2008 FORD F-350 Complaints

TL* THE CONTACT OWNS A 2008 FORD F-350. THE CONTACT STATED THAT WHILE DRIVING APPROXIMATELY 70 MPH, THE REAR PASSENGER SIDE TIRE BLEW OUT. THE CONTACT WAS INFORMED BY THE ROAD SIDE ASSISTANCE PERSONNEL THAT THE RIM WAS FRACTURED AND HAD CAUSED THE BLOW OUT. THE VEHICLE WAS TAKEN TO A LOCAL MECHANIC FOR THE REPLACEMENT OF THE RIM. AFTER THE REPAIR, THE CONTACT NOTICED THE FRONT PASSENGER SIDE RIM WAS FRACTURED AS WELL. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE VEHICLE WAS NOT REPAIRED. THE APPROXIMATE FAILURE MILEAGE WAS 120,000. *TR

TL* THE CONTACT OWNS A 2008 FORD F-350 SD. THE CONTACT STATED THAT AFTER SHIFTING INTO GEAR, THE VEHICLE ACCELERATED TO APPROXIMATELY 30 MPH. THE CONTACT WAS UNABLE TO CONTROL THE MALFUNCTION AND CRASHED INTO SEVERAL TREES. THE CONTACT DID NOT SUSTAIN ANY INJURIES. THE POLICE WERE CONTACTED A REPORT WAS FILED. THE VEHICLE WAS LATER TOWED TO AN INDEPENDENT MECHANIC WHERE IT WAS DEEMED AS DESTROYED. THE MANUFACTURER WAS CONTACTED AND THEY OFFERED NO ASSISTANCE. THE FAILURE AND CURRENT MILEAGES WERE APPROXIMATELY 134,336. *TR

ON MULTIPLE OCCASIONS, WHEN VEHICLE IS STOPPED, WITH BRAKE DEPRESSED, THE ENGINE REVS UP AND VEHICLE WANTS TO ACCELERATE FORWARD AT A HIGH RATE OF SPEED. THE ONLY WAY TO STOP THE ACCELERATION IS TO GET THE VEHICLE TRANSITIONED IN TO PARK AND CUT THE ENGINE. THE VEHICLE HAS BEEN TO THREE DEALERS, WHOM ARE UNABLE TO DIAGNOSE AND CORRECT THE PROBLEM. FORD HAS NOT BEEN RESPONSIVE. VEHICLE IS UNSAFE TO DRIVE. *TR

TL* THE CONTACT OWNS A 2008 FORD F-350. THE CONTACT STATED THAT WHILE DRIVING 45 MPH, ANOTHER VEHICLE CRASHED INTO THE FRONT OF THE CONTACT'S VEHICLE AND THE AIR BAGS FAILED TO DEPLOY. ONCE THE VEHICLE WAS STOPPED, THE AIR BAGS THEN ERRONEOUSLY DEPLOYED. THERE WAS A POWDERY SUBSTANCE THAT WAS EMITTED FROM THE AIR BAGS, WHICH CAUSED THE CONTACT TO CHOKE AND BECOME ILL. THE CONTACT ALSO SUSTAINED INJURIES TO THE CHEST, HEART, NECK AND LOWER BACK. A POLICE REPORT WAS FILED. THE VEHICLE WAS NOT TAKEN TO THE DEALER. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE VEHICLE WAS DESTROYED. THE FAILURE AND CURRENT MILEAGE WAS 24,000.

MONDAY, JANUARY 3, 2011, WE WERE DRIVING ON A RURAL ROAD IN ROUTE TO SHARPS CHAPEL, TENNESSEE WHEN THE RIGHT SIDE FRONT PASSENGER CALIPER/ROTOR ASSEMBLY FAILED CAUSING SMOKING AND BURNING SMELL OF THE BRAKE SHOES FORCING ME TO PULL TO THE SIDE OF THE ROAD. AFTER ALLOWING THE BRAKES TO COOL, I CONTACTED AND DROVE TO MORRISTOWN FORD IN TENNESSEE AND THEY TO ATTEMPTED TO REPAIR THE BRAKES BY DISASSEMBLING AND CLEANING THE CALIPER/ROTOR SINCE THEY DID NOT HAVE THE PARTS AVAILABLE TO APPROPRIATELY RECTIFY THE SITUATION. THIS REPAIR WAS NOT EFFECTIVE AND THE PROBLEM HAS REPEATED ITSELF FOUR TIMES SINCE THEN, MOST RECENTLY ON OCTOBER 5, 2012. THIS APPEARS TO BE A VERY DANGEROUS VEHICLE DESIGN AND/OR PART FAILURE!! FORD NEEDS TO RECTIFY THIS PROBLEM!! *TR

TL* THE CONTACT OWNS A 2008 FORD F-350 SD. THE CONTACT STATED THAT WHILE ATTEMPTING TO ASCEND AN INCLINE, THE VEHICLE LOST POWER, MAKING IT EXTREMELY DIFFICULT TO ACCELERATE UPHILL. THE VEHICLE WAS TAKEN TO THE DEALER WHERE IT WAS DETERMINED THAT THE FUEL PRESSURE REGULATOR HAD FAILED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS CONTACTED ABOUT THE ISSUE. THE FAILURE MILEAGE WAS 140,000 AND THE CURRENT MILEAGE WAS 150,000.

