2004 FORD F-350 Complaints

TL* THE CONTACT OWNS A 2004 FORD F-350. WHILE THE VEHICLE WAS BEING SERVICED BY AN INDEPENDENT MECHANIC, IT WAS OBSERVED THAT THE DRIVER AND PASSENGER SIDE INNER ROCKER PANELS HAD SEVERE CORROSION, FAILED, AND NEEDED TO BE REPLACED. THE VEHICLE WAS REPAIRED. PRIOR TO THE FAILURE, THE CONTACT NOTICED THAT THE FRAME WAS CRACKED. THE CONTACT TOOK THE VEHICLE TO THE LOCAL DEALER (FORMULA FORD, 4318 MIDDLE RD, RUTLAND, VT, 05701) WHERE IT WAS CONFIRMED THAT THE FRAME WAS FRACTURED, BUT THEY WOULD NOT REPAIR THE VEHICLE. THE FRAME WAS REPAIRED. THE CONTACT GOT THE DEPARTMENT OF MOTOR VEHICLES INVOLVED; THEREFORE, THE DEALER PAID SOME OF THE REPAIR COST TO BE WELDED BY THE CONTACT'S INDEPENDENT PROFESSIONAL WELDER. THE MANUFACTURER WAS NOT CONTACTED. THE FAILURE MILEAGE WAS APPROXIMATELY 140,590.

WHEN GOING AROUND CURVES, HITTING SMALL BUMPS, OR STOPPING, THE FRONT END STARTS TO SHAKE VIOLENTLY. SLOWING DOWN OR STOPPING IS THE ONLY WAY TO STOP THE SHAKING. THE TRUCK HAS BEEN TAKEN TO SEVERAL REPAIR SHOPS WITH NO AVAIL. THEY CAN'T FIND ANYTHING WRONG. THIS PROBLEM IS VERY DANGEROUS. I'M GETTING SCARED TO DRIVE IT.

SPEED CONTROL DOES NOT DISENGAGE WHEN HITTING THE BRAKES. YOU MUST SLOW THE TRUCK DOWN BY SEVERAL MILES PER HOUR BEFORE THE SYSTEM WILL DISENGAGE. (PUSH HARD AND LONG). THE PROBLEM WILL GO AWAY FOR A PERIOD OF TIME IF YOU PREFORM AN EMERGENCY STOP THAT CAUSES THE ANTI-LOCK BRAKE SYSTEM TO ACTIVATE. THIS WILL CURE THE ISSUE FOR AWHILE. BUT WITH NORMAL BRAKING THE PROBLEM WILL RETURN WITH IN SEVERAL DAYS.

TL* THE CONTACT OWNS A 2004 FORD F-350. WHILE DRIVING APPROXIMATELY 20 MPH, THE VEHICLE STALLED WITHOUT WARNING. THE CONTACT COASTED THE VEHICLE TO THE SHOULDER TO A COMPLETE STOP. THE VEHICLE WAS STARTED NORMALLY, BUT STALLED AGAIN THE SAME AFTERNOON. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE VIN WAS EXCLUDED FROM NHTSA CAMPAIGN NUMBER: 05V270000 (ENGINE). THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 133,307.

WE HAVE HAD FOUR SEPARATE INCIDENTS INVOLVING UNINTENDED ACCELERATION WITH OUR 2004 FORD F350. WHEN APPLYING THE BRAKES, THE VEHICLE SUDDENLY ACCELERATES. IT HAS HAPPENED TWICE GOING DOWN OUR DRIVEWAY, ONCE WHEN DRIVING IN CITY TRAFFIC, AND ONCE WHEN WE WERE PARKING AT A REST STOP. THE VEHICLE WAS DRIVING AT LOW SPEEDS IN ALL OF THESE INSTANCES. IN THE MOST RECENT INCIDENT, THE VEHICLE SUDDENLY ACCELERATED, JUMPED THE CURB AND STRUCK A TRASH CAN AT A REST STOP. THANKFULLY NO ONE WAS IN FRONT OF OUR VEHICLE AS THEY COULD HAVE BEEN KILLED. THE VEHICLE ALSO REAR ENDED ANOTHER VEHICLE IN ANOTHER INCIDENT. THIS HAS HAPPENED THREE TIMES WHEN MY HUSBAND WAS DRIVING AND ONCE WHEN I WAS DRIVING. AFTER THE MOST RECENT INCIDENT WE GOOGLED THIS AND FOUND THERE ARE NUMEROUS CLASS ACTION LAWSUITS AGAINST FORD FOR THIS ISSUE, AND THAT OUR YEAR VEHICLE (2004) HAS ONE OF THE HIGHEST INCIDENT RATES.

