2004 FORD F-350 Complaints

TL* THE CONTACT OWNS A 2004 FORD F-350 SD EQUIPPED WITH BF GOODRICH RUGGED TERRAIN TIRES, SIZES LT 265/75/R16. THE CONTACT STATED THAT WHILE DRIVING 72 MPH, THE REAR DRIVER'S SIDE TIRE BLEW AND CAUSED DAMAGE TO THE REAR DRIVER'S SIDE QUARTER PANEL. THE CONTACT MENTIONED THAT THE FAILURE RECURRED TWICE BEFORE THE MOST RECENT FAILURE. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC, WHO WAS UNABLE TO DETERMINE THE CAUSE OF THE FAILURE. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE TIRES WERE REPLACED. THE TIRE FAILURE MILEAGE WAS 20,000 AND THE VEHICLE FAILURE MILEAGE WAS 332,000. THE CURRENT MILEAGE WAS 347,000. UPDATED 12/30/13*CN

TL* THE CONTACT OWNS A 2004 FORD F-350 SD. THE CONTACT STATED THAT WHILE TRAVELING VARIOUS SPEEDS, WHITE SMOKE EMITTED FROM THE TAIL PIPE AT AN ALARMING RATE AND ACCELERATION POWER WAS LOST. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS CONTACTED ABOUT THE FAILURE AND INFORMED THE CONTACT THAT THE VEHICLE WAS NOT INCLUDED IN THE MANUFACTURER'S RECALL. THE FAILURE MILEAGE WAS 150,000.

TL* THE CONTACT OWNS A 2004 FORD F-350 SD. THE CONTACT STATED THAT WHILE DRIVING 65 MPH, THE VEHICLE BEGAN TO EMIT HEAVY AMOUNTS OF SMOKE. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC FOR DIAGNOSIS AND THE CONTACT WAS INFORMED THAT TWO FUEL INJECTORS, TWO OIL COOLERS, AND THE EGR VALVE WOULD NEED TO BE REPLACED. THE VEHICLE WAS REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 150,000 AND THE CURRENT MILEAGE WAS 157,000.

TL* THE CONTACT OWNS A 2004 FORD F-350. THE CONTACT STATED THAT THE VEHICLE STALLED WITHOUT WARNING WHILE DRIVING 65 MPH. THE VEHICLE WAS TOWED TO THE CONTACT'S RESIDENCE WHERE AN INDEPENDENT MECHANIC PERFORMED A DIAGNOSTIC. THE FAILURE WAS LOCATED AT THE FUEL INJECTION PRESSURE SENSOR. THE MANUFACTURER WAS CONTACTED AND ADVISED THAT THE VIN WAS NOT INCLUDED IN NHTSA CAMPAIGN NUMBER 05V270000 (ELECTRICAL SYSTEM). THE VEHICLE WAS NOT REPAIRED. THE APPROXIMATE FAILURE AND CURRENT MILEAGE WAS 85,000.

I WAS LEAVING MY HOME WITH MY TRAVEL TRAILER FOR VACATION. I MADE IT TO THE FIRST TRAFFIC LIGHT AND HAD GREAT DIFFICULTY STOPPING THE VEHICLE. THE BRAKE PEDAL WENT STRAIGHT TO THE FLOOR, I NEEDED TO USE THE TRAILER BRAKES TO STOP. AFTER DRIVING VERY SLOWLY HOME I DIAGNOSED THE PROBLEM AS A FAULTY BRAKE LINE. THIS WAS NOT AN ORDINARY TYPE LINE, THIS WAS A STAINLESS STEEL LINE THAT HAD SOME TYPE OF SEALING DEVICE IN THE ENDS THAT FAILED. THERE ARE TWO MORE OF THE SAME TYPE LINES ON THE VEHICLE. I HAVE GREAT CONCERN THAT IF ONE OF THESE LINES FAILED WILL THE OTHER TWO FAIL? THIS COULD HAVE BEEN A HORRIFIC ACCIDENT HAD I NOT BEEN ABLE TO USE TRAILER BRAKES TO STOP THE VEHICLE. *TR

