2004 FORD F-350 SD Complaints

TL*THE CONTACT OWNS A 2004 FORD F-350 SUPERDUTY. THE CONTACT STATED THAT WHILE DRIVING, THE CHECK ENGINE LIGHT ILLUMINATED. THE VEHICLE WAS TAKEN TO AN AUTHORIZED DEALER WHO STATED THAT THE HEAD GASKET WAS DEFECTIVE. THE DEALER STATED THAT THE STUD PACKAGE NEEDED TO BE REPLACED FOR A PERMANENT FIX. THE VEHICLE HAD NOT BEEN REPAIRED. THE MANUFACTURER OFFERED NO ASSISTANCE WHEN CONTACTED. THE CURRENT AND FAILURE MILEAGES WERE 81,300 UPDATED 04/29/11

2004 FORD F350 TRUCK. CONSUMER STATES DEFECTIVE EGR VALVE BEING REPLACED SEVERAL TIMES.*TGW THE CONSUMER STATED HE HAS BEEN TO THE DEALER 10 TIMES DUE TO NUMEROUS CHECK ENGINE LIGHT ISSUES. THE ENGINE IDLED FAST. THE DEALER STATED IT WAS NORMAL AS THE VEHICLE HAD A HYDRO-BOOST.*JB

TL*THE CONTACT OWNS A 2004 FORD F350. WHILE THE VEHICLE WAS PARKED THE CONTACT TURNED THE KEY IN THE IGNITION AND THE VEHICLE WOULD NOT START. THE VEHICLE WAS TOWED TO THE DEALER. THE TECHNICIANS STATED THAT THE FUEL INJECTION CONTROL MODULE NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER STATED THAT THERE WAS A RECALL ON THE 2004 FORD F450 FOR THE SAME FAILURE BUT NOT FOR THE F350. THE APPROXIMATE FAILURE MILEAGE WAS 178,000.

TL* THE CONTACT OWNS A 2004 FORD F-350 SUPER DUTY. THE CONTACT STATED THAT WHILE DRIVING 60 MPH, THE VEHICLE STALLED WITHOUT WARNING. THE CONTACT STATED THAT THE FAILURE WOULD OCCUR EVERY TIME THE CONTACT DROVE THE VEHICLE. THE CONTACT TOOK THE VEHICLE TO THE DEALER TO HAVE A FULL EGR VALVE REPAIR, FUEL INJECTOR REPAIR, AND A TURBO CHARGER REPAIR. NONE OF THE REPAIRS REMEDIED THE STALLING OF THE VEHICLE. THE CONTACT STATED THAT NEITHER THE DEALER NOR THE MANUFACTURER WAS ABLE TO SOLVE THE STALLING ISSUE. THE CONTACT STATED THE FAILURE WAS A SAFETY HAZARD THAT THE MANUFACTURER NEEDED TO ADDRESS. THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS 76,000. UPDATED 02/22/11

TL*THE CONTACT OWNS A 2004 FORD F350 SUPER DUTY. WHILE DRIVING AT ANY SPEED, THE CONTACT STATED THAT THE VEHICLE WOULD HESITATE, SHUT OFF AND THEN LOOSE POWER INTERMITTENTLY SIMILAR TO NHTSA CAMPAIGN ID NUMBER : 05V270000 ( ELECTRICAL SYSTEM:WIRING). THE VEHICLE WAS TAKEN TO THE DEALER WHERE THEY PERFORMED A DIAGNOSTIC TEST WHICH CONFIRMED THAT THE WIRING HARNESS NEEDED TO BE REPLACED AS WELL AS THE INJECTION CONTROL PRESSURE SENSOR. THE MANUFACTURER WAS NOTIFIED WHO ADVISED THE CONTACT THAT HIS VIN WAS NOT COVERED UNDER THIS RECALL. THE VEHICLE WAS NOT REPAIRED. THE CURRENT MILEAGE WAS APPROXIMATELY 71,000. THE FAILURE MILEAGE WAS APPROXIMATELY 62,000.