TL* THE CONTACT OWNS A 2004 FORD F-350. THE CONTACT STATED THAT WHILE DRIVING AT VARIOUS SPEEDS, THE VEHICLE WOULD SUDDENLY SHUT OFF AND ON SEVERAL OCCASIONS WOULD NOT START. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC, WHO DETERMINED THAT THE FUEL INJECTION CONTROL MODULE WIRE HARNESS NEEDED TO BE REPLACED. THE CONTACT NOTIFIED THE MANUFACTURER, WHO EXPLAINED THAT THE HARNESS WAS REPLACED IN 2005 UNDER NHTSA CAMPAIGN NUMBER: 05V270000 (ELECTRICAL SYSTEM). THE FAILURE MILEAGE WAS 83,000.

TL* THE CONTACT OWNS A 2004 FORD F-350. WHILE DRIVING THE VEHICLE, IT EXPERIENCED A COMPLETE LOSS OF POWER. THE VEHICLE WAS TAKEN TO THE DEALER WHERE IT WAS DIAGNOSED THAT THE WIRING HARNESS WAS DEFECTIVE AND NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. PRIOR TO THE FAILURE, THE VEHICLE WAS REMEDIED UNDER NHTSA CAMPAIGN NUMBER: 07E066000 (EQUIPMENT). THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS APPROXIMATELY 100,000.

TL* THE CONTACT OWNS A 2004 FORD F-350 SD EQUIPPED WITH BF GOODRICH BAJA CHAMPION ALL TERRAIN (NA) TIRES, SIZE: FT285/75/R16 (NA). WHILE DRIVING 40 MPH, THERE WAS AN ABNORMALLY LOUD POPPING NOISE THAT CAME FROM THE LOWER PART OF THE VEHICLE. THE CONTACT WAS ABLE TO PULL THE VEHICLE OVER TO THE SHOULDER, WHERE IT WAS WITNESSED THAT A REFLECTOR HAD LODGED ITSELF INTO THE REAR DRIVER SIDE TIRE. THE VEHICLE WAS TAKEN TO THE DEALER WHERE IT WAS DIAGNOSED THAT THE TIRE FAILED DUE TO IT BEING PUNCTURED AND WOULD NEED TO BE REPLACED. THE TIRE WAS REPLACED. THE TIRES WERE REPLACEMENT TIRES. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE APPROXIMATE VEHICLE FAILURE MILEAGE WAS 145,006 AND THE TIRE FAILURE MILEAGE WAS 60.

BOUGHT BFG COMMERCIAL T/A TIRES FROM COSTCO LAKE ELSINORE, CA ON 05-23-2015 I WENT BACK TO COSTCO WITH A HANDLING COMPLAINT AFTER A RECENT CAMPING TRIP FIRST TIME ON THESE TIRES. WITH MY 29 FOOT TRAVEL TRAILER MY TRUCK HANDLES VERY POORLY TIRE SIDE WALLS FEEL VERY SOFT MAKES HANDLING A SERIOUS SAFETY ISSUE. TRUCK FEELS LIKE ITS WANDERING AND WHEN TRYING TO STOP THE TRAILER THE TIRES FEEL AS IF THEY ARE TRYING TO COME OF THE RIMS. MY TRUCK IS A 2004 FORD F-350 SRW TRUCK MORE THAN CAPABLE OF TOWING THIS TRAILER. THE TRUCKS MILEAGE AT THE TIME OF INSTALL WAS 154601 CURRENT MILEAGE IS 155061 SO I HAVE PUT A TOTAL OF 460 MILES ON THESE TIRES. COSTCO WOULD ONLY REBALACE AND ROTATE TIRES WITHOUT ANY OF MY SAFTEY CONCERNS ADDRESSED.

BOUGHT BFG COMMERCIAL T/A TIRES FROM COSTCO LAKE ELSINORE, CA ON 05-23-2015 I WENT BACK TO COSTCO WITH A HANDLING COMPLAINT AFTER A RECENT CAMPING TRIP FIRST TIME ON THESE TIRES. WITH MY 29 FOOT TRAVEL TRAILER MY TRUCK HANDLES VERY POORLY TIRE SIDE WALLS FEEL VERY SOFT MAKES HANDLING A SERIOUS SAFETY ISSUE. TRUCK FEELS LIKE ITS WANDERING AND WHEN TRYING TO STOP THE TRAILER THE TIRES FEEL AS IF THEY ARE TRYING TO COME OF THE RIMS. MY TRUCK IS A 2004 FORD F-350 SRW TRUCK MORE THAN CAPABLE OF TOWING THIS TRAILER. THE TRUCKS MILEAGE AT THE TIME OF INSTALL WAS 154601 CURRENT MILEAGE IS 155061 SO I HAVE PUT A TOTAL OF 460 MILES ON THESE TIRES. COSTCO WOULD ONLY REBALACE AND ROTATE TIRES WITHOUT ANY OF MY SAFTEY CONCERNS ADDRESSED.