2000 FORD F-250 SD Complaints

TL*THE CONTACT OWNS A 2000 FORD F-250 SD. WHILE DRIVING 10 MPH, THE CONTACT SMELLED BURNING WIRES IN THE VEHICLE AND NOTICED SMOKE COMING FROM THE HOOD. HE PULLED THE VEHICLE OVER AND OPENED THE HOOD. THE SMOKE CEASED, BUT THERE WAS A MELTED BLACK WIRE UNDER THE MASTER CYLINDER, WHICH HE BELIEVES CAUSED THE SMOKE. THE CONTACT DROVE BACK HOME, LOOKED UNDER THE HOOD AGAIN, AND NOTICED THAT IT WAS THE BRAKE PRESSURE SWITCH. THROUGH RESEARCH, HE FOUND THAT THERE WAS A RECALL, BUT IT DID NOT INCLUDE DIESEL ENGINES. THE DEALER WAS UNABLE TO ASSIST. THE CURRENT AND FAILURE MILEAGES WERE 160,000.

THE BLOWING OUT OF SPARK PLUG ON 2000 F-250. I WAS LEAVING WALMART PARKING LOT WHEN I HEARD A LOUD NOISE COMING FROM THE MOTOR, I STOP OPENED THE HOOD AND SAW THE SPARK PLUG LAYING ON TOP OF THE MOTOR. *TR

LAST YEAR ABOUT SEPT 08...MY 2000 F-250 10 CYLINDER P-UP STARTED VERY ROUGH-LIKE. IT WOULD NOT DO 50 MPH ANYMORE AS OF THAT SAME DATE. I TOOK IT TO GOOD-YEAR AND TO TWO OTHER GARAGES FOR ESTIMATES AS TO WHAT WENT WRONG. THE 10TH VALVE HAD STUCK. I TOOK IT TO THE DEALER AND THEY CHARGED ME 4,000 DOLLARS TO DO A VALVE JOB. THE TRUCK ONLY HAD 49K MILES ON IT. THE ENTIRE REAR OF THE ENGINE REQUIRED ALL NEW PLUGS AND WIRES. *TR

I WAS DRIVING MY FORD F250 WITH THE 5.4 TRITON V8 GAS ENGINE DOWN THE ROAD WHEN IT SOUNDED AS IF THE ENGINE HAD BLOWN. UPON INVESTIGATION AT A LOCAL REPAIR SHOP IT WAS DETERMINED THE LEFT REAR SPARK PLUG HAD BLOWN OUT OF THE CYLINDER HEAD. THE COST FOR THE REPAIR WAS QUOTED BETWEEN $300 TO $3000 PENDING ON HOW BAD THE DAMAGE WAS TO THE SPARK PLUG THREADS. IT IS CURRENTLY PARKED UNTIL THE REPAIR CAN BE MADE. *TR

I OWN A 2000 FORD F-250 POWERSTROKE 7.3 LITER TRUCK THAT WAS RECALLED FOR A CAMSHAFT POSITION SENSOR THAT FAILS INTERMITTENTLY. IT WILL LEAVE THE TRUCK NOT RUNNING, AND CAN RESULT IN NOT HAVING POWERSTEERING OR BRAKES. I HAD THE SENSOR REPLACED AND MY BIGGEST COMPLAINT IS THAT IT MADE MY TRUCK RUN WORSE. IT NOW HAS A MISFIRE THAT IS DIRECTLY ATTRIBUTED TO THE 'NEW' IMPROVED SENSOR. I AM NOT PLEASED AND WOULD LIKE SOME ACTION. *TR

OWNER OF A 2000 FORD F250 WANTS TO BE REIMBURSED FOR REPLACING THE CAMSHAFT POSITION SENSOR UNDER RECALL 07S57. *NJ THE CONSUMER STATED HE HAD TO REPLACE THE CAMSHAFT POSITION SENSOR TWICE. *JB

TL*THE CONTACT OWNS A 2000 FORD F-250 SUPERDUTY. WHILE DRIVING 40 MPH, THE ENGINE SHUT OFF AND THE VEHICLE CONTINUED TO ROLL. THE DRIVER ATTEMPTED TO DEPRESS THE BRAKE PEDAL TO STOP THE VEHICLE, BUT IT WOULD NOT STOP. THE VEHICLE FINALLY ROLLED TO A STOP IN THE GRASS WITHOUT A CRASH. THE VEHICLE WAS VERY HOT AND FLAMES WERE NOTICED COMING FROM THE FRONT OF THE VEHICLE, DIRECTLY UNDER THE ENGINE. THE FIRE DEPARTMENT ARRIVED AND EXTINGUISHED THE FIRE. THE VEHICLE WAS BURNED FROM THE TIRES TO THE WINDSHIELD AND DASHBOARD. THE MANUFACTURER STATED THAT THE VEHICLE WAS NOT INCLUDED IN NHTSA CAMPAIGN ID NUMBER 07V553000 (ENGINE AND ENGINE COOLING:ENGINE:DIESEL). THE CURRENT AND FAILURE MILEAGES WERE APPROXIMATELY 160,000. UPDATED 03/18/09. *LJ UPDATED 03/18/09.*JB

WHILE DRIVING 65 MPH ON THE FREEWAY, THE SPARK PLUG BLEW OUT OF THE ENGINE. NOW I AM LOOKING FOR A WAY TO REPAIR THIS. THERE IS NO WAY TO PUT AN NEW SPARK PLUG IN THE VEHICLE. I RESEARCHED THIS PROBLEM ONLINE AND SEEMS TO BE A BIG PROBLEM WITH FORD VEHICLES. *TR

TL*THE CONTACT OWNS A 2000 FORD F-250 SD. THE CONTACT STATED THAT THE VEHICLE WAS LOSING BRAKE FUEL, WHICH WAS LEAKING FROM THE MASTER CYLINDER PUSH ROD RETAINER CLIP. THE FAILURE OCCURS WHEN THE VEHICLE IS IN MOTION OR PARKED. THE DEALER STATED THAT THEY WOULD NOT REPAIR THE FAILURE FOR FREE BECAUSE THE VEHICLE WAS NOT INCLUDED IN A RECALL. THE FAILURE MILEAGE WAS 83,000.

FORD 5.4L SPARK PLUGS. I JUST EXPERIENCED MY THIRD BLOWOUT. LUCKILY, I WAS CLOSE TO HOME AND DID UNPLUG THE FUEL INJECTOR. SOMEONE LESS KNOWLEDGEABLE MAY HAVE DRIVEN THEIR VEHICLE AND WITH UNBURNED GASOLINE PUMPING ONTO A HOT ENGINE, WITH THE BLOWNOUT SPARK PLUG NEAR BY, THUS CAUSING A FIRE, OR WORSE AN EXPLOSION. IT IS MY RECOMMENDATION THAT FORD BE REQUIRED TO REPLACE THE CYLINDER HEADS ON THE DEFECTIVE VEHICLES, AT THEIR EXPENSE, WITH THEIR NEWLY REDESIGNED CYLINDER HEADS. IF THE CYLINDER HEADS WERE NOT DEFECTIVE, THEY WOULD NOT HAVE REDESIGNED THEM!!! DOES SOMEONE NEED TO DIE IN A SERIOUS AUTOMOBILE FIRE, BEFORE THEY ARE FORCED TO RECTIFY THEIR PROBLEM? IF THEY CAN ASK THE FEDERAL GOVERNMENT TO BAIL THEM OUT, THEY CAN STEP UP AND TAKE CARE OF THE MESS THEY HAVE CREATED. *TR