2000 FORD F-350 SD Complaints

BOTH REAR INSIDE TIRES WENT FLAT AT THE SAME TIME. THE RIGHT TIRE HAD APPROX. 5390 MILES ON IT SINCE IT WAS THE SPARE FROM AN EARLIER BLOWOUT. THE LEFT TIRE HAD APPROX. 22875 MILES ON IT. I HAVE NOT FILED THIS WITH THE TIRE COMPANY DUE TO THEIR TREATMENT FROM THE FIRST FAILURE. I WAS TOWING A FIFTH WHEEL RV TRAILER AT THE TIME OF THE INCIDENT.*JB

INSIDE REAR DUAL TIRE BLEW OUT WHILE DRIVING CAUSING DAMAGE TO THE FENDER, LINER AND MUD FLAP. COMPANY STATED TIRE HAD BEEN RUN FLAT. I DON'T THINK IT WOULD HAVE BLOWN IF IT WAS FLAT. I ALSO HAD TWO MORE TIRES GO OUT IN JULY OF 2002 (I WILL FILE ON IT ALSO).

CLUTCH RELEASE BEARING (THROW OUT BEARING) ACTUATOR ARM FAILURE RESULTING IN MOVEMENT OF VEHICLE WHILE CLUTCH PEDAL IS DEPRESSED THIS IS THE SECOND FAILURE OF THE SUBJECT PART IN THE LIFE OF THIS SERIAL NUMBER TRUCK. THE FIRST OCCURRED AT APX. 37,000 MILES; THE SECOND AT APX. 95,000 MILES. BOTH REPAIRS WERE COMPLETED USING OEM PARTS. I AM IN POSSESSION OF THE SECOND FAILED PART AND WILL MAKE IT AVAILABLE FOR INSPECTION UPON REQUEST. THIS FAILURE IS A MAJOR SAFETY ISSUE AS THE POWER TRAIN CAN NOT BE INTERRUPTED BY NORMAL MEANS. THAT IS, ONE NORMALLY DEPRESSES THE CLUTCH PEDAL TO INTERRUPT POWER TRANSMISSION AND APPLIES BRAKE ACTION TO STOP THE VEHICLE. WHEN THE SUBJECT ARM FAILS, ONE DEPRESSES THE CLUTCH PEDAL AND THE VEHICLE CONTINUES MOVEMENT, CAUSING AN INHERENT REACTION DELAY TO ASSES THE ABNORMALITY, SUBSEQUENTLY FOLLOWED BY APPLICATION OF BRAKE PRESSURE TO STOP THE VEHICLE, CAUSING A SIGNIFICANT BIND IN THE TRANSMISSION, RESULTING IN THE INABILITY TO MOVE THE TRANSMISSION SHIFTER OUT OF GEAR, THEN ONE MUST EITHER TURN OFF THE IGNITION OR APPLY BRAKE PRESSURE OF SUFFICIENT FORCE TO STALL THE ENGINE; ALL OF WHICH HAS CONSUMED AND EXCEEDED A REASONABLY PLANNED STOPPING DISTANCE. THE RESULTING DELAY MAY RESULT IN INJURY OR DEATH OF BY STANDERS, SHOULD THEY BE PINCHED BETWEEN THE FAILURE VEHICLE AND A STATIONARY OBJECT. THE OPERATING NATURE OF A TRUCK OF THIS DESIGN INCREASES THE RISK OF INJURY OR DEATH, FOLLOWING THE DESCRIBED FAILURE. THE MANUFACTURER MARKETS THIS TRUCK TO COMMERCIAL OPERATORS AND ONE WILL ROUTINELY FIND THE VEHICLE EMPLOYED ON WORK SITES AND SIMILARLY CONGESTED AREAS. THIS FAILURE LEAVES THE TRUSTING AND CAPABLE OPERATORS OF THIS VEHICLE AND UNSUSPECTING BY-STANDERS AT RISK OF INJURY OR DEATH; WHILE AT PLAY OR ON THE WORK PLACE.

