2008 FORD F-250 SD Complaints

WE PURCHASED THIS 2008 FORD F-250 SUPER DUTY NEW AT THE FORD STORE IN SAN LEANDRO, CA ON JULY 21, 2007 AND CONTINUE TO BE THE ORIGINAL OWNERS. THIS VEHICLE IS EQUIPPED WITH A 6.4 TURBO-DIESEL ENGINE. THIS VEHICLE IS SUBJECT TO TSB 07-26-2 (WIRING HARNESS DEFECT ON HPFP) ISSUED AUGUST 2007. ON THE MORNING OF MARCH 27, 2015, WHILE ACCELERATING ONTO A FREEWAY AND AT AN APPROXIMATE SPEED OF 50 MPH, THE ENGINE SHUT DOWN WITHOUT ANY WARNING. I LOST ALL ACCELERATION AND THE ENGINE DIED. BRAKING AND STEERING WERE ALSO DIMINISHED. I GOT LUCKY AND WAS ABLE TO AVOID A COLLISION AND COAST TO THE SIDE OF THE ROAD WHERE THE VEHICLE WOULD NOT RESTART. THE VEHICLE WAS TOWED TO A LOCAL REPAIR SHOP (BUD ADAMS - CASTRO VALLEY, CA; BAR#:228593 CAL#:66801). DIAGNOSIS REVEALED A SHORT IN THE WIRING OF THE HIGH PRESSURE FUEL PUMP GASKET WIRING HARNESS (THE SUBJECT OF TSB 07-26-2 WHEREIN FORD RECOGNIZED ON OR ABOUT AUGUST OF 2007 A PROBLEM WITH UNPROTECTED WIRING WITHIN THE HPFP WIRING HARNESS). REPAIRS WERE EXTREMELY COSTLY ($3,791.89 REDUCED TO $2,591.89) BUT MORE IMPORTANTLY THIS INSTANTANEOUS FAILURE WITHOUT WARNING IS GOING TO CAUSE AN ACCIDENT, INJURY OR DEATH; IT IS ONLY A MATTER OF TIME. I GOT LUCKY. I SEE OTHER COMPLAINANTS WHO HAD HOURS STUCK IN THE DESERT, SOMEONE WITH A LOAD OF CATTLE STUCK WITHOUT WARNING, THE LIST GOES ON. IN EACH REPORTED INSTANCE THE OPERATOR DESCRIBED AN IMMEDIATE LOSS OF POWER PLANT WITH NO WARNING. I URGE THE NTSB TO INVESTIGATE THESE UNPLANNED SHUT DOWNS OF THIS VEHICLE'S POWER PLANT. UNDER CERTAIN CIRCUMSTANCES THIS MAY LEAD TO LOSS OF CONTROL OF THE VEHICLE, COLLISION, INJURY AND POSSIBLY DEATH. FORD HAS KNOWN ABOUT THIS ISSUE SINCE AUGUST OF 2007 YET HAS NOT ISSUED A RECALL. SOME MAY SAY THIS IS DUE TO THE LARGE COSTS INVOLVED TO REMOVE AND REPLACE THE HPFP GASKET AND WIRING HARNESS (IN PART INVOLVING THE REMOVAL OF THE VEHICLE'S CAB). *TR

WAS TOLD BY DEALER, REAR CALIPER WAS DRAGGING, I REPLACED REAR BRAKES AND IN THE PROCESS NOTICED BOTH BACK CALIPERS WERE DEFECTIVE AT 62000 MILES. ONE PISTON ON ONE SIDE WAS ATTACHED TO THE PAD AND CRACKED IN HALF. THE OTHER SIDE, BOTH PISTONS WERE BROKEN. AT SUCH A SHORT MILEAGE INTERVAL, CALIPERS SHOULD NOT BE DEFECTIVE AND DRAGGING ON THE ROTORS. *TR

WHILE DRIVING MY 08 FORD F250 SD, I EXPERIENCE SEVERE SHIMMY GOING OVER A BUMP IN THE ROAD OR SMALL DIP. MORE NOTICEABLE WHEN GOING ABOUT 45 AND I HIT A BUMP AND THE WHEEL JERKS AND THROWS THE TRUCK WHAT FEELS LIKE FEET. I HAVE NOT REPLACED ANY PARTS YET NOR HAVE I SPOKEN WITH THE DEALER. THE FIRST I EVER KNEW THERE WAS A PROBLEM NOTED BY FORD WAS WHEN I RECEIVED AN ALERT ON FLMOWNER.COM AND IT STATED FIELD SERVICE ACTION NUMBER: 09L02 FSA TITLE: CUSTOMER MAINTENANCE REMINDER VEHICLE SHIMMY AND TIRE INFLATION PRESSURE I ALWAYS MAINTAIN PROPER TIRE PRESSURE AND HAVE THEM BALANCED AND ROTATED ON A REGULAR BASIS THROUGH DISCOUNT TIRES (WHERE I BOUGHT NEW TIRES IN 2011). I DON'T HAVE A LIFT AND HAVEN'T ALTERED ANY OF THE STOCK SUSPENSION PARTS. MILEAGE AND TIME FRAME ARE AN APPROX AS I WASN'T AWARE OF THIS SERVICE ISSUE PRIOR TO THIS WEEK. THOSE ARE THE APPROXIMATES TO WHEN I MOVED TO CO.