2004 FORD F3500 6.0 L DIESEL IN LAST YEAR 4 MONTHS HAVE HAD ENGINE AN FUEL INJECTED PROBLEMS HAD IN SHOP 5 TIMES PICKUP STALLS OUT DIES IN INTERSECTIONS RUNS ROUGH SOMETIMES LOTS OF WHITE SMOKE BAD FUEL MILEAGE THEY FIX IT PROBLEM COMES BACK HAVE COMPLAINED BUT NO ONE SEAMS TO CARE NEED HELP! *TR

TL*THE CONTACT OWNS A 2004 FORD F350. THE CONTACT STATED THAT THE VEHICLE STALLED, LUNGED FORWARD AND THE RPM'S INCREASED. WHEN THE ENGINE STALLED THE POWER STEERING FAILED AND HE HAD NO CONTROL OVER THE STEERING FUNCTION. FORD WAS NOTIFIED AND STATED THAT THEY WOULD CONTACT THE DEALER NEAREST TO HIM AND DISCUSS IT WITH THEM. THE VEHICLE WAS NOT REPAIRED. THE FAILURE STARTED ABOUT ONE YEAR AGO AND HAD BECOME PROGRESSIVELY WORSE. THE FAILURE MILEAGE WAS APPROXIMATELY 83,000. THE CURRENT MILEAGE WAS 95,000.

TL*THE CONTACT OWNS A 2004 FORD F-350 SUPERDUTY. THE CONTACT STATED THAT THE NOZZLE ON THE FUEL INJECTOR SEPARATED FROM THE BODY OF THE INJECTOR WHICH CAUSED PROGRESSIVE ENGINE DAMAGE. THE CONTACT NOTICED THE FAILURE WHEN THE VEHICLE BEGAN EMITTING BLACK SMOKE AND "RUNNING ROUGH". THE VEHICLE WAS TAKEN TO AN AUTHORIZED DEALERSHIP WHERE THE CONTACT WAS INFORMED THAT THE ENGINE NEEDED TO BE REPLACED. ANOTHER DEALER INSTALLED THE NEW ENGINE WHICH WAS ALSO DEFECTIVE AND HAD TO BE REPLACED DUE TO OIL MIXING WITH THE ANTIFREEZE. THE CONTACT CALLED THE MANUFACTURER WHO OFFERED NO ASSISTANCE. THE CURRENT MILEAGE WAS APPROXIMATELY 115,800. THE FAILURE MILEAGE WAS APPROXIMATELY 115,000. UPDATED 01/11/2011*LJ UPDATED 02/23/11

TL* THE CONTACT OWNS A 2004 FORD F350 SUPER DUTY. THE CONTACT STATED THAT THE HEAD-GASKET FAILED AND WOULD CAUSE THE ENGINE TO LOSE WATER. THE VEHICLE WAS RE[PAIRED AT A COST OF $3000 THE MANUFACTURER WAS NOT CONTACTED. THE FAILURE WAS 144,000. UPDATED 12/29/10 *BF UPDATED 04/0/611

2004 F350 SUPERDUTY 6.0 DIESEL 110025 MILES ON TRUCK. THE VEHICLE WILL SOME TIME SPUTTER ONE TO THREE TIMES AND THE ENGINE SHUTS OFF SOMETIME STARTING, SOMETIMES FAILING TO START. WHILE DRIVING AT TIMES THE ENGINE WILL JUST SHUT OFF SOMETIMES WILL RESTART SOMETIMES IT WILL NOT. I HAVE HAD IT IN TO A DEALERSHIP SHOP TO BE FIXED AND THEY CAN NOT AT THIS TIME FIND AN ANSWER. I FEEL THIS MIGHT BE SIMILAR TO A RECALL NOTICE FOR OTHER TRUCK OF THIS SORT, BUT MY VEHICLE VIN NUMBER DOES NOT FOLLOW UNDER THIS ACCORDING TO THE DEALERSHIP. THE NHTSA CAMPAIGN NUMBER THAT HAS SIMILAR PROBLEM IS 05V270000. THERE HAS NOT BEEN ANY INJURIES OR DAMAGE YET, BUT A VEHICLE THAT JUST SHUTS OFF WHEN DRIVING DOES NOT FEEL SAFE TO ME. I HAVE ONLY OWED IT SINCE 6 AUG 10 AND NO PROBLEM OF THIS SORT HAS BEEN DOCUMENTED AS REPORTED ON THIS VEHICLE. THIS VEHICLE HAS ACTED UP EVER DAY EXCEPT ONE DAY FROM THE PERIOD OF 6 AUG10 TO 12 AUG 10. *TR