICLES TO FORD SEVERAL TIMES AFTER THE DEALER MADE AND THEN CHARGED THEM FOR THE TSB REPAIR. FORD IS ACCEPTING NO RESPONSIBILITY FOR THIS EXTREMELY DANGEROUS SITUATION. THESE VEHICLES 2005 ON ARE UNSAFE TO DRIVE ON THE ROAD. *TR

FORD F-250 WITH NO BRAKE LIGHT OR REAR TURN SIGNALS. CUSTOMER STATES THAT THIS IS A SAFETY DEFECT. HE STATED THAT THE DEALER SAID THEY WOULD BE ABLE TO LOOK AT IT WITHIN 7 DAYS. CONSUMER BELIEVES THAT IS UNACCEPTABLE. *KB

FRONT END BOUNCES DANGEROUSLY WHEN DRIVING OVER UNEVEN ROAD OR POTHOLES. FIRST PROBLEM OCCURRED AT 1100 MILES ON 9-15-06 AND SERVICE DEPT COULD FIND ANYTHING WRONG. HAPPENED AGAIN ON THE SAME MONTH STILL COULD NOT FIND ANYTHING. ON 10-23-06 TOOK HEAD MECHANIC FROM SERVICE DEPT WITH ME ON A TEST DRIVE AND THE PROBLEM HAPPENED 3 TIMES MECHANIC COULD NOT PIN POINT PROBLEM. ON 12-11-06 THEY LOOSENED AND RETORQUED ALL FASTENERS STILL NOT FIXED. THEY HAVE REPLACED DAMPENER AND STEERING SHOCK STILL NO FIX IT. TRUCK BOUNCES DANGEROUSLY AND GOES RIGHT OR LEFT COULD CAUSE MAJOR ACCIDENT. JUST PICKED UP TRUCK AGAIN FROM DEALERSHIP THEY RETORQUED EVERYTHING AGAIN STILL NOT FIXED. *JB

2006 F250 FX4 6.0 FRONT END STARTS TO SHACK WHEN HITTING A BUMP TRUCK IS UNCONTROLLABLE TIL SLOWING DOWN TO ABOUT 30MPH. *TR