TL* THE CONTACT OWNS A 2004 FORD F350. THE CONTACT STATED THAT WHILE DRIVING 55 MPH, THE VEHICLE STALLED WITHOUT WARNING. THE VEHICLE WAS TOWED TO AN INDEPENDENT MECHANIC FOR DIAGNOSIS WHERE IT WAS STATED THAT THE FUEL INJECTION CONTROL MODULE NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE APPROXIMATE FAILURE MILEAGE WAS 74,000. *TR

I WAS DRIVING DOWN THE INTERSTATE WITH MY 2004 F-350 DUALLY WITH MY DUMP TRAILER ON THE BACK. I WAS HEADED DOWN A SLIGHT HILL WHEN THE STEERING WHEEL STARTED TO SHAKE. THE FRONT WHEELS STARTED TO MOVE BACK AND FORTH FROM LEFT TO RIGHT AND RIGHT TO LEFT VERY FAST BUT IN SHORT STROKES. THE SHAKING AND THE STROKES BEGAN TO GET LONGER SO THE WHEELS WERE TURNING MORE AND MORE EACH TIME THE WHEELS TURNED BACK AND FORTH.. THE SHAFT THAT COMES OF OF THE STEERING BOX THAT GOES TO THE PITMAN ARM SHEARED IN HALF. THIS CAUSED ME TO LOOSE CONTROL OF THE TRUCK BECAUSE I HAD NO STEERING. WHEN I HIT THE BRAKES THE WHEELS LOCKED COMPLETELY RIGHT, CAUSING ME TO GO OFF THE HIGHWAY, I HIT A BANK ON THE SIDE OF THE HIGHWAY HEAD ON, THEN THE TRAILER PULLED ME AROUND 180 DEGREES AND I ROLLED THE TRUCK AND TRAILER. *TR

TL* THE CONTACT OWNS A 2004 FORD F-350. THE CONTACT STATED THAT WHILE DRIVING APPROXIMATELY 35 MPH, THE ENGINE REDUCED POWER WITHOUT WARNING. THE VEHICLE WAS TAKEN TO THE DEALER FOR DIAGNOSIS. THE TECHNICIAN STATED THAT THE FUEL INJECTORS WOULD HAVE TO BE REPLACED. THE VEHICLE WAS REPAIRED HOWEVER, THE FAILURE RECURRED. THE VEHICLE WAS NOT FURTHER REPAIRED. THE APPROXIMATE FAILURE MILEAGE WAS 235,000.

ENGINE BEGAN BUCKING, SUDDEN POWER LOSS AND POWER STEERING AND POWER BRAKE LOSS. MECHANIC CONCLUSION WAS THAT THE LINING OF THE FUEL TANK HAD DISLODGED AND CAUSED THE ENGINE TO FOUL, CAUSING A SUDDEN POWER LOSS. DEALER SAID THEY HAD NEVER HEARD OF THE PROBLEM BUT WE LATER LEARNED THEY WERE VERY FAMILIAR WITH IT, HAD DONE DOZENS OF REPAIRS (REPLACEMENT OF TANK WITH POLY TANK) AND THAT A "SECRET" REPAIR BULLETIN HAD BEEN ISSUED TY FORD TO ALL DEALERS. THIS ISSUE IS NOW THE SUBJECT OF A CLASS ACTION LAWSUIT IN NEW JERSEY. GOOGLE "FORD FUEL TANK LINING" FOR MORE INFO ON THE SUIT, BUT BY NOT ISSUING A RECALL THIS ISSUE IS A POTENTIAL SAFETY CONCERN. HAD WE BEEN IN HEAVIER TRAFFIC AND UNABLE TO GET THE VEHICLE TO THE SIDE OF THE ROAD THERE MAY HAVE BEEN A SERIOUS ACCIDENT. *TR

TL* THE CONTACT OWNS A 2004 FORD F-350 SUPER DUTY. THE CONTACT STATED THAT THE VEHICLE STALLED WITHOUT WARNING. THE VEHICLE WAS TAKEN TO THE DEALER AND WAS TOLD THAT THE FUEL INJECTION CONTROL MODULE WIRING HARNESS NEEDED TO BE REPLACED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE WHO DID NOT OFFER ANY ASSISTANCE SINCE THE VEHICLE WAS NOT INCLUDED IN NHTSA RECALL CAMPAIGN ID NUMBER: 05V270000 (ELECTRICAL SYSTEM: WIRING). THE FAILURE MILEAGE AND CURRENT MILEAGE WAS 140,000.