COLD MORNING STARTS, ENG: 7.3DIESEL. PROBLEM STARTED AROUND DEC. 31,2001. ON FIRST START ENG. IS SLOW TO START, WHEN IT DOES START IT GOES FROM 300RPM TO 1200RPM ABOUT THREE TIMES AND THEN SETTLES DOWN ON 800RPM'S AND RUNS OK. THE VEH. HAS BEEN IN APPROX. 4 OR 5 TIMES FOR THIS PROBLEM. THE DEALER SHOWS THE VEH, HAS BEEN IN TWICE FOR THIS PROBLEM. I HAVE TALKED WITH OTHER FORD TRUCK OWNERS WITH A 7,3 DIESEL ENG. AND NO ONE HAS HAD THIS PROBLEM. THE DEALER TELLS ME THAT THIS IS NORMAL FOR THE 7.3DI IN COLD WEATHER. QUESTION: IF THIS IS NORMAL WHY DID IT TAKE ALMOST A YEAR FOR THIS TO START. OTHER PROBLEMS: 1. AARM REMAN INJ PKG #8 CYL REPLACED. 2. WARPED ROTORS (FRONT), WARPED PADS HEAT CRACKED, CALIPERS REPLACED. 3. 50 MILES ON TRUCK, TRUCK PULLED TO THE RIGHT ALL THE TIME, TOOK INTO DEALER 4 TIMES, (CARSON CITY), DEALER IN FALLON CAME TO MY HOUSE TOOK THE VEH. TO FALLON & FIXED PULLING PROBLEM. 4. POWERTRAIN CONTROL MODULE (PCM) REPLACED. 5. EGR PRESSURE FEEDBACK-PFE/EXHAUST BACK PRESSURE -EBP-REPLACED. 6. DEALER INSTALLED FUEL HEATER KIT , SOP TOP WATER FUEL HEATER. ( ALL OF THIS & THIS DIESEL STILL GOES FROM 300RPM TO 1200RPM). I TALKED TO A DIESEL SHOP IN RENO, NV. AND HE SAID THERE IS SOMETHING WRONG WITH THIS DIESEL. I HATE TO THINK WHAT THIS IS DOING TO THE INTERNAL PARTS OF THIS ENG. I WOULD THINK THAT THE BEARINGS AT 300RPM ARE GETTING VERY LITTLE OIL PRESSURE. ( HOW EVER THE DEALER SAID THIS IS NORMAL AND THAT I SHOULD PLUG IN THE ENG. HEATER. QUESTION: HOW DO YOU PLUG IN WHEN YOU ARE ON VACATION OR OUT FISHING WHICH I DO ALOT.

THE FRONT WHEEL ROTORS WARPED AND HAD TO BE RE-SURFACED AT 22,000 MILES. THE DEALER TURNED THE ROTORS AND INSTALLED NEW FRONT BRAKE PADS. AT 32,000 MILES THE FRONT ROTORS WERE WARPED AGAIN. WHEEL VIBRATION COULD BE FELT IN THE BRAKE PEDAL AND FRONT END ON HARD BRAKING WHILE GOING DOWN STEEP HILLS. THE DEALER SAID THAT THE WARPING WAS CAUSED BY EXCESSIVE HEAT. AT 32,000 AND 38,000 MILES THEY SAID THAT BRAKES ARE NOT COVERED UNDER WARRANTY AND THEY WOULD NOT CORRECT THE PROBLEM. THE RECOMMENED HAVING THE ROTORS TURNED AND INSTALLING "COMPOSITE/METALLIC" BRAKE PADS. THEY STATED THAT THE FACTORY BRAKE PADS ARE TOO HARD FOR THE ROTORS. THE BRAKE PADS HAVE SHOWN LITTLE WEAR. THERE IS AN EXHAUST BRAKE ON THE VEHICLE AND THE BRAKES HAVE BEEN USED SPARINGLY. I FEEL THAT THERE IS AN ENGINEERING PROBLEM WITH THE FRONT BRAKE SYSTEM. DT