TL* THE CONTACT OWNS A 2008 FORD F-350 SUPER DUTY. THE CONTACT STATED THAT WHEN DRIVING 55-70 MPH OVER A ROAD BUMP, THE VEHICLE WOULD SHAKE UNCONTROLLABLY. THE CONTACT HAD TO APPLY PRESSURE TO THE BRAKE PEDAL IN ORDER TO CONTROL THE VEHICLE. THE FAILURE WAS EXPERIENCED NUMEROUS TIMES. THE VEHICLE WAS TAKEN TO THE DEALER WHO TEST DROVE THE VEHICLE, BUT WAS UNABLE TO DUPLICATE THE FAILURE. THE CONTACT TOOK THE VEHICLE TO A TIRE SPECIALIST WHO PERFORMED AN ALIGNMENT AND REPLACED THE TIRES AND SHOCKS HOWEVER, THE FAILURE WAS NOT CORRECTED. THE VEHICLE CONTINUED TO SHAKE UNCONTROLLABLY WHEN DRIVING OVER A ROAD BUMP. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 29,800 AND THE CURRENT MILEAGE WAS 30,000.

FORD F350 WITH 6.4L DIESEL HAD CHECK ENGINE LIGHT (CEL) ILLUMINATE WHILE DRIVING. ENGINE IMMEDIATELY SLOWED TO IDLE (800RPM) AND WOULD NOT RESPOND TO THROTTLE INPUTS. WAS NOT ABLE TO CLEAR ROADWAY AND BLOCKED TRAFFIC ON BUSY URBAN ROAD. DEALER WAS "NOT ABLE TO FIND ANYTHING WRONG", YET "PERFORMED CALIBRATION UPDATE ON PCM". I WAS INFORMED "THIS NEEDS TO BE DONE AS VEHICLE AGES AND SENSORS WEAR." REVIEWED OWNERS MANUAL AND DID NOT LOCATED MAINTENANCE INTERVAL FOR "CALIBRATION UPDATES TO PCM." I AM CERTAIN THIS IS AN INHERENT PCM SOFTWARE CODE ERROR LEADING TO COMPLETE LOSS OF ENGINE OPERATION. A DANGEROUS SITUATION ON CONGESTED ROADWAYS. *TR

UPON INSPECTION OF THIS VEHICLE,OUR MECHANIC FOUND THE AUTOMATIC DIPSTICK TUBE RUSTED IN HALF ON THE RIGHT SIDE OF THE ENGINE. AT THE BRACKET THAT BOLTS TO THE EXHAUST MANIFOLD. WE BELIEVE THIS TO BE A POTENTIAL FIRE /SAFETY HAZARD IF SOME ONE WAS TO FILL OR CHECK THE TRANSMISSION WHILE THE ENGINE IS HOT. WE ALSO FOUND THE RIGHT SIDE SHOCK TOWER SEVERELY DEGRADED BECAUSE OF RUST. THE TOP OF THE TOWER HAS LARGE PIECES OF RUST SCALE ON TOP OF THE TOWER THAT WE FEEL COULD POSSIBLY ALLOW THE COIL SPRING PRESSURE TO FRACTURE THE STEEL AND CAUSE A LOSS OF STEERING. I HAVE NOT SEEN THIS MUCH CORROSION ON A TRUCK THIS NEW. WE HAVE TAKEN PICTURES AND CAN BE E-MAILED IF NEEDED. THIS VEHICLE HAS BEEN REMOVED FROM SERVICE UNTIL IT CAN BE REPAIRED. THIS IS A CITY OF ALLENTOWN ,PA FLEET VEHICLE. *TR

START OF MULTIPLE OCCURRENCES OF DEATH WOBBLE WITH THIS TRUCK AND NUMEROUS TRIPS TO THE FORD DEALERSHIPS WITH NO FIX. TIRES REPLACED APPROXIMATELY 28,000 MILES AT MY EXPENSE: ( WAS TOLD THIS WOULD MOST LIKELY FIX THE WOBBLE). I WAS ADVISED THE FRONT END ALIGNMENT OUT (CASTER SETTING) AND COULD NOT BE FIXED BY FORD BECAUSE THE CASTER ADJUSTERS NECESSARY TO REPAIR - NOT AVAILABLE AT THE TIME. BUT FORD ADVISED ME THE ALIGNMENT WITHOUT THE CASTER ADJUSTERS WAS STILL WITHIN FORD SPECS AND WOULD BE FINE. LAST VISIT TO THE DEALERSHIP FOR THE DEATH WOBBLE AROUND 09-19-2012, VEHICLE @ 34,090. ADVISED THE MECHANIC ATTEMPTED TO ALIGN VEHICLE WITH CASTER ADJUSTER SLEEVES; WAS UNABLE TO FIX, WRONG SLEEVES. WOULD HAVE BEEN CHARGED FOR THE REPAIR APPROX. 400.00. I WAS TOLD THAT IF I HAD THE FRONT ALIGNED CORRECTLY IT WOULD TAKE CARE OF DEATH WOBBLE. 95% SURE IT WOULD FIX. I FINALLY WENT TO LOCAL MECHANIC SHOPS. FIXED WOBBLE WITH 2 STEERING STABILIZERS @ 324.74 CHARGE. ALIGNMENT WITH CASTER SLEEVES @ 414.22 CHARGE. I AM PLANNING TO ASK FORD FOR REIMBURSEMENT BUT I DOUBT THEY WILL COMPLY. *TR