TL* THE CONTACT OWNS A 2008 FORD F-250 SD. THE CONTACT STATED THAT THERE WAS WATER LEAKING INTO THE REAR OF THE VEHICLE. AS A RESULT, MOLD WAS BUILDING UP ON THE REAR SEATS AND SEAT BELTS. THE CONTACT ALSO STATED THAT WATER WAS ENTERING THROUGH THE CABIN AND HE WAS CONCERNED THAT IT MIGHT POTENTIALLY LEAK THROUGH THE MOON ROOF. THE CONTACT MENTIONED THAT THE FAILURE CAUSED A STRONG MILDEW ODOR IN THE VEHICLE. THE VEHICLE WAS TAKEN TO THE DEALER ON MORE THAN TWO OCCASIONS WHERE THE FAILURE WAS UNDETERMINED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 5.

3/13 I BOUGHT A SET OF FEDERAL COURAGIA MT 35X12.50X20 TIRES AND 10 MONTHS LATER THE STEEL BELTS SEPARATED CAUSING TIRE FAILURE. 2/14 I BOUGHT ANOTHER SET OF THE SAME TIRES AND THEY SEPARATED AFTER 8 MONTHS. DOT4113 IS THE SERIAL NUMBER OF THE SECOND SET OF TIRES. I DO NOT HAVE THE SERIAL NUMBER FOR THE FIRST SET. I WOULD NOT RECOMMEND THESE TIRES TO ANYONE AND WHAT DO I HAVE TO DO TO GET COMPENSATED BECAUSE FEDERAL WILL NOT GET BACK IN TOUCH WITH ME. *TR

TL* THE CONTACT OWNS A 2008 FORD F-250 SD. WHILE DRIVING 65 MPH, THE STEERING FAILED WITHOUT WARNING. THE STEERING WHEEL WAS CAPABLE OF MOVING, BUT FAILED TO DIRECT THE VEHICLE. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHERE THE TECHNICIAN STATED THAT THE MOUNT BOLTS WERE FRACTURED. THE BOLTS WERE REPLACED BY THE TECHNICIAN. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 132,000.

1. VEHICLE (FORD 250) NORTHBOUND ON I-5, TOWING AN EMPTY 16-FOOT TRAILER 2. CATASTROPHIC TIRE DETREAD OF LEFT REAR TRUCK TIRE (BFGOODRICH COMMERCIAL T/A LT 265/70R17 LRE M+S). 3. ALL TIRES TO BE REPLACED AND BODY SHOP WORK TO REPAIR VEHICLE DAMAGE. *TR

STEERING ON VEHICLE BECAME INCREASINGLY DIFFICULT. THE POWER STEERING PUMP LOST HALF OF THE FLUID. REPLACED THE POWER STEERING PUMP. SIXTY DAYS LATER THE STEERING GEAR BOX BOUND UP AND WOULD NOT ALLOW THE WHEELS TO BE TURNED.THE STEERING GEAR BOX WAS REPLACED. *TR

TL* THE CONTACT OWNS A 2008 FORD F-250 SUPER DUTY. WHILE DRIVING 65 MPH, THE STEERING FAILED AS A LOUD ABNORMAL POP SOUND EMITTED FROM THE ENGINE. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE ISSUE. THE APPROXIMATE FAILURE MILEAGE WAS 130,000. THE VIN WAS UNAVAILABLE. UPDATED 12/2/14*CN THE CONSUMER STATED THE BOLTS HOLDING THE STEERING BOX ON THE FRAME SHEARED OFF. UPDATED 01/08/15

2008 FORD F 250 SUPER DUTY DIESEL 6.4 ENGINE - ENGINE QUIT RUNNING WITH NO WARNING, WOULD NOT RESTART. WAS IN THE MIDDLE OF A LONG BRIDGE OVER THE MISSISSIPPI RIVER. THIS WAS A MAJOR INCONVENIENCE. HAD TO BE TOWED TO DEALER. TSB 07-26-2 WAS PERFORMED TO FIX THE KNOWN PROBLEM OF AN UNPROTECTED WIRE IN THE HIGH PRESSURE FUEL PUMP GASKET CHAFFING THROUGH. THIS WAS AN EXPENSIVE REPAIR SINCE THE CAB HAD TO BE REMOVED. A REVISED GASKET WITH PROTECTED WIRE WAS INSTALLED. LUCKILY I WAS NOT TOWING OUR 5TH WHEEL AT THE TIME. THIS IS A SERIOUS SAFETY RISK. FORD SHOULD RECALL AND COVER THE EXPENSE TO REPAIR AS THIS WAS A KNOWN DESIGN FLAW. *TR