THE STEERING BOX BROKE CAUSING INSURED TO LOSE CONTROL RUNNING OFF THE ROAD AND INTO A DITCH, CLAIM 03-3137-171. *JG

WHILE IN MOTION, INSURED ATTEMPTED TO CHANGE LANES WHEN THE STEERING WENT OUT, CAUSING INSURED TO STRIKE ANOTHER VEHICLE IN THE REAR, RIGHT FRONT WHEEL HAD BEEN PUSHED BACK CAUSING SECTOR SHAFT TO BREAK, CLAIM 31-3069-892. *JG

CLAIM NUMBER 59-V709-810 - CONSUMER STATES THAT THE STEERING ARM SHEARED FROM THE STEERING BOX, FORD STATED THIS WAS ACCIDENT RELATED, UNABLE TO FIND CONTACT ON STEERING ARM, NO CONTACT AROUND STEERING LINKAGE OR SPRING, CONTACT WAS MADE ON LEFT FRONT OF BUMPER BAR. *TT

CLAIM NUMBER 11-3548-745 - WHILE IN STOP AND GO TRAFFIC IN THE FAR RIGHT LANE, VEHICLE 1 WAS TRAVELING IMMEDIATELY BEHIND VEHICLE 2, AS VEHICLE 2 STOPPED FOR TRAFFIC, VEHICLE 1 ATTEMPTED TO CHANGE LANES, WHEN SUDDENLY THE STEERING WOULD NOT RESPOND, CAUSING VEHICLE 1 TO COLLIDE WITH REAR RIGHT SIDE OF VEHICLE 2, INJURIES WERE A RESULT OF IMPACT. *TT

STEERING ON MY TRUCK WAS FINE FOR THE FIFST 35,000 MILES AND THEN LOST ALL POWER STEERING WHEN STOPPED WITH FOOT ON BRAKE OR OFF THE BRAKE. I TOOK THE TRUCK IN TO THE FORD DEALOR AND WAS TOLD THIS IS A NORMAL WAY FOR THIS SYSTEM TO WORK AND LIVE WITH IT,I CALLED FORD MOTER COMPANY AND THEY SAID THE SAME THING. I FEEL THIS IS A SAFTEY PROBLEM AS WHEN OFF ROAD YOU CANT GET THE TRUCK TO TURN IF THERE IS ADVERSE WEATHER CONDITIONS AND YOU MUST TRY TO TURN AT LOW SPEED OR NO SPEED. IF IT IS ICY ON THE ROAD OR EVEN ON DRY PAVEMENT IF YOU APPLY THE BRAKES AND TRY TO STEAR OUT OF A SKID SAY TO AVOID A CRASH YOU CANT GET THE TRUCK TO TURN DUE TO YOUR FOOT ON THE BRAKE.YOU CANT TURN IN SHOPPING CENTER PARKING LOTS TO GET INTO PARKING SPACES DUE TO THE STEERING PROBLEM. AND SHAME ON FORD FOR SELLING THESE TRUCKS THAT THEY KNOW HAVE THIS SITUATION (BULLITON 15446) AND NOT TELLING THE CONSUMER THAT THIS IS A PROBLEM WITH THESUPER DUTY F-SERIES AND THE EXCURSION AND LEADING YOU TO BELIEVE THAT THE TRUCK WILL FUNCTION AS WEEL AT 5 MILES AS IT WILL AT 40,000 MILES. THEY SHOULD BE MADE TO FIX THIS PROBLEM AND TO DISCLOSE THE FACTORY BULLITON 15446 TO ALL CONSUMERS LOOKING AT THERE PRODUCT AS IT AFFECTS THE DRIVE ABILITY AND RESALE VALUE OF THE TRUCK. *AK